Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
2725–50K
2550–75K
3075–100K
38100–150K
29150K+
237 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports2 fire reports26 injury reports
What owners actually said
422 reports
Mileage unknown · Apr 8, 2025
Service Brakes
Toyota installed known faulty brake booster and master cylinder systems in Prius C models manufactured 2012-2014. Knowing these systems would fail, but not wanting to pay for their mistake, they created a basically secret "extended warranty program" for owners to get their brake booster replaced ONLY IF for a specific 2 year tim…
Read full complaint
Toyota installed known faulty brake booster and master cylinder systems in Prius C models manufactured 2012-2014. Knowing these systems would fail, but not wanting to pay for their mistake, they created a basically secret "extended warranty program" for owners to get their brake booster replaced ONLY IF for a specific 2 year time frame their brakes failed with a certain DTC code. Knowing that many prius owners would not actually receive the notification nor had driven their vehicle enough miles for the braking system to fail, they got away without having to correct their issue. The brakes literally just fail and stop working in the middle of the highway, causing extreme safety concerns and accidents with no responsibility from Toyota.
NHTSA ODI #11653450
Mileage unknown · Apr 2, 2025
Service Brakes
Brake system went out suddenly making the car brakes not work
NHTSA ODI #11652358
Mileage unknown · Mar 29, 2025
Electrical System
The accelerator wasn’t pushing down after I turned a corner then the lights in attached photo appeared. The power inverter needs to be replaced and since my car had the J0V software update in 2/2019, and the recall update came out in 3/2019, it was not linked to my vin as it should’ve been. The update to J0V (attached) should ha…
Read full complaint
The accelerator wasn’t pushing down after I turned a corner then the lights in attached photo appeared. The power inverter needs to be replaced and since my car had the J0V software update in 2/2019, and the recall update came out in 3/2019, it was not linked to my vin as it should’ve been. The update to J0V (attached) should have been posted w my vin, correct? They are fixing it under customer support but refuse to tow it or give me rental bc they are saying it isn’t a recall issue, when the document below says it applies to all cars that needed J0V. I want to be sure all cars that had recall service before the March2019 update get this update linked to their vin.
NHTSA ODI #11651487
Mileage unknown · Mar 27, 2025
Service Brakes
Subject: Safety Complaint – 2012 Toyota Prius Brake Booster Failure (C1391 Code) I am writing to formally report a serious safety defect in my 2012 Toyota Prius involving the brake system. Recently, my vehicle’s dashboard displayed the ABS, traction control, and brake warning lights, indicating a critical braking issue. Upon dia…
Read full complaint
Subject: Safety Complaint – 2012 Toyota Prius Brake Booster Failure (C1391 Code) I am writing to formally report a serious safety defect in my 2012 Toyota Prius involving the brake system. Recently, my vehicle’s dashboard displayed the ABS, traction control, and brake warning lights, indicating a critical braking issue. Upon diagnostic testing at a Toyota dealership, the vehicle was found to have DTC Code C1391 – Brake Booster Leak/Accumulator Failure. I later discovered that Toyota acknowledged this defect and issued a Customer Support Program (CSP) to cover repairs. However, I was never notified, despite always servicing my vehicle at Toyota dealerships. When I contacted Toyota, they confirmed that my vehicle has been flagged in their system, yet I was never received anything in the mail about the potential brake failure. Toyota initially set the CSP expiration in 2023, later extending it to May 2025, but they have refused to repair my vehicle under this program. The estimated repair cost is $4,680.09 along with a diagnostic fee of 206.09, which is a significant financial burden for an issue stemming from a known manufacturing defect. Most importantly, this is a major safety hazard: My brakes now produce a loud hissing sound when pressed, indicating imminent failure. If the brake booster fails completely, it could result in a loss of braking power, endangering myself, passengers, and others on the road. Numerous Prius owners have reported similar failures, yet Toyota has not issued a formal recall. I urge NHTSA to investigate this defect further and push Toyota to issue a full recall instead of a limited support program that many owners were unaware of. Given the life-threatening nature of brake failure, Toyota should not be allowed to limit coverage or deny repairs for a problem they have long recognized. I respectfully request that NHTSA take action to ensure Toyota addresses this safety defect responsibly.
NHTSA ODI #11651221
Mileage unknown · Mar 25, 2025
Insert, Padding
The styrofoam padding of the headrest came unglued from the plastic base of the headrest. This was discovered when removing fabric to wash the fabric. Car was not driving at the time.
NHTSA ODI #11650537
Mileage unknown · Mar 19, 2025
Service Brakes
My break actuator goes off every 12 seconds continuously. There is no warning sign in the dash board. Brought the vehicle to the Toyota dealership and had it checked out. The dealership says there is no problems according to their analysis. But the actuator continuously goes off every 12 seconds and the dealership said this was …
Read full complaint
My break actuator goes off every 12 seconds continuously. There is no warning sign in the dash board. Brought the vehicle to the Toyota dealership and had it checked out. The dealership says there is no problems according to their analysis. But the actuator continuously goes off every 12 seconds and the dealership said this was "normal" and charged me the service fee. I am seriously concerned because I drive this car with my child and I am reading that this is a bad sign and that the breaks might fail at any time. Since the dashboard doesn't give me a warning sign and the dealership says there's no problems based on their diagnostics, even if everyone can hear the actuator go off ever 12 seconds I guess I can safely drive this vehicle...it seems like driving a ticking disaster waiting to happen.
NHTSA ODI #11649360
Mileage unknown · Mar 16, 2025
Service Brakes
Brakes failed
NHTSA ODI #11648561
Mileage unknown · Mar 16, 2025
Service Brakes
ABS pump and master cylinder malfunction. Pump is running very often. Hard braking makes it sound abnormally.
NHTSA ODI #11648555
106,019 miles · Mar 6, 2025
Service Brakes, HydraulicTraction Control System
The contact owns a 2012 Toyota Prius. The contact stated while driving 60 MPH, there was an abnormal grinding sound coming from the brakes while the brake pedal was depressed. The brakes, the traction control, and the ABS warning lights were illuminated. The vehicle was then taken to an independent mechanic where it was diagnose…
Read full complaint
The contact owns a 2012 Toyota Prius. The contact stated while driving 60 MPH, there was an abnormal grinding sound coming from the brakes while the brake pedal was depressed. The brakes, the traction control, and the ABS warning lights were illuminated. The vehicle was then taken to an independent mechanic where it was diagnosed with brake booster and master cylinder assembly failure. The vehicle was not repaired for the most recent failure. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 106,019.
NHTSA ODI #11646751
Mileage unknown · Feb 18, 2025
Service Brakes
I accidentally slid out into traffic as my brakes failed as I pulled up to stop at the edge of the parking lot. I was nearly hit driver's side on a pickup. Fortunately, it was able to swerve around me and there was no immediate following vehicle. I was able to pull out and back into a nearby parking lot to address the problem wi…
Read full complaint
I accidentally slid out into traffic as my brakes failed as I pulled up to stop at the edge of the parking lot. I was nearly hit driver's side on a pickup. Fortunately, it was able to swerve around me and there was no immediate following vehicle. I was able to pull out and back into a nearby parking lot to address the problem with my brakes. Upon speaking to my mechanic and local Toyota Dealership I was informed that the brake booster/accumulator had failed and that this was a known issue on my vehicle. Toyota extended a special warranty on these parts several times but did not notify owners of the safety risk. That warranty coverage has expired for my vehicle. I believe it is an inherent safety risk and they obscured it by covering the parts under this extended warranty. I believe they should be recalled and at the least owners should be warned of the risks. All communications were done over the phone or in person, I have no electronic records. I submitted an identical request on my 2011 Prius by accident, as I used it's VIN when I meant to use the VIN on my 2012 Prius. Regardless, I am now concerned for my safety in both vehicles.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2012 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration