2001 Toyota RAV4

TL* THE CONTACT OWNS A 2001 TOYOTA RAV4. THE CONTACT STATED THAT WHEN PULLING FROM A LIGHT AND TRYING TO DEPRESS THE ACCELERATOR PEDAL, IT DID NOT RESPOND. ALL OF A SUDDEN, THE VEHICLE JERKED FORWARD AS IF SOMEONE HAD STOMPED ON THE GAS PEDAL. SHE NOTICED THE PROBLEM SEVERAL TIMES PRIOR TO THE FAILURE TO A SMALLER DEGREE. SHE TOOK THE VEHICLE TO A REPAIR SHOP AND THE MECHANIC STATED THAT THE TRANSMISSION WAS THE CAUSE FOR FAILURE AND MOST LIKELY NEEDED TO BE REBUILT. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT WITH A REPRESENTATIVE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 92,000.

TRANSMISSION SLIPPING, UNABLE TO ACCELERATE. SEVERE JERKING, BONE RATTLING AND VERY JARRING, LOSS OF POWER AND VEHICLE STALLING. OCCURRED SEVERAL TIMES, HAD REPAIRED IMMEDIATELY AND A HIGH COST TO ME. TRANSMISSION HASN'T FELT RIGHT SINCE. STOPPED DRIVING VEHICLE TO REPLACEMENT OF ECM WAS REPLACED. I'M NOT CONFIDENT THAT THE TRANSMISSION DIDN'T SUFFER DAMAGE DURING THIS LIMITED TIME IT WAS DRIVEN AND UNTIL THE REPAIR COULD BE MADE. I HAVEN'T FELT COMPLETELY SAFE BECAUSE THE FAILURE WAS SO SEVERE AND QUICK TO SURFACE. *TR

THE TRANSMISSION ON MY DAUGHTER'S 2001 TOYATA RAV STARTED SLIPPING TWO WEEKS AGO. MY DAUGHTER STILL IS A COLLEGE STUDENT AND STILL RESIDES AT HOME COMMUTING TO SCHOOL (15 MILES ONE WAY) EVERYDAY. I AM A MECHANICAL ENGINEER AND HAVE RELIGIOUSLY MAINTAINED ALL OUR VEHICLES AND KNOW THAT THE TRANSMISSION SHOULD NOT GIVE ANY PROBLEMS WITH JUST OVER 100,000 MILES. I HAVE DRIVEN ALL MY VEHICLES WAY PAST OVER 160K MILES AND NEVER HAVE HAD ANY PROBLEMS. I HAVE RESEARCHED THE INTERNET AND THERE ARE ALOT OF COMPLAINTS WITH THIS SAME PROBLEM. TOYOTA SHOULD BE MADE TO RECALL AND FIX THE PROBLEMS. *TR

I ALSO HAD TO SHELL OUT $3000 TO REPLACE A FAULTY ECM FOR THE TOYOTA RAV4 2001. THE CAR HAD LOW MILEAGE AND JUST PAST THE 7 YEAR WARRANTY. THE CAR'S TRANSMISSION IS NOT SHIFTING AND THE CAR ALMOST DIED ON THE WAY TO THE DEALERSHIP. I FOUND THOUSANDS OF REPORTED CASES OF PEOPLE SHARING THE SAME GRIEF AND APPARENTLY THIS PROBLEM WITH THE ECM EXTENDS TO 2002-2003 RAV4 AND COROLLAS AS WELL. TOYOTA KNOWS ABOUT THIS PROBLEM BECAUSE THEY HAD A RECALL THE PATCH THE ECM AT 2006. BUT THE PATCH DOES NOT WORK AND PERHAPS A SMALL BANDAGE TO MASK THE REAL PROBLEM. AND TOYOTA BANKED ON THE FACT THAT CAR WILL EXCEED THE WARRANTY SO THEY BLOW ALL OF US OFF AND MAKE US PAY FOR THE PART OR DUMP THE CAR. I BROUGHT THIS UP WITH THE DEALERSHIP AND ALSO WITH TOYOTA HEADQUARTER AND THEY VEHEMENTLY DENIED THIS IS A WIDE SPREAD PROBLEM AND REFUSED TO FIX THE PROBLEM FOR FREE OR TO DO A RECALL. BUT JUST DOING A CASUAL SEARCH THIS PROBLEM IS THE HIGHEST REPORTED PROBLEM WITH ANY TOYOTAS AND THIS PROBLEM SPANS TO EU AND AUSTRALIA AS WELL. THE ONLY REASON WHY THIS IS NOT PUBLICIZE IS BECAUSE LUCKILY NO ONE DIED, OR WE DON'T KNOW ABOUT IT. BUT THE RAV4 CAN EASILY STALLED ON THE FREEWAY AND CAUSING ANOTHER CAR TO SLAM INTO THE RAV4. TOYOTA HAS A HISTORY OF LYING TO THE PUBLIC. FOR THE LAST 10 YEARS, THEIR CARS ALL HAD SOME TYPE OF ELECTRICAL PROBLEMS. IT'S NOT JUST THE ACCELERATOR OR BRAKE ISSUE, IT'S ELECTRICAL. THEY HAVE A POOR DESIGN THAT KILLS. I HOPE THIS LETTER CAN PROMPT ANOTHER INVESTIGATION INTO OTHER MODELS OF TOYOTA THAT HAD SUFFERED WITH OTHER ISSUES IN THE LAST DECADE. *TR

EVENT 1: 1. SHORTLY AFTER BUYING CAR, NOTED ENGINE REVS WOULD SOAR BY 700 TO 800 RPMS BETWEEN GEARS WHILE SHIFTING MANUAL TRANSMISSION. FOUND THIS HAPPENED BY JUST DISENGAGING THE CLUTCH WITHOUT SHIFTING EVEN WITH FOOT NOT ON THE ACCELERATOR PEDAL. 2. THE REV SOARING HAPPENED CONSISTENTLY. NO CONSEQUENCES EXCEPT FOR AN UNPLEASANT DRIVING EXPERIENCE. 3. COMPUTER WAS REPROGRAMMED BY THE DEALER FROM WHOM I BOUGHT THE CAR. REV JUMPS REDUCED TO ABOUT 400 RPM. A SECOND REPROGRAMMING REDUCED IT TO ABOUT 200 RPM. THIS BEHAVIOR STILL EXISTS. EVENT #2. 1. ABOUT SIX MONTHS AFTER PURCHASING THE CAR, NOTED THAT WHEN CRUISING WITH RPMS ABOVE 2800 RPM IN 5TH GEAR WITH CRUISE CONTROL ENGAGED AND FOOT NOT ON ACCELERATOR PEDAL, ON DISENGAGING THE CLUTCH, THE ENGINE REVS WOULD SOAR TO 3,200 RPM TO 3,500 RPMAND REMAIN THERE FOR PERIODS RANGING BETWEEN 5 SECONDS TO OVER A MINUTE. THIS OCCURRED WHILE THE CAR WAS COASTING AND SLOWING WHILE NOT UNDER POWER. 2. THIS BEHAVIOR FREQUENTLY OCCURRED UNDER THE ABOVE CONDITIONS. NO CONSEQUENCES EXCEPT AS A PROFESSION ENGINEER AND FORMER SPORTS CAR RACING DRIVER, I KNEW THIS BEHAVIOR WAS NOT NORMAL. 3. BEHAVIOR EXAMINED BY MY LOCAL TOYOTA DEALER. MECHANIC HOOKED UP RECORDING BOX TO CAR, BUT I WAS UNABLE TO REPLICATE THE BEHAVIOR ON THIS OCCASION. DATA EXAMINED BY A TOYOTA ENGINEER WHO PRONOUNCED THERE WAS NOT A PROBLEM. LATER, I WAS AGAIN ABLE TO REPLICATE THE BEHAVIOR. AFTER YET ANOTHER COMPUTER REPROGRAMMING, THIS BEHAVIOR OF REMAINING AT A HIGH RPM SEEMS TO HAVE STOPPED. HOWEVER, THE ENGINE REVS STILL WILL SURGE TO ABOUT 3,400 RPM BEFORE DROPPING OFF. *TR

ENGINE CONTROL MODULE AND AUTO TRANSMISSION FAILURE. BOUGHT RAV USED JULY 2007 WITH 109,230 MI. CHECK ENGINE LIGHT WAS ON (HAS REMAINED ON) BUT WAS DIAGNOSED AS O2 SENSOR & RAV OPERATED PERFECTLY (LIVE WHERE EMISSIONS CHECK NOT REQUIRED). MAY 2009 TRANNY STARTED ALTERNATING BETWEEN WORKING GOOD, SHIFTING ROUGH, SLIPPING BETWEEN GEARS, AND NOT DOWNSHIFTING AT SLOW DOWN OR STOP. HAD MECHANIC WITH OVER 15 YRS EXPERIENCE AT TOYOTA DEALERSHIP CHECK IT (AFTER HOURS). HE WAS UNAWARE OF CONNECTION TO FAULTY ECM SO WE THOUGHT TRANY WAS BAD & HE FLUSHED TRANNY. THAT REDUCED FREQUENCY OF SYMPTOMS BUT DID NOT STOP THEM. WE STILL THOUGHT PROBLEM WAS MECHANICAL & TRANNY REBUILD/REPLACE WAS INEVITABLE & I DROVE IT LONGER TO SAVE UP MONEY FOR REPAIRS. I LIVE ON A SEMI-RURAL OHIO STATE ROUTE WITH 55MPH POSTED LIMIT & 65MPH AVERAGE SPEED. I HAD NUMEROUS NEAR MISSES WHEN THE VEHICLE WOULD NOT ACCELERATE PROPERLY OR BEGAN TO ACCELERATE NORMALLY THEN SLIPPED, HESITATED, OR REFUSED TO SHIFT. MY 18YR OLD SON DROVE THE RAV IN DEC & PULLED OUT OF OUR DRIVEWAY IN FRONT OF A SEMI TRACTOR TRAILER RIG WITH WHAT WOULD HAVE BEEN SAFE DISTANCE EXCEPT THAT THE RAV DECIDED NOT TO ACCELERATE. THE TRUCK WAS ABLE TO PASS, BUT HAD THERE BEEN ONCOMING TRAFFIC, IT WOULD NOT HAVE BEEN ABLE TO SLOW ENOUGH IN TIME. INTERMITTENT SYMPTOMS CONTINUED UNTIL 12/14/09 WHEN 2ND & 3RD GEAR BURNED OUT & I DROVE HOME 20 MILES IN 1ST. JUST PARTS THRU TOYOTA WILL COST $2000 FOR REBUILT TRANNY PLUS $1000 FOR ECM. INDEPENDENT REPAIRMEN CAN FIX THE ECM FOR $65. HAD I AT LEAST KNOWN ROOT CAUSE OF THE SYMPTOMS WAS ECM NOT TRANNY (TOYOTA'S KNOWN SINCE 2006 OR BEFORE) I COULD HAVE SAVED $4-5K & AVOIDED 7 MONTHS OF RISKY DRIVING. I CHALLENGE ANYONE WHO THINKS THIS IS NOT A SAFETY ISSUE TO DRIVE ONE OF THESE AND RELY ON IT WHEN IT FAILS IN 65MPH TRAFFIC. OR WE CAN WAIT UNTIL SOMEONE IS KILLED WHERE THERE IS ENOUGH EVIDENCE TO SHOW THIS PROBLEM WAS THE CAUSE OF THE ACCIDENT AND NOT POOR DRIVER JUDGMENT. *TR