I RECEIVED A LONG TECHNICAL LETTER FROM TOYOTA WITH MY VIN NUMBER WARNING ME OF A POSSIBLE FAILURE OF THE INTELLIGENT POWER MODULE IN MY 2015 PRIUS. IT SAYS THIS IS NOT A RECALL, BUT RATHER AN ADVISEMENT OF A VOLUNTARY CUSTOMER PROGRAM THAT HAS BEEN INITIATED FOR MY VEHICLE. IT SAYS THAT IF I HAVE THE INCLUDED SYMPTOMS, TO BRING…
Read full complaint
I RECEIVED A LONG TECHNICAL LETTER FROM TOYOTA WITH MY VIN NUMBER WARNING ME OF A POSSIBLE FAILURE OF THE INTELLIGENT POWER MODULE IN MY 2015 PRIUS. IT SAYS THIS IS NOT A RECALL, BUT RATHER AN ADVISEMENT OF A VOLUNTARY CUSTOMER PROGRAM THAT HAS BEEN INITIATED FOR MY VEHICLE. IT SAYS THAT IF I HAVE THE INCLUDED SYMPTOMS, TO BRING IT IN FOR EVALUATION, AND A REPAIR WILL BE ATTEMPTED, BUT IF THE PROBLEM IS NOT THE IPM, I WILL HAVE TO PAY FOR THE INVESTIGATION. THIS SOUNDS MOST UNFAIR. I DO NOT HAVE THE SKILLS TO MAKE THE NECESSARY DETERMINATION. I CALLED MY LOCAL TOYOTA DEALERSHIP AND THEY SAID THEY WOULD HAVE SOMEONE CALL ME BACK, BUT NO ONE HAS CALLED!
NHTSA ODI #11400147
41,000 miles · Mar 20, 2019
Service BrakesUnknown Or Other
AT 41,000 THE VEHICLE PER A GOODYEAR DEALER ADVISED THAT MY FRONT BRAKES WERE METAL ON METAL. THE CALIBER WAS ALSO FROZEN AND THE BRAKE LINE WAS LEAKING. THE CAR WAS AT THE DEALERSHIP ON 3/7/19 WITH NO MENTION OF A NEED FOR REPAIRS TO THE FRONT BRAKES. IS THERE A GENERAL PROBLEM WITH BAD BRAKES ON TOYOTA VEHICLES?
NHTSA ODI #11190229
200 miles · Sep 5, 2018
Unknown Or Other
THE LOUDNESS OF THE HORN IS VERY UNSAFE. TOYOTA OUGHT TO BE ASHAMED OF INSTALLING SUCH A "WHIPPY SOUNDING HORN SYSTEM ON ITS HYBRID. WHEN I WAS CUT-OFF IN CITY TRAFFIC, THE HORN LOUDNESS WOULDN'T ATTRACT IMMEDIATE ATTENTION TO MOST OTHER DRIVERS.
NHTSA ODI #11124623
Mileage unknown · Sep 5, 2018
Electronic Stability Control (esc)Unknown Or Other
NOTED RECALL ON THE NEWS FOR ELECTRICAL SYSTEM FOR 2015 TO 2018
NHTSA ODI #11124500
12,700 miles · Jun 5, 2016
Unknown Or OtherCrash
WHILE DRIVING IN A PARKING LOT, THE BRAKES WERE PRESSED TO SLOW DOWN THE CAR TO TURN INTO A PARKING LANE. HOWEVER, INSTEAD OF BRAKING THE CAR ACCELERATED. THE BRAKES WERE PRESSED AGAIN, AND THE CAR CONTINUED TO ACCELERATE. THE CAR FINALLY STOPPED, APPROXIMATELY MIDWAY DOWN THE PARKING LANE. AS A RESULT, MY MOTHER AND I WERE INVO…
Read full complaint
WHILE DRIVING IN A PARKING LOT, THE BRAKES WERE PRESSED TO SLOW DOWN THE CAR TO TURN INTO A PARKING LANE. HOWEVER, INSTEAD OF BRAKING THE CAR ACCELERATED. THE BRAKES WERE PRESSED AGAIN, AND THE CAR CONTINUED TO ACCELERATE. THE CAR FINALLY STOPPED, APPROXIMATELY MIDWAY DOWN THE PARKING LANE. AS A RESULT, MY MOTHER AND I WERE INVOLVED IN A MINOR CAR ACCIDENT.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2015 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration