NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
614 reports52,000 miles · Aug 21, 2013
Electrical SystemFire
WHILE DRIVING DOWN THE ROAD IN THE VAN WITH 7 ELDERLY PEOPLE IT CAUGHT ON FIRE AND SMOKE CAME INTO THE CABIN VIA A/C VENTS. I PULLED OVER AND ALL 7 OF US SCRAMBLED TO GET OUT OF THE VAN. FIRE WAS POURING OUT FROM UNDERNEATH AND BLACK SMOKE OUT OF THE HOOD. WITHIN ABOUT 20 SECONDS AFTER WE GOT OUT, THE VAN WAS FULLY ENGULFED I…
Read full complaint
WHILE DRIVING DOWN THE ROAD IN THE VAN WITH 7 ELDERLY PEOPLE IT CAUGHT ON FIRE AND SMOKE CAME INTO THE CABIN VIA A/C VENTS. I PULLED OVER AND ALL 7 OF US SCRAMBLED TO GET OUT OF THE VAN. FIRE WAS POURING OUT FROM UNDERNEATH AND BLACK SMOKE OUT OF THE HOOD. WITHIN ABOUT 20 SECONDS AFTER WE GOT OUT, THE VAN WAS FULLY ENGULFED IN FIRE. THE VAN WAS TOTALLY DESTROYED AND ONLY THE METAL FRAME WAS LEFT. THE FIRE INVESTIGATOR HIRED BY MY INSURANCE COMPANY BELIEVES THE FIRE STARTED IN THE ECM. THERE WERE NO WARNINGS AT ALL EXCEPT THE SMOKE IN THE CABIN AND FROM UNDER THE HOOD. WE WERE EXTREMELY LUCKY TO GET OUT ALIVE AS WE ARE ALL OVER 75 YRS OLD AND NOT ALL OF US IN GREAT HEALTH. THE VAN IS A TOTAL LOSS AND MY TOYOTA IS AWARE OF THE EVENT AND A CLAIM NUMBER ASSIGNED TO US. *TR
NHTSA ODI #10536494
21,000 miles · Aug 20, 2013
Tires
THE TIRES ON MY VAN HAVE EXCESSIVE WEAR AND NEED TO BE REPLACED AFTER ONLY 20,000 MILES. I INSTALLED A HITCH ON THE CAR MYSELF SHORTLY AFTER PURCHASING THE VEHICLE AND USED IT TO TOW. I RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA FOR MY 2011 SIENNA AWD MINIVAN THAT READS "THE TIRE AND LOADING INFORMATION PLACARD DOES NOT STATE…
Read full complaint
THE TIRES ON MY VAN HAVE EXCESSIVE WEAR AND NEED TO BE REPLACED AFTER ONLY 20,000 MILES. I INSTALLED A HITCH ON THE CAR MYSELF SHORTLY AFTER PURCHASING THE VEHICLE AND USED IT TO TOW. I RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA FOR MY 2011 SIENNA AWD MINIVAN THAT READS "THE TIRE AND LOADING INFORMATION PLACARD DOES NOT STATE THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS. INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE, INCREASING THE RISK OF A CRASH." IT GOES ON TO SAY "BASED UPON THIS INFORMATION TOYOTA HAS DETERMINED THAT THE FOLLOWING ACTIONS WILL BRING YOUR VEHICLE INTO COMPLIANCE WITH THE APPLICABLE REQUIREMENTS: REPLACEMENT OF THE FACTORY INSTALLED TIRES WITH NEW EXTRA LOAD TIRES." IT ALSO SAYS "...THE DEALER WILL REPLACE THE TIRES AND LABEL/PLACARD NOTED ABOVE AT NO CHARGE TO YOU." I SPENT OVER 90 MINUTES AT THE DEALER AND 20 MINUTES ON THE PHONE WITH TOYOTA. THEY REFUSED TO HONOR THEIR RECALL BECAUSE THE HITCH ON THE CAR WAS AN AFTER-MARKET HITCH AND NOT INSTALLED BY TOYOTA. I FAIL TO UNDERSTAND WHY THEY ARE NOT HONORING THEIR RECALL AND THEIR OFFER TO REPLACE THE TIRES SIMPLY BECAUSE THE HITCH WAS NOT PURCHASED THROUGH TOYOTA. *TR
NHTSA ODI #10536313
40,100 miles · Aug 13, 2013
Air Bags
THE AIR BAG WARNING LIGHT CAME ON. I TOOK IT TO THE DEALER. THEY SAID THE AIRBAG DOESN'T NOT WORK NOW AND THEY ARE BLAMING IN ON A WIRING ISSUE, NOT AN AIR BAG ISSUE. THEY WANT ME TO PAY $220 TO INSTALL A NEW SPIRAL CABLE, BUT GIVE ME THE PART FOR FREE. THIS DOESN'T MAKE SENSE. THE TOYOTA TACOMA TRUCKS HAD THE SAME ISSUE AND…
Read full complaint
THE AIR BAG WARNING LIGHT CAME ON. I TOOK IT TO THE DEALER. THEY SAID THE AIRBAG DOESN'T NOT WORK NOW AND THEY ARE BLAMING IN ON A WIRING ISSUE, NOT AN AIR BAG ISSUE. THEY WANT ME TO PAY $220 TO INSTALL A NEW SPIRAL CABLE, BUT GIVE ME THE PART FOR FREE. THIS DOESN'T MAKE SENSE. THE TOYOTA TACOMA TRUCKS HAD THE SAME ISSUE AND THEY HAD A RECALL. *TR
NHTSA ODI #10535208
Mileage unknown · Aug 2, 2013
StructureUnknown Or Other
(TOYOTA, SIENNA 2011) PASSENGER AUTOMATIC SLIDING DOOR ANTI-JAM SENSOR FAILED. OBJECT (MACBOOK) WAS PLACED IN DOOR POCKET COMPARTMENT. DOOR SWITCH WAS PRESSED AND DOOR BEGAN OPENING. MACBOOK DID NOT COMPLETELY CLEAR THE DOORS PATH COMPLETELY AND DOOR BEGAN CRUSHING IT. I COULD HEAR SOMETHING WASN'T RIGHT AND SAW THE DOOR BEND T…
Read full complaint
(TOYOTA, SIENNA 2011) PASSENGER AUTOMATIC SLIDING DOOR ANTI-JAM SENSOR FAILED. OBJECT (MACBOOK) WAS PLACED IN DOOR POCKET COMPARTMENT. DOOR SWITCH WAS PRESSED AND DOOR BEGAN OPENING. MACBOOK DID NOT COMPLETELY CLEAR THE DOORS PATH COMPLETELY AND DOOR BEGAN CRUSHING IT. I COULD HEAR SOMETHING WASN'T RIGHT AND SAW THE DOOR BEND THE LAPTOP AND PARK IN THE FULLY OPEN POSITION. YOU COULD CLEARLY SEE AND HEAR THE DOOR HAD MET AN OBSTACLE AND WAS STRUGGLING, BUT JUST PRESSED THROUGH IT. DOOR MADE NO ATTEMPT TO STOP OR REVERSE. THE MACBOOK WAS DAMAGED. THE WHOLE MACHINE WAS BENT BY THE DOOR AND I CAN NO LONGER FIT A CD IN THE OPTICAL SLOT BECAUSE IT IS NOW CURVED RATHER THAN FLAT. THESE DOORS ARE STRONG ENOUGH BE BEND METAL! THE "ANTI-JAM" SYSTEM FAILED. AFTER SEEING THAT, I REALLY THINK THAT THESE DOORS HAVE TO CAPABILITY TO SERIOUSLY INURE SOMEONE.
NHTSA ODI #10533323
24,000 miles · Jul 22, 2013
Electrical SystemFire
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE DOOR CAUGHT ON FIRE. THE FIRE SPREAD TO THE FUEL TANK AND FLAMES QUICKLY ENGULFED THE VEHICLE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT INSPECTED. IN ADDITION, THE CONTACT STATED T…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE DOOR CAUGHT ON FIRE. THE FIRE SPREAD TO THE FUEL TANK AND FLAMES QUICKLY ENGULFED THE VEHICLE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT INSPECTED. IN ADDITION, THE CONTACT STATED THAT THE SECURITY SYSTEM WOULD SPORADICALLY SOUND PRIOR TO THE FIRE INCIDENT. THE VEHICLE WAS NOT INSPECTED TOO DETERMINE THE CAUSE OF THE FIRE. THE FAILURE AND THE CURRENT MILEAGE WAS 24,000. *TR
NHTSA ODI #10526063
7,802 miles · Jul 12, 2013
Service Brakes
WHEN I HIT THE BRAKES AROUND 60 MPH I FELT THAT THE FRONT WHEELS WAS SHAKEN, VIBRATES AND FELT ROUGH AT THE STEERING WHEEL AND BRAKE PEDAL. I TOOK IT TO THE DEALER AND THEY SAID THAT THE ROTORS WERE RUSTY AND WARP BECAUSE THE HEAT. THEY CUT THE ROTORS. NO CHARGE. NOW, I HAD THE SAME PROBLEM WITH 23000 MILES. SAME EXCUSE. THE R…
Read full complaint
WHEN I HIT THE BRAKES AROUND 60 MPH I FELT THAT THE FRONT WHEELS WAS SHAKEN, VIBRATES AND FELT ROUGH AT THE STEERING WHEEL AND BRAKE PEDAL. I TOOK IT TO THE DEALER AND THEY SAID THAT THE ROTORS WERE RUSTY AND WARP BECAUSE THE HEAT. THEY CUT THE ROTORS. NO CHARGE. NOW, I HAD THE SAME PROBLEM WITH 23000 MILES. SAME EXCUSE. THE ROTORS WERE RUSTY AND WARP AND THEY SAID THEY HAVE TO BE CUT AND TO REPLACE THE PADS. ALSO, THEY SAID THAT THE BRAKE FLUID NEEDED TO BE CHANGE. $559.00 WAS THE CHARGE. I HAD NO CHOICE. MY LIFE DEPENDS ON THE BRAKE. MY COMPLAINT IS THAT THERE IS A FACTORY DEFECT WITH THESE ROTORS AND THE BRAKES. I HAD SO MANY CARS IN MY LIFE AND I NEVER HAD THIS PROBLEM OF ROTORS BEEN WARP BECAUSE OVERHEATING. MILLIONS OF CARS RUNS EVERY DAY AT 65 MPH AND I DON'T HEAR THAT EVERY 5,000 MILES THEY HAVE TO CUT THE ROTORS BECAUSE OVERHEATING. I BELIEVE THIS IS A FACTORY DEFECTS AND THAT THEY SHOULD REPLACE THE ROTORS AT NO COST TO ME. PLEASE, I NEED TO KNOW WHERE I CAN FILE A FORMAL COMPLAINT TO TOYOTA, SINCE THE DEALER IS TRYING TO RIP ME OFF. *TR
NHTSA ODI #10524607
40,000 miles · Jul 9, 2013
Service Brakes
MY SECOND COMPLAINT TO NHTSA - PREVIOUS NHTSA # 10470305 THIS IS THE 3RD TIME IN 2 YEARS I HAVE HAD ISSUES WITH THE BRAKES WHEN I APPLY BRAKES, THE PEDAL GOES ALL THE WAY TO THE FLOOR AND VEHICLE DOESN'T STOP. I HAVE REQUESTED MY MONEY BACK OR REPLACED MY CURRENT SIENNA WITH A NEW ONE AS I HAVE PREVIOUSLY ASKED FOR WHEN IT HAP…
Read full complaint
MY SECOND COMPLAINT TO NHTSA - PREVIOUS NHTSA # 10470305 THIS IS THE 3RD TIME IN 2 YEARS I HAVE HAD ISSUES WITH THE BRAKES WHEN I APPLY BRAKES, THE PEDAL GOES ALL THE WAY TO THE FLOOR AND VEHICLE DOESN'T STOP. I HAVE REQUESTED MY MONEY BACK OR REPLACED MY CURRENT SIENNA WITH A NEW ONE AS I HAVE PREVIOUSLY ASKED FOR WHEN IT HAPPENED IN MAY OF 2011 AFTER DRIVING 600 MILES ON A BRAND NEW VEHICLE AND AT AROUND 20000 MILES IN 2012 WHEN IT HAPPENED AGAIN. I FEAR FOR THE SAFETY OF MY KIDS, MY FAMILY, MYSELF AND OTHERS AROUND ME WHEN I AM DRIVING. TOYOTA KNOWS THEY ARE AT FAULT YET THEY WANT ME TO TAKE RESPONSIBILITY.TOYOTA REFUSES TO HELP, THEY WANT TO BE GIVEN CHANCES TO FIX IT AS THEY'VE TRIED TWICE ALREADY SEE PREVIOUS COMPLAINT - I BOUGHT A BRAND NEW 2011 TOYOTA SIENNA XLE IN MAY OF 2011 FROM JAY WOLFE TOYOTA IN KANSAS CITY MO. AFTER 1000 MILES WITHIN LESS THAN A MONTH, STARTED HAVING BRAKE PROBLEMS. WHEN I PRESS THE BRAKE, IT WAS GLIDING, TAKING THE PADDLE TO THE FLOOR IN ORDER TO STOP THE VEHICLE EVEN AT SLOW SPEEDS. I WAS ENROUTE TO OMAHA FOR THE WEEKEND WITH MY FAMILY AND KIDS WHEN I STARTED HAVING THE BRAKE PROBLEM. I TOOK THE VEHICLE BACK TO THE DEALERSHIP AND THEY TOOK 4 DAYS TO CHECK AND DETERMINE IT WAS AIR IN THE BRAKE SYSTEM. I AM SURE THERE WAS MORE TO IT BUT THAT IS ALL THEY SAID AND FIXED. ONE PERSON FROM CORPORATE WAS THERE AND TOLD US AND GUARANTEED THAT WE SHOULD NEVER SEE THIS PROBLEM AGAIN. NOW LESS THAN A YEAR AFTER AT 26000 MILES STARTED HAVING SAME ISSUES WITH BRAKE. NOW THE DEALERSHIP SAYS THERE MAY BE A LEAK IN THE BRAKE SYSTEM THAT MAY NOT HAVE BEEN LOOK AT BEFORE. I ADVISED THEM DUE TO SAFETY OF MY FAMILY AND MY KIDS AND OTHERS ON THE ROAD, I AM NOT TAKING THIS VEHICLE BACK AND I REQUESTED TO BE REPLACED WITH ANOTHER NEW VEHICLE SINCE THEY ARE AT FAULT BY SELLING ME A VEHICLE WITH A BRAKE PROBLEM AND BY NOT FIXING IT RIGHT IN THE FIRST PLACE. *TR
NHTSA ODI #10523879
Mileage unknown · Jul 8, 2013
EquipmentEquipment Adaptive/mobility
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 13V123000 (EQUIPMENT) AND TOOK THE VEHICLE TO THE DEALER FOR SERVICE. THE CONTACT WAS ADVISED THAT BECAUSE THE VEHICLE DID NOT CONTAIN A FACTORY TRAILER HITCH, THEN THEY WOULD NOT REPAIR THE VEHICLE UNDER THE RECALL. THE D…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 13V123000 (EQUIPMENT) AND TOOK THE VEHICLE TO THE DEALER FOR SERVICE. THE CONTACT WAS ADVISED THAT BECAUSE THE VEHICLE DID NOT CONTAIN A FACTORY TRAILER HITCH, THEN THEY WOULD NOT REPAIR THE VEHICLE UNDER THE RECALL. THE DEALER ADVISED THE CONTACT THAT HE HAD TO CHANGE THE RIM AND WHEEL SIZE IN ORDER TO BECOME COMPLAINT AND FALL UNDER THE RECALL. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT SERVICED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. *TR
NHTSA ODI #10523702
47,000 miles · Jun 25, 2013
Visibility/wiper
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH THE GLASS IN THE SUNROOF EXPLODED WITH A LOUD BANG. IN ADDITION, GLASS FRAGMENTS FELL INTO THE SUNROOF AREA BUT DID NOT ENTER THE INTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH THE GLASS IN THE SUNROOF EXPLODED WITH A LOUD BANG. IN ADDITION, GLASS FRAGMENTS FELL INTO THE SUNROOF AREA BUT DID NOT ENTER THE INTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.
