2001 Toyota RAV4

2001 TOYOTA RAV4 - MANUFACTURER-PROGRAMMED ECM FAILURE LEADING TO HARD SHIFTING, PROBLEMS ACCELERATING, AND MISFIRING. UNFORTUNATELY, TOYOTA IS ONLY COVERING THE REPAIR COST IF UNDER 80,000 MILES. APPEARS THIS IS HAPPENING TO MANY PEOPLE NO MATTER WHAT THE MILEAGE IS AND SINCE THIS IS A SAFETY ISSUE, A RECALL SHOULD BE MADE TO REPAIR THIS FREE OF CHARGE TO THE OWNER. I HAD TO PAY OVER $1300 TO GET THIS FIXED. *TR

2001 TOYOTA RAV4 4WD CAR HAS NOT HAD ANY PROBLEMS UNTIL RECENTLY WHEN THE TRANSMISSION STARTED ACTING UP. IT IS VERY INTERMITTENT. WHEN STARTING FROM A STOPPED POSITION OR GETTING ONTO A FREEWAY THE CAR WILL LOOSE ITS POWER. THE TRANSMISSION SLIPS, JERKS, AND ENGINE SPEEDS UP WITHOUT CAR PROPERLY ACCELERATING. VERY DANGEROUS SITUATION BECAUSE YOU CANNOT MERGE WITH TRAFFIC, CAN?T GET OUT OF THE WAY OF OTHER VEHICLES ONCE THE CAR ENTERS AN INTERSECTION, OR COULD GET REAR ENDED BY OTHER VEHICLES. I CAN DRIVE THE CAR FOR A COUPLE OF DAYS WITHOUT THE PROBLEM SHOWING UP. HAD IT IN TO MY MECHANIC TWICE AND THEY CAN?T REPRODUCE IT TO FIX IT. NO PROBLEMS SHOW UP ON THE COMPUTER CHECK. WHEN IT DOES HAPPEN IT MIGHT ONLY HAPPEN ONCE WHEN STARTING OUT FROM A STOP AND THEN BE FINE FOR MANY DAYS OR MILES. I CANNOT MAKE IT DO IT. AFTER RESEARCHING THIS PROBLEM ON THE INTERNET I HAVE LEARNED IT IS A DEFECTIVE DESIGN PROBLEM WITH THE ECM MODULE THAT CONTROLS THE TRANSMISSION. TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN DATED MARCH 6, 2006. THEY HAVE NOT NOTIFIED OWNERS OF THE PROBLEM. *TR

MY 2001 RAV4, WITH JUST OVER 80K ON IT, WENT BELLY-UP. TWO DAYS BEFORE THE EXTENDED WARRANTY EXPIRED (BOUGHT IT CERTIFIED USED), THE TRANSMISSION STARTED SLIPPING, DISABLING THE CAR 2 HOURS FROM HOME. THE DEALER IT WAS TOWED TO SAID THEY COULDN'T FIND ANYTHING WRONG WITH IT, PUT IN 3/4 QT OF TRANNY FLUID, CALLED IT GOOD. IN FEBRUARY, AFTER IT WAS OUT OF WARRANTY, IT ONCE AGAIN DIED ON A TRIP, AGAIN 2 HOURS AWAY FROM HOME. THE DEALER I HAD IT TOWED TO THIS TIME SAID IT NEEDED A NEW TRANSMISSION. THE CODE WAS P0770 FOR SOLENOID MALFUNCTION. AFTER LONG NEGOTIATIONS WITH TOYOTA THEY REPLACED THE TRANSMISSION. *TR

FALL '08 2001 TOYOTA RAV4 BEGAN STALLING UNEXPECTEDLY WHILE CHANGING GEARS BETWEEN 2 AND 3 RPMS. SUDDEN JERKS AND HALTS OCCUR AFTER COMING TO COMPLETE STOPS AND ATTEMPTING TO ACCELERATE TO GO. DIAGNOSTIC TEST CLAIMS SOLENOIDS BUT TOYOTA DEALERSHIP SUGGESTS REPLACING ECM AND/OR TRANSMISSION. AN EXPENSE OF ABOUT $4500 WITHOUT GUARANTEE OF FIXING THE PROBLEM. EXTREMELY DANGEROUS WHEN DRIVING IN HIGHWAY, KEEPING UP WITH TRAFFIC PACE SUDDENLY HALTS AND LOOSES POWER. *TR

