IllustrationCHECKING ENGINE LIGHT ON AND OFF SLIDE DOOR NOT WORKING PROPERLY
2002 Toyota Sienna
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Toyota Sienna do not stand out strongly from the model-year median of 183.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sienna years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
2125–50K
2150–75K
2575–100K
18100–150K
11150K+
120 reports with mileage · 61 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports4 fire reports9 injury reports
Exterior Lighting complaints
2 reportsTL*THE CONTACT OWNS A 2002 TOYOTA SIENNA. AT 34,006 MILES, THE BRAKES BEGAN TO MAKE SQUEAKING NOISES AND THE BRAKE WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED WHILE DRIVING 45 MPH. AT 36,000, 46,000, AND 49,000 MILES, THE DEALER REPLACED THE FRONT AND REAR BRAKES, THE REAR AND FRONT ROTORS, AND ALSO RESURFACED THE FRONT A…
Read full complaint
TL*THE CONTACT OWNS A 2002 TOYOTA SIENNA. AT 34,006 MILES, THE BRAKES BEGAN TO MAKE SQUEAKING NOISES AND THE BRAKE WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED WHILE DRIVING 45 MPH. AT 36,000, 46,000, AND 49,000 MILES, THE DEALER REPLACED THE FRONT AND REAR BRAKES, THE REAR AND FRONT ROTORS, AND ALSO RESURFACED THE FRONT AND REAR DRUMS. THE REPAIRS WERE PERFORMED UNDER WARRANTY. NEVERTHELESS, THE BRAKES CONTINUED TO SQUEAK AND THE BRAKE PEDAL MUST BE DEPRESSED VERY HARD IN ORDER FOR THE VEHICLE TO STOP. THE DEALER STATED THAT THE NOISE WAS DUE TO THE BRAKE BUSTER AND IT NEEDED TO BE REPLACED AT THE COST OF $1,000 SINCE THE VEHICLE WAS OUT OF WARRANTY. THE MANUFACTURER STATED THAT THEY COULD NOT BE OF ASSISTANCE SINCE THE WARRANTY EXPIRED. THEY PROVIDED THE CONTACT WITH REFERENCE NUMBER 2007-0220392. THE CURRENT MILEAGE WAS 78,000 AND FAILURE MILEAGE WAS 34,006. THE DEALER STATED ARM RESTS, REPLACED BRAKE LIGHT BULB, SQUEAK IN THE INSIDE CABIN. UPDATED 11/26/07 *TR
Official recalls
110V160000 · Structure
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE01036 · Engine Compartment Fire
Opened Oct 19, 2001 · Closed Feb 11, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.