NHTSA ODI #10521629
15,300 miles · Jun 18, 2013
Structure
SIENNA PARKED INSIDE GARAGE. GARAGE DOOR WAS OPEN. I SLAMMED THE TRUNK DOOR TO CLOSE IT. MY 10 YEAR OLD SON COMPLAINED WHY I SLAMMED DOOR; I COULD HAVE CLOSED IT GENTLY. I TOLD HIM BECAUSE SOMETIMES THE TRUNK DOOR DOES NOT CLOSE ALTHOUGH IT APPEARS TO HAVE CLOSED. WE GOT IN THE SIENNA. I STARTED ENGINE. GARAGE DOOR STILL OPE…
Read full complaint
SIENNA PARKED INSIDE GARAGE. GARAGE DOOR WAS OPEN. I SLAMMED THE TRUNK DOOR TO CLOSE IT. MY 10 YEAR OLD SON COMPLAINED WHY I SLAMMED DOOR; I COULD HAVE CLOSED IT GENTLY. I TOLD HIM BECAUSE SOMETIMES THE TRUNK DOOR DOES NOT CLOSE ALTHOUGH IT APPEARS TO HAVE CLOSED. WE GOT IN THE SIENNA. I STARTED ENGINE. GARAGE DOOR STILL OPEN. I REVERSED THE CAR. THEN HEARD SMALL NOISE FROM THE BACK. THEN I SAW THE TRUNK DOOR WAS UP AND OPEN IN UP POSITION. I PARKED THE CAR, WENT BACK. THE SIENNA TAG PLATE WAS BROKEN HALF IN THE MIDDLE, APPARENTLY HITTING THE GARAGE DOOR. I CLOSED THE DOOR DOWN. SLOWLY BACKED THE CAR OUT OF THE GARAGE. THEN MY WIFE AND I HAD TO FORCE THE GARAGE TO CLOSE BECAUSE THE CAR'S BACKDOOR KNOCKED ONE OF ITS GLIDING WHEELS OFF TRACK. WE HAD TO FORCE IT BACK IN. THE DOOR OPENER WAS OFF THE TRACK AS WELL. ONE DAY LATER AFTER TRYING SEVERAL TIMES, THE DOOR WAS BACK WORKING AGAIN. WE ARE TESTING THE DOOR NOW. THE CAR DRIVES FINE. ~10 DAYS I DUMPED BOOKS OFF LIBRARY AND CLOSED THE TRUNK DOOR. AFTER GOING THROUGH A ROUNDABOUT FOR 0.7 MILE, THE SIGNAL FLASHED INDICATING THE TRUNK DOOR WAS LOOSE. I HAD TO PULL OVER TO CLOSE IT. MY WIFE ALSO SAID SEVERAL TIMES NOW SHE HAD THE SAME PROBLEM: THE DOOR WENT LOOSE AND THEN SIGNALED US IT WAS LOOSE MINUTES OR MILES AFTER WE STARTED THE ENGINE AND LEFT THE PARKING SLOT. *TR
NHTSA ODI #10520384
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration