NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
13 reportsClear category filter61,000 miles · May 31, 2018
VisibilityVisibility/wiper
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S WINDSHIELD HAD A CRACK APPROXIMATELY SIX INCHES LONG. THE VEHICLE WAS TAKEN TO RIVERSIDE TOYOTA (131 HWY 411 E, ROME, GA 30161, (706) 291-2886), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S WINDSHIELD HAD A CRACK APPROXIMATELY SIX INCHES LONG. THE VEHICLE WAS TAKEN TO RIVERSIDE TOYOTA (131 HWY 411 E, ROME, GA 30161, (706) 291-2886), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.
NHTSA ODI #11098980
106,000 miles · Feb 1, 2017
StructureVisibility
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 10 MPH, THE DRIVER SIDE SLIDING DOOR OPENED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE OVERHEAD SWITCH WAS REPLACED. IN ADDITION, THE SUN ROOF GASKET DETACHED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NO…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 10 MPH, THE DRIVER SIDE SLIDING DOOR OPENED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE OVERHEAD SWITCH WAS REPLACED. IN ADDITION, THE SUN ROOF GASKET DETACHED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V340000 (AIR BAGS) AND 16V858000 (STRUCTURE). THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10948955
66,000 miles · Dec 4, 2014
StructureVisibility
THE WHEELS ON THE DRIVER SIDE SLIDING DOOR BROKE CAUSING IT TO STOP WORKING AND SHATTERING THE BACK WINDOW OF MY VAN. MY CHILD WAS SITTING BY THE WINDOW THAT SHATTERED. WE WERE VERY LUCKY SHE WAS NOT INJURED BY THE GLASS. *TR
NHTSA ODI #10662214
60,000 miles · Dec 1, 2014
Visibility
DRIVING UP DRIVEWAY AND CLOSING REAR WINDOW WHEN THE WINDOW EXPLODED INTO THOUSANDS OF PIECES SENDING GLASS IN EVERY DIRECTION. HAD A PASSENGER BEEN IN THE REAR SEAT INJURIES WOULD HAVE BEEN LIKELY IN MY OPINION. MY CONCERN IS IF THIS HAPPENS WHEN SOMEONE HAS A CHILD IN THE REAR SEAR. THE END RESULT WAS SMALL FRAGMENTS OF GLA…
Read full complaint
DRIVING UP DRIVEWAY AND CLOSING REAR WINDOW WHEN THE WINDOW EXPLODED INTO THOUSANDS OF PIECES SENDING GLASS IN EVERY DIRECTION. HAD A PASSENGER BEEN IN THE REAR SEAT INJURIES WOULD HAVE BEEN LIKELY IN MY OPINION. MY CONCERN IS IF THIS HAPPENS WHEN SOMEONE HAS A CHILD IN THE REAR SEAR. THE END RESULT WAS SMALL FRAGMENTS OF GLASS OVER THE ENTIRE THIRD ROW SEATING AREA. *JS
NHTSA ODI #10661493
Mileage unknown · May 13, 2014
Visibility
DRIVING APPROX. 45 MILES PER HOUR IN THE CITY AND SUDDENLY THE PASSENGER SIDE REAR BACK WINDOW (VENT WIDOW) SHATTERED. FIRST A VERY LOUD NOISE AND THEN THE GLASS SHATTERED AND WENT EVERYWHERE. THERE WAS NO VISIBLE DAMAGE NOR DID THERE SEEM TO BE ANY EXTERNAL DEBRIS THAT COULD HAVE HIT THE WINDOW. THE ROAD WAS RATHER SMOOTH. …
Read full complaint
DRIVING APPROX. 45 MILES PER HOUR IN THE CITY AND SUDDENLY THE PASSENGER SIDE REAR BACK WINDOW (VENT WIDOW) SHATTERED. FIRST A VERY LOUD NOISE AND THEN THE GLASS SHATTERED AND WENT EVERYWHERE. THERE WAS NO VISIBLE DAMAGE NOR DID THERE SEEM TO BE ANY EXTERNAL DEBRIS THAT COULD HAVE HIT THE WINDOW. THE ROAD WAS RATHER SMOOTH. NOT SURE IF THIS IS A COMMON PROBLEM FOR WINDOWS OR THE 2011 TOYOTA SIENNA. *TR
