2019 Toyota RAV4

Component: Engine — Engine Cooling System — Coolant Pump Summary: The electric water pump on my 2019 Toyota RAV4 failed prematurely at 64273 miles. The check engine light illuminated with diagnostic trouble code P26CB (Engine Coolant Pump Performance/Stuck Off). The engine coolant temperature fluctuated rapidly / coolant level dropped. The vehicle required immediate repair to avoid engine damage. This is a recurring failure pattern on 2019–2021 Toyota RAV4 and Camry vehicles equipped with the 2.5L A25A-FKS engine, where the electric water pump seizes due to an apparent defect in its plastic housing and rotor assembly. Failures are routinely reported at 30,000–60,000 miles—far below the expected service life of the component. Loss of coolant circulation creates an overheating hazard and can lead to sudden loss of propulsion and engine damage while driving. Toyota has issued technical service bulletins related to coolant seepage at the pump but has not recalled the component or extended warranty coverage, leaving owners to bear repair costs of $600–$1,300 for a premature defect-driven failure. I request NHTSA to evaluate this defect for a safety recall.

As soon as my vehicle hit 100K mileages and there's "AWD System malfunction" sign showed up on dash. Got it done replaced it cost roughly more than $500. After 2 days later another problem shows up on dash this time it was "engine maintenance required" show on dash again. Heard people had the same issue to whoever own 2019 RAV4 and they all had the same for those 2 issues. Toyota company should pay attention for these kind of problems or like some of of recall.

The Coolant Bypass Valve on my vehicle failed, leading to a risk of sudden engine overheating and potential coolant leaks into the electrical harness. This is a documented defect (CSP 23TE03) that Toyota has failed to address for vehicles over 100,000 miles, creating a safety hazard for high-mileage owners. This is a major concern on a known issue and those that don't have funds to pay for this known failure. They need to do a recall for ALL!

The 8-speed automatic on my 2019 RAV4 (2.5L 4 Cyl) has been shifting super rough at lower speeds, to the point to where downshifts can send the revs into redline territory, but the car really doesn't move. No warning lights, passed state inspection, recently serviced. purchaced this car in Janurary with 50k miles on it and noticed it within a few weeks of driving. I am now at 57k and the issue is signifigantly worse than it was before. Will be taking it to Toyota soon. The safety issues arise when I do not know how the car is going to accelerate or respond to throttle input in traffic. I don't trust the car to handle any fast throttle input if I need to move out of the way quickly.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message "Engine Maintenance Required - Visit the Dealer" was displayed on the screen. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the coolant flow control valve needed to be replaced. The vehicle was repaired out-of-pocket. Upon further investigation, the contact related the failure to Customer Support Program: 24TE04. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 116,000.

I was driving down a road and my engine just stopped working lights came on saying there were several issues including the engine. I researched online and found there were recalls due to this same problem for the same make, model and year as my Vehicle, but there is no recall on my vehicle. The dealer confirmed the engine was seized up or whatever wording they used. No one has inspected it other than Rodland Toyota. There were no warning lights or messages or symptoms before the issue.

This is another complaint with the same issue. Got gas on January 1, 2026, the truck did not how any indication that it was going to have any problems. Engine shut down and wouldn’t turn back on. This has happened twice after getting gas, no dealership knows the problem. This is casing me stress and putting myself and family in danger. Considering it stops out of no where

The contact owns a 2019 Toyota Rav4. The contact stated while driving 70 MPH, the vehicle experienced a loss of motive power. No warning light was illuminated. The contact managed to push the vehicle over to the shoulder of the road, and the vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

My 2019 Toyota RAV4 experienced a dangerous electrical and transmission failure that ultimately caused the vehicle to stall while driving and made me lose control. For several weeks before the incident, the vehicle showed subtle hesitation when accelerating but no warning lights. After the car stalled and spun out coming off the Ben Franklin Bridge onto I-76 near downtown Camden, police responded, confirmed the vehicle had unexpectedly shut off, and verified there was no crash damage. I later brought the car to the Toyota dealership, where they discovered corrosion on the battery cable, failed ABS sensors, and a weak battery. I paid $668 for a new battery, new cable, and ABS sensor repairs. At that time, the dealership did not inform me of any transmission issues and released the vehicle back to me. I made it only a short distance up the road before realizing the vehicle could not accelerate past 40 mph and was still malfunctioning, so I immediately returned it. The next day, the dealership initially claimed there was nothing wrong with the vehicle, but after I insisted they re-evaluate the car, they then informed me that the transmission was failing and needed replacement. This sequence of electrical instability, combined with the transmission malfunction, ultimately led to the earlier stall where I lost all power steering and braking assist and spun out into the median. The vehicle, diagnostic records, and replaced components are available for inspection. The sudden loss of power and control created a major safety risk to me and other drivers in a high-traffic area.

Was insinuating engine was over heating even in -4° weather has no hot air plenty of coolant. This is causing the vehicle to "buck" amd having to have to pull over and waiting several minutes to let the engine "cool off" I can make it about 3 miles in-between pull overs. After some research I feel like the issue falls under a current lawsuit against Toyota regarding the coolant valve based on reading other issues and what my rav is doing. It is a several thousand dollar fix through a dealership and one my family can not afford especially if it is a poorly manufactured part of the car. It is one of two vehicles we have and need to daily living especially having a child and no means yo offered another safe vehicle at this time. The coolant pump itself