TL* THE CONTACT OWNS A 2000 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SLIPPED OUT OF FIFTH GEAR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED …
Read full complaint
TL* THE CONTACT OWNS A 2000 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SLIPPED OUT OF FIFTH GEAR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 62,000 AND THE CURRENT MILEAGE WAS 145,000.
NHTSA ODI #10532662
72,000 miles · Jul 28, 2007
Power Train
MANUAL TRANSMISSION INTERMITTENTLY CAME OUT OF FIFTH GEAR AND WENT INTO NEUTRAL WHILE DRIVING 50-70 MPH. CAR WAS TAKEN TO AN REPAIR FACILITY OTHER THAN TOYOTA, WHERE A SERVICE BULLETIN WAS FOUND. CAR WAS THEN TAKEN TO TOYOTA DEALER AND THE TRANSMISSION WAS REBUILT. TOYOTA OF AMERICA WAS NOTIFIED. I WAS INFORMED THAT TOYOTA D…
Read full complaint
MANUAL TRANSMISSION INTERMITTENTLY CAME OUT OF FIFTH GEAR AND WENT INTO NEUTRAL WHILE DRIVING 50-70 MPH. CAR WAS TAKEN TO AN REPAIR FACILITY OTHER THAN TOYOTA, WHERE A SERVICE BULLETIN WAS FOUND. CAR WAS THEN TAKEN TO TOYOTA DEALER AND THE TRANSMISSION WAS REBUILT. TOYOTA OF AMERICA WAS NOTIFIED. I WAS INFORMED THAT TOYOTA DID NOT CONSIDER THIS 'PROBLEM' WHICH THEY KNEW OF WORTHY OF A RECALL BECAUSE IT DID NOT EFFECT ENOUGH VEHICLES. *TR
NHTSA ODI #10197731
65,000 miles · Nov 3, 2004
Power Train
MANUAL TRANSMISSION INTERMITTENTLY CAME OUT OF FIFTH GEAR AND WENT INTO NEUTRAL WHILE DRIVING 50-70 MPH. DEALER WAS NOTIFIED, AND UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM.*AK
NHTSA ODI #10099314
Mileage unknown · Jun 5, 2002
Power Train
WHEN IN REVERSE THERE IS A LOUD NOISE AT ALL TIMES. DEALER STATED THERE WAS NOTHING WRONG WITH TRANSSMISION.*AK
NHTSA ODI #8011127
Mileage unknown · Jan 29, 2002
Power Train
CONSUMER STATES HE BELIVES THAT VEHICLE HAS A TRANSMISSION PROBLEM, WHEN DRIVING THE TRANSMISSION MAKES A CLUNK SOUND, VEHICLE HAS BEEN TO THE DEALER ON 2 OCCASIONS, HOWEVER DEALER INFORMED CONSUMER THAT VEHICLE IS FUNCTIONING PROPERLY AND THERE WOULD BE NO FURTHER REPAIR OR ACTION.*JB
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
Remedy: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.
VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. IF THE SUBJECT VEHICLES ARE REPEATEDLY PARKED BY PLACING THE SHIFT LEVER INTO THE "P" POSITION WITHOUT APPLYING THE PARKING BRAKE, THE PARKING LOCK ROD, A COMPONENT OF THE TRANSMISSION PARKING LOCK SYSTEM, COULD BREAK.
Consequence & remedy
Consequence: THIS CONDITION CAN RENDER THE SYSTEM INOPERATIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING LOCK ROD.
VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.
Consequence & remedy
Consequence: THE DISC ROTOR COULD BREAK (WHERE IT MOUNTS TO THE WHEEL), RESULTING IN A LOSS OF BRAKING ACTION ON THAT WHEEL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DISC BRAKE ROTORS. IF THE VEHICLE IS EQUIPPED WITH STEEL WHEELS, TOYOTA WILL REPLACE THE FRONT DISC BRAKE ROTORS AND STEEL WHEELS WITH NEW DISC BRAKE ROTORS AND NEW ALUMINUM WHEELS. IN ADDITION A CAUTION LABEL THAT READS, "USE NEW GENUINE TOYOTA ALUMINUM WHEELS." WILL BE AFFIXED. VEHICLES ALREADY EQUIPPED WITH ALUMINUM WHEELS WILL ONLY REQUIRE CAUTION LABEL INSTALLATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration