NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
8 reportsClear category filter103,000 miles · May 24, 2021
Engine And Engine Cooling
The contact owns a 2010 Toyota Sequoia. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an unknown dealer to be diagnosed. The contact was informed that there was moisture and condensation in the air injection pump and the air switching valve. The contact stated that there was a m…
Read full complaint
The contact owns a 2010 Toyota Sequoia. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an unknown dealer to be diagnosed. The contact was informed that there was moisture and condensation in the air injection pump and the air switching valve. The contact stated that there was a manufacturer’s warranty pertaining to the failure causing the check engine warning light to become illuminated however, the warranty was for 150,000 miles or 10 years, whichever came first. The vehicle was no longer covered under the warranty. The manufacturer was notified of the failure. The vehicle was repaired. The approximate failure mileage was 103,000. "The contact was informed that there was moisture and condensation in the air injection pump and the air switching valve." since this is not correct. The dealer only said that the items needed to be replaced due to the indicator light. They could not verify that there was a specific issue with the parts but said that it was an indicator that the parts could go bad and needed to be replaced.
NHTSA ODI #11418336
50,250 miles · Sep 16, 2012
Engine And Engine CoolingStructure
DISCOVERED REAR BUMPER WAS SEVERELY BURNED AROUND TAIL PIPE AFTER PULLING A TRAILER. I PURCHASED THE VEHICLE NEW FROM MODESTO TOYOTA. I BROUGHT THE VEHICLE TO MODESTO TOYOTA AND REPORTED THE PROBLEM AS A FACTORY DEFECT. THEY INSPECTED THE PROBLEM AND REPORTED BACK TO ME THAT THERE WAS NOTHING WRONG WITH THE TAIL PIPE AND BECAUSE…
Read full complaint
DISCOVERED REAR BUMPER WAS SEVERELY BURNED AROUND TAIL PIPE AFTER PULLING A TRAILER. I PURCHASED THE VEHICLE NEW FROM MODESTO TOYOTA. I BROUGHT THE VEHICLE TO MODESTO TOYOTA AND REPORTED THE PROBLEM AS A FACTORY DEFECT. THEY INSPECTED THE PROBLEM AND REPORTED BACK TO ME THAT THERE WAS NOTHING WRONG WITH THE TAIL PIPE AND BECAUSE IT WAS BEYOND THE WARRANTY PERIOD THERE WAS NOTHING THEY WOULD. I HAVE LOOKED AT ANOTHER 2010 SEQUOIA WHICH PULLS A TRAVEL TRAILER AND DISCOVERED THE SAME PROBLEM. I FEEL THIS PROBLEM HAS A POTENTIAL TO START A FIRE AND SHOULD BE COVERED BY TOYOTA REGARDLESS OF VEHICLE MILES. *TR
NHTSA ODI #10475566
Mileage unknown · Mar 10, 2012
Engine And Engine CoolingFire
IT MADE NOISE ON START AND WHILE PULLING OUT OF PARKING THE FLAMES/SMOKE CAME UNDER THE ENGINE/HOOD AND WHOLE VEHICLE GOT BURNED IN FEW MINUTES. RECENTLY HAD 30K SERVICE DONE BY TOYOTA DEALER. IT HAS BEEN RUNNING IN EXCELLENT CONDITION. *TR
NHTSA ODI #10451067
19,255 miles · Jul 26, 2011
Engine And Engine Cooling