NHTSA ODI #10588240
2,400 miles · Apr 12, 2013
Visibility
AT 2400 MILES. MY TOYOTA SIENNA START HAVING WINDOWS PROBLEM. IT IS VERY NEW CAR. AFTER NUMBERS OF REPAIR. THIS SIENNA-STILL BOTH PASSENGER FRONT AND REAR WINDOWS WILL AUTOMATICALLY ROLL BACK DOWN WHEN GETTING TO THE TOP. AND BACK DOOR CAN NOT BE CLOSED COMPLETELY. ESPECIAL RECENTLY. I FEEL THIS IS VERY DANGERS. BECAUSE …
Read full complaint
AT 2400 MILES. MY TOYOTA SIENNA START HAVING WINDOWS PROBLEM. IT IS VERY NEW CAR. AFTER NUMBERS OF REPAIR. THIS SIENNA-STILL BOTH PASSENGER FRONT AND REAR WINDOWS WILL AUTOMATICALLY ROLL BACK DOWN WHEN GETTING TO THE TOP. AND BACK DOOR CAN NOT BE CLOSED COMPLETELY. ESPECIAL RECENTLY. I FEEL THIS IS VERY DANGERS. BECAUSE THIS VAN WINDOWS UP AND DOWN IT IS VERY DANGER FOR MY 2 YEARS OLD BABY. IT MAY CUT HIS HAND. I DO NOT WANT THIS TERRIBLE VAN ANYMORE. THIS VAN REALLY MAKE ME HEADACHE AND WORRY. IF THIS VAN HAS NO PROBLEM. I WILL DEFINITELY NOT BOTHER ANYBODY. BUT IN FACT. THIS VAN REALLY CAUSE PROBLEM. AND BAD THING IS AFTER VISITED SEVERAL DIFFERENT DEALERSHIP. PROBLEM IS STILL HAPPENING. IF TOYOTA CAN FIX PROBLEM. CUSTOMER HAS NOTHING TO COMPLAINT. WHAT CAN WE DO ABOUT THIS. I AM VERY VERY DISAPPOINTED WITH TOYOTA QUALITY CONTROL SYSTEM. I AM A VERY DISAPPOINTED WITH 2 TOYOTA DEALERSHIP(CLAREMENT DEALERSHIP AND JOHN ELWAY'S CROWN DEALERSHIP)BECAUSE I WENT TO THESE DEALERSHIP MANY TIMES, WHAT THEY HAVE DONE IS PROBLEM STILL EXISTED. I AM PLANNING TO TRY 3RD TOYOTA DEALERSHIP. THIS IS MY FIRST TOYOTA. AND EXPERIENCE LET MY WIFE AND I FEEL VERY BAD AND VERY HEADACHE ABOUT THIS KIND OF QUALITY. *TR
NHTSA ODI #10506045
25,000 miles · Mar 21, 2013
VisibilityVisibility/wiper
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE SUNROOF SHATTERED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT AN OBJECT MAY HAVE STRUCK THE GLASS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE SUNROOF SHATTERED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT AN OBJECT MAY HAVE STRUCK THE GLASS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WAS APPROXIMATELY 25,000. THE VIN WAS UNAVAILABLE. *TR
NHTSA ODI #10503927
25,160 miles · Oct 3, 2011
Visibility
I WAS OUT IN THE FRONT PORCH NEAR MY GARAGE AROUND 7:30PM AND MY SIENNA WAS PARKED INSIDE THE GARAGE. SUDDENLY A LOUD NOISE LIKE AN EXPLOSION OF SORT OCCURRED THAT SCARED ME PRETTY BAD THAT PROMPTED ME TO LOOK INSIDE THE GARAGE AND I WAS SHOCKED TO SEE TWO LARGE HOLES SIMULTANEOUSLY ON EITHER SIDE (LEFT AND RIGHT) OF THE REAR WI…
Read full complaint
I WAS OUT IN THE FRONT PORCH NEAR MY GARAGE AROUND 7:30PM AND MY SIENNA WAS PARKED INSIDE THE GARAGE. SUDDENLY A LOUD NOISE LIKE AN EXPLOSION OF SORT OCCURRED THAT SCARED ME PRETTY BAD THAT PROMPTED ME TO LOOK INSIDE THE GARAGE AND I WAS SHOCKED TO SEE TWO LARGE HOLES SIMULTANEOUSLY ON EITHER SIDE (LEFT AND RIGHT) OF THE REAR WINDSHIELD AND THE GLASS WAS SLOWLY CAVING OUT AND THEN SHATTERED COMPLETELY IN (NOT SPIDER-WEB LIKE) SLOWLY FALLING AWAY INTO THE TRUNK. AFTER COMING BACK TO MY SENSES FROM THE INITIAL SHOCK, I CALLED MY INSURANCE COMPANY TO SEE IF THEY HAD HEARD OF SUCH FREAK INCIDENTS TO WHICH THEY SAID 'YES'. THEY DID MENTION TO GO TO THE DEALER AND SINCE IT IS STILL BRAND NEW (LESS THAN 9 MONTHS OLD), THE GLASS WILL BE REPLACED UNDER MANUFACTURER WARRANTY. I WENT TO[XXX] IN ARLINGTON, TX FROM WHOM I HAD PURCHASED THE VAN ALONG WITH THEIR DEALER WARRANTY ON TOP OF THE MANUFACTURER WARRANTY AND AFTER THEIR SERVICE MANAGER LOOKED AT THE NON-EXISTENT WINDSHIELD WITH SOME OF THE GLASS STILL HANGING ON TO THE EDGES, HE SAID HE CANNOT MAKE A JUDGMENT AS TO WHETHER IT WAS A MANUFACTURER'S DEFECT OR VANDALISM SINCE THERE IS NO WAY TO KNOW AS THE GLASS IS NOT IN THE WINDSHIELD ANYMORE (??!!!). I TOLD THEM THAT IF THE GLASS SHATTERS, IT WILL NOT BE INTACT AND YET THEY WOULD NOT BUY MY ARGUMENT. I CALLED TOYOTA CORPORATE AND THEY SAID UNLESS THE DEALER MAKES THE JUDGMENT, THEY CANNOT PROCEED WITH REPLACEMENT OF THE WINDSHIELD. I SINCERELY URGE THE NHTSA TO INQUIRE THIS INCIDENT SINCE IF IT HAD OCCURRED WHILE DRIVING, THERE WOULD HAVE BEEN A SERIOUS RISK OF DEATH OR INJURY CAUSED DUE TO THE SUDDEN SHOCK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
NHTSA ODI #10428336
13,900 miles · Sep 21, 2011
Visibility
I HEARD AN EXTREMELY LOUD EXPLOSION SOUND COMING FROM THE ROOF OF MY 2011 SIENNA JUST RIGHT AFTER I GOT ONTO A HIGHWAY AND WAS TRAVELING ABOUT 40MPH. THE SURROUNDING WAS CLEAR WHEN IT HAPPENED. I CALLED THE POLICE WHO FOUND OUT THAT THE SUNROOF GLASS BULGED UP AND SHATTERED. THE POLICE COULDN'T FIND ANY SIGNS OF ROCKS HITTING…
Read full complaint
I HEARD AN EXTREMELY LOUD EXPLOSION SOUND COMING FROM THE ROOF OF MY 2011 SIENNA JUST RIGHT AFTER I GOT ONTO A HIGHWAY AND WAS TRAVELING ABOUT 40MPH. THE SURROUNDING WAS CLEAR WHEN IT HAPPENED. I CALLED THE POLICE WHO FOUND OUT THAT THE SUNROOF GLASS BULGED UP AND SHATTERED. THE POLICE COULDN'T FIND ANY SIGNS OF ROCKS HITTING THE SUNROOF AND BASED ON THE GLASS BREAKAGE PATTERN SUSPECTED THAT THE CAR'S INTERIOR CABIN PRESSURE MIGHT HAVE CAUSED THE SUNROOF GLASS TO EXPLODE AND BREAK. HOWEVER, THE TEMPERATURE AT THE TIME WAS ONLY AROUND 65'F, SO IT COULDN'T BE DUE TO HEAT. THE POLICE SUSPECTED THE SUNROOF GLASS COULD BE A DEFECTIVE PART AND ASKED ME TO FOLLOW UP WITH A TOYOTA DEALER. *TR
NHTSA ODI #10426556
Mileage unknown · Aug 4, 2011
Visibility
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR VIEW MIRROR WAS VIBRATING WHILE DRIVING AT LOW SPEEDS AND IT WAS OBSTRUCTING HIS VIEW. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS AWARE OF THE FAILURE. NONE OF THE REPAIRS WERE PERFORMED. THE CURRE…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR VIEW MIRROR WAS VIBRATING WHILE DRIVING AT LOW SPEEDS AND IT WAS OBSTRUCTING HIS VIEW. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS AWARE OF THE FAILURE. NONE OF THE REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 16,000. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10417126
Official recalls
14Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Nov 29, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence & remedy
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence & remedy
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Consequence & remedy
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence & remedy
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration