2019 Toyota RAV4

Engine maintenance required light came on. Vehicle was diagnosed with needing a new coolant bypass valve. Researching online and in Toyota groups, this is a widespread issue. Even the dealer said they have had many of these repairs yet Toyota has not issued a recall. This is a repair with a cost of $500-$1000 and a safety concern but Toyota has not addressed it.

On May 13, 2023, ‘Engine Maintenance Required-Visit Your Dealer’ warning appeared on my console. I immediately brought the vehicle to the Toyota dealer. I was told the Coolant Bypass Valve went bad. This was at roughly 45,000 miles. I had previously purchased a ‘No deductible extended warranty’ from this same Toyota dealer. Now they tell me this ‘Valve’ is not covered under warranty. I was charged $887.99 for repair of this ‘Valve’. As this could cause the engine to overheat, causing additional damage, it most certainly is a safety issue.

2019 Toyota Rav4 Premium Engine Maintenance light visit dealer popped up on the vehicle. Researching online apparently the coolant bypass valve malfunctioning is a recurring issue with the 2019 Toyota Rav4, not sure why a recall has not been done yet for this vehicle. Went to the dealer to have the vehicle looked at, before having it diagnosed the service person stated it is probably the coolant bypass valve and that the part is on back order, vehicle was put on the machine to have it diagnosed and confirmed that the Coolant Bypass Valve will need to be replaced. The only warning light that it gave me was Engine Maintenance light came on. The service advisor said the vehicle is perfectly fine to drive till they get the part in, which still concerns me because of the engine. I am having to pay out of pocket to get it repaired but after talking to the service people and researching online from other people, there really should be a recall for the Coolant Bypass Valve.

We have a 2019 Toyota Rav4, win VIN JTMK1RFV8KD******, about a week ago this message appeared: "ENGINE MAINTENANCE REQUIRED. VISIT YOUR DEALER." The Mileage was still 74,104. After a week, I took it to a mechanic shop; I had the oil changed and discovered that the message cannot be removed. I had the vehicle system scanned and one of the items that came up is "Engine and engine cooling". My mechanic went on line to find out if there's a RECALL issue on my vehicle with its VIN. There are 8 Recall issues on the KELLY BLUE BOOK website but not on the Toyota website. We called the dealership and they confirmed that my VIN is not included in the list. Toyota is charging $180 or more just to Diagnose. WHY do we have to pay for the Manufacturer's defects?

The engine on my Rav4 suddenly stopped without any notification while I was driving it on the freeway. I could have been severely injured from the risk of being rear ended by vehicles behind me. I have experienced this twice now, and both times, I have been on a busy highway in the middle of rush hour traffic. While driving, the engine would start sputtering and the vehicle will jolt and shake, eventually causing a warning message to appear that says power steering low, engine shutting off, place vehicle in Park. Then, when I turn the engine off, and try to restart it, it would flash a message that read Not ready to drive. After towing the vehicle to a service department, the vehicle would start up like normal, and the techs could not get vehicle to duplicate the issue. No codes would come up when they place it on a scanner, either. I researched the issue online, and it appears I am not the only one who has experienced this issue with the Rav4. Please reference https://www.rav4world.com/threads/engine-stopped-steering-power-low.323916/ This incident happened twice, once on 3/6 and again on 3/8. I thought the issue was fixed after having my vehicle towed on 3/6 to Freeman Toyota Service where they determined the issue was due to a recall on the fuel pump. However, the incident occurred again on 3/8, and I had to have the vehicle towed as the engine shut off while I was driving on the freeway blocking one lane of traffic on the interchange that connects one freeway to another. I was very fearful of other vehicles crashing into me as some of them were squeezing by between my vehicle and the retaining wall to get around me. It took the wrecker over an hour to get to me due to high traffic time. I have uploaded 2 tow bills I had to pay, and the service invoice for the recall work done. My vehicle is currently at another Toyota Service department where they are telling me they are unable to duplicate the issue.