JANUARY 2008 I HAD THE ECM REPROGRAMMED BY TOYOTA AFTER RECEIVING A LETTER TO COME IN FOR THIS. ON JUNE 3, 2008, I EXPERIENCED A SUDDEN STUTTER FOLLOWED BY A LOUD NOISE WHILE DRIVING. THE FOLLOWING MORNING WHILE DRIVING TO WORK THE VEHICLE STUTTERED AND FELT LIKE IT WAS GOING TO STALL. IT WOULD HESITATE ON ACCELERATION. I CALLED THE DEALERSHIP FOR SERVICING AND TOOK THE CARE IN. THE ADVISOR TOLD ME TO REPLACE THE ECM AND TRANSMISSION. THE SERVICE CODE INDICATED THAT THE TRANSMISSION FAILED. THE TOYOTA TECH SERVICE BULLETIN (TC002-06) FROM 3//3/06 INDICATED THAT IMPROVEMENTS HAD BEEN MADE TO THE MANUFACTURING PROCESS OF THE ECM AND TO REPAIR THIS PROBLEM, R&R ECM WHICH WAS NOT DONE IN THE RECALL. *TR

MY 2001 TOYOTA RAV4 BEGAN ACTING UP AND WOULD NOT SHIFT CORRECTLY. IT WOULD SHIFT VERY HARD, AND WOULD OFTEN HESITATE BEFORE SHIFTING INTO GEAR. THE CHECK ENGINE LIGHT CAME ON, AND THE VEHICLE WAS TAKEN TO A TRANSMISSION SHOP. THE SHOP RECOMMENDED REPLACING THE TRANSMISSION AND ECM MONITOR TO CORRECT THE ISSUE, AS THEY WERE VERY AWARE OF THE ISSUE WITH THE RAV4'S AND ALSO BECAUSE METAL SHAVINGS WERE FOUND IN THE TRANSMISSION PAN. TOYOTA IS WELL AWARE OF THIS ISSUE, AND CONTINUES TO TRY AND AVOID THEIR RESPONSIBILITIES WITH THESE VEHICLES. IN MARCH 2006, TOYOTA SENT DEALERS A TECHNICAL SERVICE BULLETIN WARNING THEM THAT SOME CONSUMERS MIGHT COMPLAIN ABOUT HARSH SHIFTING. IT SAID IMPROVEMENTS WERE MADE TO THE COMPUTER ?MANUFACTURING PROCESS TO REDUCE THE POSSIBILITY OF THIS CONDITION OCCURRING.? IT THEN TOLD THE DEALERS TO REPLACE THE MODULE AND IF THAT DID NOT WORK TO REPLACE THE TRANSMISSION. BUT CONSUMERS OWNING THE VEHICLES WERE NEVER NOTIFIED ABOUT THE PROBLEM. TOYOTA ALSO REFUSED TO DO ANYTHING IS THE VEHICLES MILEAGE IS OVER THE 80,000 WARRANTY PERIOD, AND LUCKY FOR THEM, MOST VEHICLES DO NOT HAVE ANY ISSUES UNTIL THEY ARE OUT OF THE WARRANTY PERIOD. *TR

2001 TOYOTA RAV4 HAS TRANSMISSION SLIPPAGE/HARSH SHIFTING. MANUFACTURER DEFECT IN ECU IS WELL KNOWN BUT TOYOTA WILL NOT REPLACE DEFECTIVE ITEM. ANYONE DRIVING THIS MODEL IS IN A "TICKING TIME BOMB" FOR TRANSMISSION FAILURE. IF IT HAPPENS AT SPEED, THERE WILL BE DEATH/INJURY INCURRED. INFORMATION WAS IN N.Y. TIMES ON 8/26/2009 ARTICLE. I AM THE OWNER OF THIS VEHICLE AND WANT TO BE ADDED TO THE NHTSA LIST OF COMPLAINTS/CONCERNS ABOUT THIS WELL KNOWN DEFECT. REQUEST AGENCY PRESSURE TOYOTA TO RECALL/REPLACE ECU/ECM/TRANSMISSION AS NEEDED ON EVERY OPERATIONAL RAV4 IN THE 2001-2003 RANGE. TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN TC002-06 ON MARCH 3, 2006 ADVISING SERVICE MANAGERS TO REPLACE ECM/TRANSMISSIONS.. "ONLY IF CUSTOMER COMPLAINS" THIS IS A DEVIOUS WAY OF AVOIDING AN OUTRIGHT NOTIFICATION/RECALL AND I REQUEST YOUR GOOD AGENCY HELP OWNERS LIKE ME WHO ARE ENDANGERING THEIR FAMILIES/THEM SELVES & THE GENERAL PUBLIC ON OUR ROADS. I AM A LICENSED DRIVING INSTRUCTOR IN THE STATE OF CONNECTICUT AND WILL MAKE EVERYONE I KNOW AWARE OF THIS DANGEROUS SITUATION WITH A TOYOTA PRODUCT. YOUR ASSISTANCE IS APPRECIATED. *TR