The contact owns a 2019 Toyota Rav4. The contact stated that the roof rack clips were fractured and water was leaking into the vehicle, causing the vehicle to shut off intermittently, electrical failures, and air bags malfunction. The vehicle was taken to the local dealer where it was diagnosed that the headliners were leaking. …
Read full complaint
The contact owns a 2019 Toyota Rav4. The contact stated that the roof rack clips were fractured and water was leaking into the vehicle, causing the vehicle to shut off intermittently, electrical failures, and air bags malfunction. The vehicle was taken to the local dealer where it was diagnosed that the headliners were leaking. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The approximate failure mileage was 66,000.
NHTSA ODI #11486603
Mileage unknown · Aug 19, 2022
Air BagsElectrical SystemStructure
There is a known issue with 2019+ Toyoya RAV4 where the Roof Rack Rails seaks leak water into the Driver and Passenger SRS A Pillar, i don't understand why there isn't a TSB for this, im concerned that the water intrusion will damage the Airbags or Electrical components and cause the airbag to deploy or cause improper SRS A pill…
Read full complaint
There is a known issue with 2019+ Toyoya RAV4 where the Roof Rack Rails seaks leak water into the Driver and Passenger SRS A Pillar, i don't understand why there isn't a TSB for this, im concerned that the water intrusion will damage the Airbags or Electrical components and cause the airbag to deploy or cause improper SRS A pillar airbag operation. I'm also concerned about rust, A Quick google search and youtube will show the issue occuring but toyota is only fixing it under warranty, i don't think this should happen on a car under 3 years old with less than 50,000 miles. I do notice a foul odor in the car which led me to find this related TSB T-SB-0094-21 for a similar issue but none for Roof Rack Seals. Toyota has updated the Seals to thicker ones from the flimsy paper gasket to thicker plastic since 2019 so they know about the issue and have corrected it but only under warranty. i did see complaints on carcomplaints.com also but i'm out of factory warranty.
NHTSA ODI #11480241
Mileage unknown · Aug 13, 2022
Structure
The rear hatch trunk doorr does not operate correctly. The hinges holding the door on could fail leaving the door to fly off the vehicle. Apparently this is a known problem on this make and model of this vehicle and toyota is unwilling to repair the problem
NHTSA ODI #11479177
Mileage unknown · Jun 22, 2022
Structure
This Rav4 developed a leak in the roof by the front and back windows. Found many references to this on the internet. It is a known problem for this vehicle that is not being addressed by Toyota. This problem can cause mold and damage to the side air bags. This is clearly a safety issue.
NHTSA ODI #11470396
Mileage unknown · May 31, 2022
Air BagsStructure
Water is entering vehicle from roof rack over the driver side A-pillar. The headliner is getting wet, and the side curtain airbags are located in this area. The concern is that the water will affect airbags, along with issues with mold and rust.
NHTSA ODI #11466704
Mileage unknown · May 7, 2022
Structure
Hi. A couple months ago I bought a certified 2019 Toyota rav4 adventure. I'm happy with the purchase however there is an issue that I'm concerned about and is a leak that comes from the roof. I checked my rav4 and I did notice some stains in the roof, by the roof pillars. I love my rav4 and I've subscribed to different rav4 ch…
Read full complaint
Hi. A couple months ago I bought a certified 2019 Toyota rav4 adventure. I'm happy with the purchase however there is an issue that I'm concerned about and is a leak that comes from the roof. I checked my rav4 and I did notice some stains in the roof, by the roof pillars. I love my rav4 and I've subscribed to different rav4 chat forums and I noticed that many people especially the one's who own the 2019 rav4 adventure have the same issue with the roof leaking, that originates from the roof racks. I noticed that there's not a recall on this issue and I would like to know if Toyota does offer a solution to this problem.
NHTSA ODI #11463724
Mileage unknown · Apr 9, 2022
Air BagsStructure
Lots of people including me are having issues with 2019 or newer Toyota RAV4 the roof guard rails seals start letting water in on both the driver side and passenger side near the airbag. This a YouTube link that explained it well. https://youtu.be/DbKHfLtI2Sc . I am worried my air bags will not function since they might be getti…
Read full complaint
Lots of people including me are having issues with 2019 or newer Toyota RAV4 the roof guard rails seals start letting water in on both the driver side and passenger side near the airbag. This a YouTube link that explained it well. https://youtu.be/DbKHfLtI2Sc . I am worried my air bags will not function since they might be getting wet.
NHTSA ODI #11460223
Mileage unknown · Mar 18, 2022
Structure
Vehicle purchased two years ago developed a failure of the mechanism that opens and supports the rear hatch with no warning. This led to cracking of hinges and brackets, and mis-alignment of the hatch which prevented it from closing and latching. The original estimate for repairs would have made the owner liable for thousands …
Read full complaint
Vehicle purchased two years ago developed a failure of the mechanism that opens and supports the rear hatch with no warning. This led to cracking of hinges and brackets, and mis-alignment of the hatch which prevented it from closing and latching. The original estimate for repairs would have made the owner liable for thousands of dollars. After reviewing evidence that this was not due to an accident or other abuse, Toyota agreed to a one-time 'goodwill' financial adjustment that reduced owner financial liability. But as reported in various Toyota owner forums, this is not an isolated incident: hatch opening mechanism failure has been experienced by owners of other Toyota products with various models and model years. A fundamental design flaw requires a remedy, not just repair to return it to its original, flawed, state.
NHTSA ODI #11457243
Mileage unknown · Feb 22, 2022
Air BagsStructure
The factory installed bike rack is not sealed properly and leaking water when rains,etc… into the SRS airbag on passenger and driver side
NHTSA ODI #11453440
Mileage unknown · Jan 9, 2022
Air BagsStructure
The roof rack rails have begun leaking due to failed weather sealants around them. Water is seeping through when it rains, getting water on the airbags, headliner, and moves along the top frame. I’m scared the electrical components will become damaged. Issue began happening right around 45,000 miles when I noticed. I have only o…
Read full complaint
The roof rack rails have begun leaking due to failed weather sealants around them. Water is seeping through when it rains, getting water on the airbags, headliner, and moves along the top frame. I’m scared the electrical components will become damaged. Issue began happening right around 45,000 miles when I noticed. I have only owned vehicle for 2.5 years.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration