IllustrationMOST LIGHTS ON DASHBOARD ARE LIT UP. VSC, ENGINE 4WD. ALSO MY MECHANIC SAID OUTS THROWING OFF A LOT OF FALSE READINGS. LIGHTS ARE ALWAYS ON SOMETIMES FEELS LIKE THE TRANSMISSION IS SLIPPING WHEN I GO FROM STOPPED TO GO ON A HILL. OUTS BEEN THIS WAY SINCE I BOUGHT IT.
2006 Toyota RAV4
Owner reports · Recalls · Investigations
More warning signs than most RAV4 years
Owner complaints for the 2006 Toyota RAV4 are substantially higher than the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1130–25K
12025–50K
12450–75K
8075–100K
81100–150K
22150K+
540 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 230 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports5 fire reports9 injury reports
Electronic Stability Control (esc) complaints
12 reportsCOMPUTER PROBLEMS CAUSING ALL THE LIGHTS TO COME ON THE DASHBOARD AND DISABLING THE SHIFTING SOLENOID. IT ALSO DISABLES THE SAFETY BRAKING AND FOUR WHEEL DRIVE. THIS CAUSES THE VEHICLE TO BE UNSAFE.
UPDATING THE RECENT COMPLAINT, WARNING LIGHTS:-CHECK ENGINE,VSC, TCS,BREAK,4WD LIGHTS ARE KEEP ON COMING , VEHICLE LOOSES ALL POWER ASSISTANCE. THIS IS THE 4TH TIME I AM EXPERIENCING THE SAME PROBLEM. THIS VEHICLE WAS WITH AUTO MECHANIC FEW DAYS AGO AND HE CHANGED THE BATTERY AND CHECK THE ALTERNATOR, ALL IN GOOD CONDITION. YEST…
Read full complaint
UPDATING THE RECENT COMPLAINT, WARNING LIGHTS:-CHECK ENGINE,VSC, TCS,BREAK,4WD LIGHTS ARE KEEP ON COMING , VEHICLE LOOSES ALL POWER ASSISTANCE. THIS IS THE 4TH TIME I AM EXPERIENCING THE SAME PROBLEM. THIS VEHICLE WAS WITH AUTO MECHANIC FEW DAYS AGO AND HE CHANGED THE BATTERY AND CHECK THE ALTERNATOR, ALL IN GOOD CONDITION. YESTERDAY MORNING I WAS ON THE WAY TO WORK,ALL WARNING LIGHTS CAME AND I HAD TO STOP THE CAR IN FREEWAY, I TURNED OFF THE ENGINE AND LEFT THE VEHICLE FOR FEW MINUTES,STARTED ENGINE AND ENGINE LIGHT WERE ON, BUT ALL POWER CAME BACK AND I COULD WENT BACK BACK TO MY HOME. I LEFT THE THIS CAR AT HOME AND TOOK MY 2ND CAR AND WENT FOR WORK. EVENING I CHECK THE CAR, MY CAR LOOKS NORMAL THERE WAS NO WARNING LIGHTS, IT WAS RUNNING NORMAL. I BELEIVE THIS CAR HAS SOME SERIOUS ELECTRONIC PROBLEM( UNABLE TO DETECT THROUGH DIAGNOSTIC MACHINE).WHICH I CHECK WITH 3 DIFFERENT MECHANICS.
DEAR, NHTSA DATABASE: TOYOTA ? MOTOR SALES (TMS), U.S.A. INC.; MOTOR CREDIT CORPORATION (TMCC); FINANCIAL SERVICES SECURITIES USA CORPORATION; GOODYEAR TIRE & RUBBER COMPANY (GOODYEAR.COM) UNSAFE:TOYOTA 2006 RAV4 (VIN) [XXX]. DEFECTS UNREPAIRABLE: 4 .JPG; UNREPAIRABLE RECALLS SAFETY RISK:1 .PDF; PR…
Read full complaint
DEAR, NHTSA DATABASE: TOYOTA ? MOTOR SALES (TMS), U.S.A. INC.; MOTOR CREDIT CORPORATION (TMCC); FINANCIAL SERVICES SECURITIES USA CORPORATION; GOODYEAR TIRE & RUBBER COMPANY (GOODYEAR.COM) UNSAFE:TOYOTA 2006 RAV4 (VIN) [XXX]. DEFECTS UNREPAIRABLE: 4 .JPG; UNREPAIRABLE RECALLS SAFETY RISK:1 .PDF; PROTECT SAFELY & SAFEGUARD ? PLEASE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
OSTEOPOROSIS AND I READ THAT THIS DRUG BRINGS ON OR MAKES WORSE ANY OSTEOPOROSIS CONDITION MINE IS EXTREMELY SEVER AND MINE IS SEVER. I HAVE SINCE GONE TO A NEUROLOGIST AND HE PUT ME ON VERAPAMIL 80 MGS 2 X A DAY. I FRACTURED MY RIGHT KNEE IN 15 PLACES-I AM IN CONSTANT PAIN-I HAVE TO PAY OUT MONEY TO GET ANYWHERE I NEED TO GO-GR…
Read full complaint
OSTEOPOROSIS AND I READ THAT THIS DRUG BRINGS ON OR MAKES WORSE ANY OSTEOPOROSIS CONDITION MINE IS EXTREMELY SEVER AND MINE IS SEVER. I HAVE SINCE GONE TO A NEUROLOGIST AND HE PUT ME ON VERAPAMIL 80 MGS 2 X A DAY. I FRACTURED MY RIGHT KNEE IN 15 PLACES-I AM IN CONSTANT PAIN-I HAVE TO PAY OUT MONEY TO GET ANYWHERE I NEED TO GO-GROCERIES,BANK ALL THE CONTINUING VISITS TO MY PRIMARY DOCTOR, MY ORTHOPEDIC SURGEON(BECAUSE UNLESS I DO NOT REPLACE MY KNEE-I WILL BE IN THIS HORRIFIC-& PAIN THAT IS MY ORTHOS OPINION. I AM ALL FOR IT JUST TO LESSEN THE PAIN- I DO NOT WANT TO HAVE TAKE PILLS WHEN IT COULD BE GONE AFTER MY ACCIDENTS- I RECEIVE IN THE MAIL YET ANOTHER RECALL THAT SPECIFICALLY SAYS MY VIN NUMBER AND SAYS THAT BESIDES SOMETHING THAT GIVES ELECTRICAL TO THE AIR BAGS- MAY CAUSE AIR BAGS-NOT TO DEPLOY-I HAVE NO CAR,IT WAS TOTALED, THE POLICE SUSPENDED MY LICENSE AND BECAUSE OF THIS I HAVE TO GO THROUGH A BUNCH OF STUFF IN ORDER TO GET MY LICENSE BACK. I HAVE CALLED TOYOTA A LOT OF TIMES-THEY DO NOT CARE=I WAS WHAT-I HAVE NO FAMILY I HAVE HAD 4 ACCIDENTS-NEVER HAD THAT MANY, I HAD A TOYOTA CECLICA FOR 20 YEARS AND NEVER HAD 1 RECALL AND DID HAVE 1 ACCIDENT..AND THAT IS 20YEARS PRIOR TO THIS ONE-THAT CAR WAS A SUPER LEMON,BUT NO ONE GIVES A [XXX] WHAT I AM GOING THROUGH AND NO ONE CARES-THE PEOPLE I HAVE TALKED TO DOWN THERE ARE RUDE AND DISRESPECTFUL TO MT. HOPEFULLY I CAN FIND A LAWYER WHICH WILL DO PRO-BONO. THANKS FOR THE 15 FRACTURES. THE LOSS OF MY LICENSE,HAVING TO -THANKS FOR THE MISERY YOU HAVE BROUGHT ME AND THE RUDE AND CRAPPY BEHAVIOR OF YOUR COLLEAGUES. I HAVE NOTHING LEFT-NO LICENSE,NO CAR-HAVE TO PAY SOMEONE TO THE DOCTORS,FOOD,HAD TO MY CHAMPIONSHIP YORKIE UP BECAUSE I COULD NOT CARE FOR HER=U TRY THAT WITH 15 FRACTURES IN UR KNEE-NOT TO MENTION WHAT THE NEUROLOGIST ABOUT MY HANDS.UR CUSTOMER SERVICE SUCKS-THEY ARE RUDE & DISRESPECTFUL. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
CAR AT ABOUT 37,000 MILES. ONLY DRIVE TO STORE AND DROP KIDS OFF TO SCHOOL. CAR PARKED FOR 10 MINUTES WHILE AT STORE SHOPPING. CAME BACK, STARTED THE ENGINE. THE ENGINE LIGHT, VSC AND 4WD LIGHTS ALL LIGHTED UP. WHEN TO LOCAL TOYOTA DEALER, DEALER SAID CAN'T SERVICE IT AT THIS TIME NEED TO MAKE APPOINTMENT. DEALER STATED B…
Read full complaint
CAR AT ABOUT 37,000 MILES. ONLY DRIVE TO STORE AND DROP KIDS OFF TO SCHOOL. CAR PARKED FOR 10 MINUTES WHILE AT STORE SHOPPING. CAME BACK, STARTED THE ENGINE. THE ENGINE LIGHT, VSC AND 4WD LIGHTS ALL LIGHTED UP. WHEN TO LOCAL TOYOTA DEALER, DEALER SAID CAN'T SERVICE IT AT THIS TIME NEED TO MAKE APPOINTMENT. DEALER STATED BASED ON THE LIGHTS, THIS MIGHT BE THE IGNITION COIL.. IT'S KNOWN TO HAVE PROBLEM. ESTIMATED COST TO FIX ABOUT $1500. BUT WE NEED TO COMPUTERIZED THE CODES.. *TR
WE WERE ON THE ROAD (ON A FAMILY VACATION). THE DAY THAT WE WERE COMING BACK THE CHECK ENGINE LIGHT, THE VSC LIGHT AND THE SLIP WARNING LIGHT CAME ON AS WE WERE PULLING OUT OF THE HOTEL PARKING LOT. ON THE WAY TO THE DEALER, I ALSO FELT LIKE THE CAR WAS MISFIRING. THE DEALER FOUND "MULTIPLE CODES P0304, P0305, P0306, P0356, P157…
Read full complaint
WE WERE ON THE ROAD (ON A FAMILY VACATION). THE DAY THAT WE WERE COMING BACK THE CHECK ENGINE LIGHT, THE VSC LIGHT AND THE SLIP WARNING LIGHT CAME ON AS WE WERE PULLING OUT OF THE HOTEL PARKING LOT. ON THE WAY TO THE DEALER, I ALSO FELT LIKE THE CAR WAS MISFIRING. THE DEALER FOUND "MULTIPLE CODES P0304, P0305, P0306, P0356, P1578, C1201. #6 COIL MALFUNCTIONING. RECOMMEND REPLACE #6 COIL PACK AND RECHECK. POSSIBLE THAT OTHER COIL MAY FAIL FROM THE RESULT OF #6 COIL FAILING." #6 COIL PACK WAS REPLACED AND THE RAV4 HAS BEEN RUNNING FINE SINCE. THE DEALER ALSO SAID THAT "TYPICALLY AFTER ONE COIL GOES THE OTHERS FOLLOW SHORTLY AFTER", SO I WILL KEEP AN EYE OPEN FOR THAT. IT IS STRANGE SINCE IGNITION COILS HAVE A LONG LIFE EXPECTANCY. I CHECKED ON-LINE AND THERE SEEMS TO BE A HIGH FAILURE RATE WITH COIL PACK PART # 90919-02251, WHICH IS THE ORIGINAL PART THAT CAME WITH THE CAR. I MADE SURE THE PART WAS REPLACED WITH THE LATEST REVISION (90919-A2007) OF THE NEW PART NUMBERS (90919-A2002, 90919-A2004 OR 90919-A2007) THAT TOYOTA CHANGED TO. IT IS ALSO INTERESTING THAT MOST OF THE FAILURES HAPPEN WITH #6, #4 AND #5 COILS (IN THAT ORDER). THE FAILURES SEEM TO CONCENTRATE AROUND THE RIGHT FRONT CORNER, WHICH IS CLOSE TO THE RADIATOR (HOT FLUID) EXIT. MAYBE THAT IS WHY THE LATER REVISION PART # COIL PACKS HAVE A DOUBLE METALLIC SCREEN OUTSIDE THE PLASTIC HOUSING, TO PROTECT THE ASSEMBLY. *TR
TO WHOM IT MAY CONCERN: I SENT THE BELOW LETTER DIRECTLY TO TOYOTA AND RECEIVED A NOTE BACK STATING MY ISSUE IS NOT CONSIDERED A RECALL. HOWEVER, I FEEL THIS IS A SAFETY ISSUE AND TOYOTA SHOULD BE COVERING THE REPAIRS. I HAVE A 2006 RAV4 THAT ENCOUNTERED AN ISSUE FEB 2010. I TOOK IT INTO A TOYOTA DEALERSHIP AND THE DIA…
Read full complaint
TO WHOM IT MAY CONCERN: I SENT THE BELOW LETTER DIRECTLY TO TOYOTA AND RECEIVED A NOTE BACK STATING MY ISSUE IS NOT CONSIDERED A RECALL. HOWEVER, I FEEL THIS IS A SAFETY ISSUE AND TOYOTA SHOULD BE COVERING THE REPAIRS. I HAVE A 2006 RAV4 THAT ENCOUNTERED AN ISSUE FEB 2010. I TOOK IT INTO A TOYOTA DEALERSHIP AND THE DIAGNOSIS WAS LEFT REAR SPEED SENSOR AND HARNESS. SINCE THE ESTIMATE WAS A LITTLE OVER $1000.00, I WAS NOT ABLE TO AFFORD THE REPAIR. WITHIN A FEW WEEKS AFTER I PICKED UP THE CAR, THE ABS, TRAC AND VSC LIGHTS WENT OFF AND STAYED OFF UNTIL DEC 2010. WHEN THE LIGHTS CAME BACK ON, I STARTED TO RESEARCH THE ISSUE AND CAME UP WITH A "TECHNICAL SERVICE BULLETIN (TSB)" EXPLAINING EXACTLY THE SYMPTOM I AM EXPERIENCING. THE TSB STATES THAT SOME 2006 MODEL YEAR RAV4 VEHICLES MAY EXHIBIT AN ABS M.I.L. "ON"............ THE TSB GOES ON STATING THE REAR WHEEL SENSOR HAVE BEEN MODIFIED TO CORRECT THIS CONDITION. MY VIN NUMBER ACCORDING TO THIS TSB SHOWS THAT MY RAV4 IS ONE OF THOSE VEHICLES THAT FALL INTO THIS CATEGORY OF A POSSIBLE FAILURE. THE WARRANTY INFORMATION STATED THE REPAIR IS COVERED UNDER THE TOYOTA COMPREHENSIVE WARRANTY OF 3 YEARS OR 36,000 MILES. THE WARRANTY APPLICATION DOES ALSO STATE THE REPAIR IS LIMITED TO CORRECTION BASED UPON A CUSTOMER'S SPECIFIC COMPLAINT. I DROVE TO A DEALER IN MY AREA AND EXPLAINED THE ISSUE AND SHOWED THEM THE TSB. I ALSO CALLED YOUR CUSTOMER EXPERIENCE CENTER. UNFORTUNATELY, I DID NOT RECEIVE ANY COOPERATION CONCERNING MY ISSUE. MY RAV4 IS 4 YEARS OLD AND HAD AROUND 48,000 MILES (THE FIRST TIME THIS ISSUE OCCURRED) - JUST OUT OF THE "COMPREHENSIVE WARRANTY". I PURCHASED A TOYOTA FOR ITS RELIABILITY AND SAFETY. NOW, BOTH OF THOSE REASONS ARE HINDERED BECAUSE OF AN ISSUE TOYOTA KNEW ABOUT IN 2006 THAT UNFORTUNATELY OCCURRED ON MY VEHICLE JUST OUT OF THE WARRANTY. I WOULD LIKE TO TALK TO SOMEONE THAT CAN MAKE A REASONABLE AND CONSCIOUS DECISION CONCERNING MY COMPLAINT. *TR
I PURCHASED A TOYOTA 2006 RAV 4 IN JANUARY OF 2006 AND HAD THE CAR SERVICED AT THE TOYOTA DEALER PER THE SCHEDULED FACTORY MAINTENANCE SUGGESTIONS. IN OCTOBER OF 2006, I WAS TRYING TO AVOID RUNNING A YELLOW LIGHT ON PEACHTREE STREET IN ATLANTA, AND ACCELERATED HARD TO AVOID THE YELLOW LIGHT. THE CAR LUNGED FORWARD AND WAS OUT…
Read full complaint
I PURCHASED A TOYOTA 2006 RAV 4 IN JANUARY OF 2006 AND HAD THE CAR SERVICED AT THE TOYOTA DEALER PER THE SCHEDULED FACTORY MAINTENANCE SUGGESTIONS. IN OCTOBER OF 2006, I WAS TRYING TO AVOID RUNNING A YELLOW LIGHT ON PEACHTREE STREET IN ATLANTA, AND ACCELERATED HARD TO AVOID THE YELLOW LIGHT. THE CAR LUNGED FORWARD AND WAS OUT OF CONTROL. EVEN THOUGH I LIFTED MY FOOT COMPLETELY OFF THE PEDAL. AFTER GETTING THROUGH THE INITIAL SHOCK I PUT THE TRANSMISSION IN NEUTRAL, THE ENGINE REVVED UP TO THE RED LINE AND I TURNED THE IGNITION SWITCH OFF. AFTER WAITING FOR A MINUTE I RESTARTED THE CAR IN PARK AND THE ENGINE IDLED NORMALLY. I TOOK THE CAR TO THE TOYOTA DEALER FOR THE SCHEDULED MAINTENANCE AND AFTER INSPECTING IT HE TOLD ME THERE WAS NOTHING WRONG WITH THE CAR. AFTER THE RECALL OF THE TOYOTA RAV 4'S I CALLED THE TOYOTA DEALER I BOUGHT THE CAR FROM AND TALKED TO HIS SERVICE MANAGER. HE TOLD ME THAT THE 2006 RAV 4'S HAVE NOT BEEN RECALLED AS THEY HAVE A DIFFERENT GAS PEDAL AND WERE MADE IN JAPAN. HE COULD NOT EXPLAIN THE CAUSE OF THE ACCELERATION. THE CAR HAS NOT DONE THAT SINCE, HOWEVER I AM NOT DRIVING THE CAR ANYMORE. MY DAUGHTER IS AND THIS CONCERNS ME GREATLY. NO FIXES OR REPAIRS HAVE BEEN DONE ON THE CAR BY THE TOYOTA DEALER. *TR
THIS IS THE SECOND COMPLAINT I HAVE HAD ON MY 2006 RAV4 V6 2WD EMISSION SYSTEM CAUSING MY VEHICLE STABILITY, TRACTION CONTROL, AND SPEED CONTROL SYSTEMS TO FAIL. THE FIRST EVENT IS ODI NUMBER 10268422. THE SECOND EVENT WAS DUE TO A MILE OF DRIVING SLOWLY IN LIGHT SNOW CAUSING A FUEL EVAPORATION FILTER TO BREAK A TUBE FITTING OF…
Read full complaint
THIS IS THE SECOND COMPLAINT I HAVE HAD ON MY 2006 RAV4 V6 2WD EMISSION SYSTEM CAUSING MY VEHICLE STABILITY, TRACTION CONTROL, AND SPEED CONTROL SYSTEMS TO FAIL. THE FIRST EVENT IS ODI NUMBER 10268422. THE SECOND EVENT WAS DUE TO A MILE OF DRIVING SLOWLY IN LIGHT SNOW CAUSING A FUEL EVAPORATION FILTER TO BREAK A TUBE FITTING OFF. WATER ENTERED THE BROKEN TUBE AND FAILED THE FUEL EVAP CHARCOAL CANISTER WHICH IN TURN FAILED THE VEHICLE STABILITY, TRACTION CONTROL, AND SPEED CONTROL SYSTEMS (ODI NUMBER 10268424). I SEE NO REASON TO TIE EMISSIONS INTO SAFETY SYSTEMS SUCH AS THESE UNLESS IT IS TO "ENCOURAGE" OWNERS TO BRING THEIR VEHICLES IN FOR EMISSIONS SERVICE. AFTER SOME WRANGLING, THE DEALER AGREED TO SUBMIT IT TO MY EXTENDED WARRANTY AND IT WAS COVERED IN FULL. I WAS TOLD THE CHARCOAL CANNISTER WOULD HAVE COST ME $700. *TR
Official recalls
1116V596000 · Suspension:rear
Aug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Consequence & remedy
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
16V096000 · Seat Belts:rear/other
Feb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
Consequence & remedy
Consequence: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
15V689000 · Visibility:power Window Devices And Controls
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
14V168000 · Air Bags:frontal:driver Side:inflator Module
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
13V383000 · Suspension:rear
Aug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Consequence & remedy
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
12V373000 · Suspension:rear
Aug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Consequence & remedy
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
11V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE12013 · Rear Suspension Arm Assembly Failure
Opened Jun 4, 2012 · Closed Sep 13, 2012
Status: closed (inferred from source dates) · Suspension; Suspension:rear
In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.
Additional source detail variants (4)
Suspension:rear
In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.
Suspension:rear
In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.
Suspension
In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.
Suspension
In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.