WHILE PULLING OUR TRAVEL TRAILER WITH OUR 2010 TOYOTA SEQUOIA LIMITED 5.7, UPON STOPPING TO FUEL UP THE BUMPER AROUND THE EXHAUST PIPE HAD MELTED AND WAS SMOKING. WE NOTICED IN THE INTERIOR A FOUL SMELL, LIKE A PLASTIC BURNING BUT COULDN'T FIGURE IT OUT. WE STOPPED TO FUEL UP AND I CHECKED UNDER THE HOOD AND THEN DISCOVERED WHER…
Read full complaint
WHILE PULLING OUR TRAVEL TRAILER WITH OUR 2010 TOYOTA SEQUOIA LIMITED 5.7, UPON STOPPING TO FUEL UP THE BUMPER AROUND THE EXHAUST PIPE HAD MELTED AND WAS SMOKING. WE NOTICED IN THE INTERIOR A FOUL SMELL, LIKE A PLASTIC BURNING BUT COULDN'T FIGURE IT OUT. WE STOPPED TO FUEL UP AND I CHECKED UNDER THE HOOD AND THEN DISCOVERED WHERE THE PROBLEM WAS. THE TOW VEHICLE WAS WELL WITHIN LIMITS ACCORDING TO THE MANUFACTURER. *TR
NHTSA ODI #10415155
Mileage unknown · Feb 28, 2011
Engine And Engine Cooling
2010 SEQUOIA PLATINUM EDITION. WHEN TOWING A TRAILER THE REAR BUMPER SECTION AROUND THE EXHAUST PIPE EXIT BECOMES BLACK AND MELTS FROM THE EXTREME HEAT. A FIRE HAZARD. DEALERSHIP NOTIFIED 3 SEPARATE OCCASIONS WITH NO CORRECTIVE ACTION. *TR
NHTSA ODI #10384707
5,000 miles · Oct 20, 2010
Engine And Engine Cooling
IN JUNE 2010, TOOK FAMILY VACATION FROM VIRGINIA TO DISNEY WORLD. PULLED TRAVEL TRAILER RATED BELOW TOW RATING (7,000 LBS). WHEN ARRIVED, NOTICED THAT THE REAR BUMPER MELTED ALL AROUND THE EXHAUST. EXHAUST DOES NOT CLEAR THE BUMPER. IF YOU LOOK AT OTHER TOW VEHICLES, THE EXHAUST PIPE CLEARLY IS AWAY FROM THE VEHICLE. THE EX…
Read full complaint
IN JUNE 2010, TOOK FAMILY VACATION FROM VIRGINIA TO DISNEY WORLD. PULLED TRAVEL TRAILER RATED BELOW TOW RATING (7,000 LBS). WHEN ARRIVED, NOTICED THAT THE REAR BUMPER MELTED ALL AROUND THE EXHAUST. EXHAUST DOES NOT CLEAR THE BUMPER. IF YOU LOOK AT OTHER TOW VEHICLES, THE EXHAUST PIPE CLEARLY IS AWAY FROM THE VEHICLE. THE EXCESS LOAD FROM PULLING THE TRAILER CREATES EXCESS HEAT. REPORTED THE PROBLEM TO TOYOTA, THEY PROVIDED ME WITH A NEW BUMPER, CHANGED NOTHING ELSE. DECIDED I DID NOT WANT THIS TO HAPPEN AGAIN, WENT TO A TOYOTA PARTS SITE ON THE SOUTH EAST REGION AND ORDERED A EXHAUST PIPE TIP. WORKS GREAT. TAKES THE HEAT PAST THE BUMPER. I SHOULD NOT HAVE HAD TO BUY THIS, TOYOTA SHOULD RECALL AND PROVIDE THE EXHAUST TIP ON ALL. *TR
NHTSA ODI #10361393
2,500 miles · Aug 21, 2010
Engine And Engine Cooling
2010 TOYOTA SEQUOIA. BRAND NEW. BUMPER BEGAN TO MELT FROM EXTREME HEAT EMITTING FROM EXHAUST PIPE. STRONG SMELL OF SMOKE IN VEHICLE. BROUGHT TO TOYOTA. HAD TOYOTA REP. INSPECT. HE STATED THAT TOYOTA HAS REC.'D. OTHER COMPLAINTS OF SAME AND THAT THEY ARE WORKING ON SOLUTION. I FEEL THAT THIS IS A FIRE HAZARD. *TR
NHTSA ODI #10351093
Mileage unknown · Feb 26, 2010
Engine And Engine CoolingVehicle Speed Control
WHILE DRIVING OUR VEHICLE, THE ENGINE SUDDENLY REVVED UP ON ITS OWN WITHOUT THE ACCELERATOR BEING DEPRESSED. NO CARPET WAS OVER THE ACCELERATOR AND THE PEDAL AND CARPET HAD BEEN REPLACED BY TOYOTA ALREADY. WE CONTACTED TOYOTA AND THEY DID NOT RESPOND. *TR
NHTSA ODI #10314557
Official recalls
9Nov 23, 2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration