IllustrationLOST FRONT BRAKES COMPLETELY DRIVING DOWN ROAD. I WAS ABLE TO SLOW CAR WITH MANUAL BRAKE ON SHIFTER IN CONJUNCTION WITH REAR BRAKES. A SERIOUS ISSUE.
2012 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2012 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
2725–50K
2550–75K
3075–100K
38100–150K
29150K+
237 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports2 fire reports26 injury reports
Service Brakes complaints
182 reportsWHEN BRAKING DURING NORMAL DRIVING CONDITIONS, A MIXTURE OF CITY AND HIGHWAY, THE CAR MAKES A SOUND LIKE THE ABS IS KICKING IN. WHEN COMING TO A STOP, THE NOISE PERSISTS UNTIL RELEASING THE BRAKE PEDAL. SHORTLY AFTER THIS STARTED, THE ABS, TRACTION CONTROL, AND BRAKE WARNING LIGHTS CAME ON. I TOOK THE VEHICLE TO MY LOCAL TOYOTA …
Read full complaint
WHEN BRAKING DURING NORMAL DRIVING CONDITIONS, A MIXTURE OF CITY AND HIGHWAY, THE CAR MAKES A SOUND LIKE THE ABS IS KICKING IN. WHEN COMING TO A STOP, THE NOISE PERSISTS UNTIL RELEASING THE BRAKE PEDAL. SHORTLY AFTER THIS STARTED, THE ABS, TRACTION CONTROL, AND BRAKE WARNING LIGHTS CAME ON. I TOOK THE VEHICLE TO MY LOCAL TOYOTA DEALERSHIP WHERE I WAS TOLD IT WAS THE BRAKE ACTUATOR NEEDED REPLACE AT THE COST OF $3600. MY 2012 PRIUS ONLY HAS 76K MILES ON IT.
VEHICLE STABILITY CONTROL, ANTI-LOCK BRAKE, AND TRACTION CONTROL LIGHTS INTERMITTENTLY TURN OFF. A FEW TIMES IT SHUT DOWN THE HYBRID SYSTEM AND TELL ME TO STOP . NOW ALL THOSE LIGHTS ARE ALL ON AND I AM DRIVING WITHOUT VSS, ABS AND TRACTION CONTROL. BRAKING IS GETTING HARDER. I TOOK IT TO THE DEALER AND THEY TOLD ME THE COST…
Read full complaint
VEHICLE STABILITY CONTROL, ANTI-LOCK BRAKE, AND TRACTION CONTROL LIGHTS INTERMITTENTLY TURN OFF. A FEW TIMES IT SHUT DOWN THE HYBRID SYSTEM AND TELL ME TO STOP . NOW ALL THOSE LIGHTS ARE ALL ON AND I AM DRIVING WITHOUT VSS, ABS AND TRACTION CONTROL. BRAKING IS GETTING HARDER. I TOOK IT TO THE DEALER AND THEY TOLD ME THE COST IS $3500. I DID SOME RESEARCH AND FOUND OUT THAT THIS IS A KNOWN PRIUS PROBLEM PROBLEM
ON JULY 28, 2017, I WAS DRIVING ALONG WITH MY THREE CHILDREN. I PULLED INTO A DRIVEWAY TO PARK MY VEHICLE BEHIND A PARKED VEHICLE. THERE WAS APPROXIMATELY A 2 FOOT SPAN BETWEEN THE BACK OF THE VEHICLE AND THE FRONT OF MY 2012 TOYOTA PRIUS. TO THE RIGHT OF THE PARKED VEHICLE WAS A PARKED TRUCK. BEING THAT I WAS PULLING INTO A…
Read full complaint
ON JULY 28, 2017, I WAS DRIVING ALONG WITH MY THREE CHILDREN. I PULLED INTO A DRIVEWAY TO PARK MY VEHICLE BEHIND A PARKED VEHICLE. THERE WAS APPROXIMATELY A 2 FOOT SPAN BETWEEN THE BACK OF THE VEHICLE AND THE FRONT OF MY 2012 TOYOTA PRIUS. TO THE RIGHT OF THE PARKED VEHICLE WAS A PARKED TRUCK. BEING THAT I WAS PULLING INTO A SPACE TO PARK MY VEHICLE, I WAS TRAVELING EXTREMELY SLOWLY. I BEGAN TO PRESS ON MY BRAKE TO PARK THE VEHICLE AND INSTANTLY KNEW THERE WAS A PROBLEM. UPON DEPRESSING THE BRAKE, SEVERAL LIGHTS BEGAN TO FLASH WITHIN THE DASH TO INCLUDE BUT NOT LIMITED TO THE ABS, WARNING LIGHT, AND THE LIGHT WITH VEHICLE SWERVE LINES. OTHER LIGHTS WERE ALSO FLASHING, BUT I DO NOT RECALL EACH ONE. THE BRAKE PAD INSTANTLY WENT STRAIGHT TO THE FLOOR WITH NO PRESSURE. THE VEHICLE WOULD NOT STOP AND CONTINUED TO TRAVEL FORWARD WITH ACCELERATION. TO AVOID HITTING THE VEHICLE IN FRONT OF ME I BEGAN TO TURN MY WHEEL TO THE RIGHT. THE VEHICLE CONTINUED TO ACCELERATE AND CAME INTO CONTACT WITH THE TRUCK THAT WAS TO MY FRONT-RIGHT. MY PRIUS FAILED TO SLOW OR STOP. IT CONTINUED TO ACCELERATE AND BEGAN PUSHING THE TRUCK UP THE DRIVEWAY AND INTO THE METAL GARAGE DOOR WITH THE BRAKE PEDAL BEING DEPRESSED THE ENTIRE TIME. EVENTUALLY, THE CAR CAME TO A STOP AND THE LIGHTS CONTINUED TO FLASH PRIOR, DURING, AND AFTER THE INCIDENT. AFTER THE CAR WAS TOWED TREAD WHEEL MARKS WERE FOUND ON THE DRIVEWAY WHERE THE WHEELS SPUN AND LEFT AN IMPRINT IN THE ASPHALT. I AND MY CHILDREN WERE UNINJURED HOWEVER, THE INCIDENT WAS INCREDIBLY TRAUMATIC. THE VEHICLE WAS DEEMED A TOTAL LOSS BY MY INSURANCE COMPANY AND AS OF YET TO BE PROCESSED FOR DIAGNOSTIC TESTING BY TOYOTA. THE TOYOTA CARE SERVICE WAS INFORMED OF THE ACCIDENT. TOYOTA BELIEVES IT TO BE ASSOCIATED WITH THE INTELLIGENCE COMPONENT OF THE VEHICLE, HOWEVER DETERMINATION IS CURRENTLY UNKNOWN UNTIL DIAGNOSTIC IS PERFORMED.
WHILE DRIVING THE VEHICLE ON A DRY SURFACE STREET, THE "CHECK HYBRID SYSTEM" LIGHT ILLUMINATED. THE BRAKE PEDAL FELT LIKE I HAD TO APPLY MORE PRESSURE TO STOP AND IT SEEMED TO TRAVEL FURTHER TOWARD THE FLOORBOARD THAN NORMAL.
I RECEIVED THE WARNING, PLEASE CHECK HYBRID SYSTEM. AFTER CHECKING THE DTC THE FOLLOWING CODE APPEARED ON THE COMPUTER: P0A08:DC/DC CONVERTER CIRCUIT STATUS WHICH INDICATES AN INVERTER PROBLEM. LOOKING AT THE RECALL WEBSITE USING VIN NUMBER, SHOWED NO RECALL CONCERNING THIS. THE PROBLEM HAPPENED MANY TIMES WHILE DRIVING ON A C…
Read full complaint
I RECEIVED THE WARNING, PLEASE CHECK HYBRID SYSTEM. AFTER CHECKING THE DTC THE FOLLOWING CODE APPEARED ON THE COMPUTER: P0A08:DC/DC CONVERTER CIRCUIT STATUS WHICH INDICATES AN INVERTER PROBLEM. LOOKING AT THE RECALL WEBSITE USING VIN NUMBER, SHOWED NO RECALL CONCERNING THIS. THE PROBLEM HAPPENED MANY TIMES WHILE DRIVING ON A CITY OR A HIGHWAY
FOR SOME TIME I HAVE NOTICED THAT WHEN BRAKING, IF MY CAR HIT A BUMP, THE BRAKES WOULD DISENGAGE FOR A SECOND OR TWO EVEN IF THE BRAKE PEDAL WAS FULLY PRESSED, AND THE CAR WOULD LURCH FORWARD UNTIL THE BRAKES REENGAGED. IT WAS A SIMILAR SENSATION TO HYDROPLANING, EVEN THOUGH IT WOULD OCCUR ON A DRY ROAD. THE ANTILOCK BRAKING SYS…
Read full complaint
FOR SOME TIME I HAVE NOTICED THAT WHEN BRAKING, IF MY CAR HIT A BUMP, THE BRAKES WOULD DISENGAGE FOR A SECOND OR TWO EVEN IF THE BRAKE PEDAL WAS FULLY PRESSED, AND THE CAR WOULD LURCH FORWARD UNTIL THE BRAKES REENGAGED. IT WAS A SIMILAR SENSATION TO HYDROPLANING, EVEN THOUGH IT WOULD OCCUR ON A DRY ROAD. THE ANTILOCK BRAKING SYSTEM LIGHT WOULD BE ON WHILE THE BRAKES WERE OUT, AND I AM TOLD THAT THE BRAKE LIGHTS ON THE BACK OF MY CAR ALSO WERE ON, BUT NO BRAKE FUNCTION FOR A SECOND OR TWO. A FEW DAYS AGO I WAS BRAKING AT A STOPLIGHT IN NORMAL WEATHER CONDITIONS AND THE BRAKES DID NOT WORK AT ALL. I HAD TO STOP THE CAR USING THE EMERGENCY BRAKE. THE MECHANIC HAS BEEN UNABLE TO FIND ANYTHING WRONG WITH THE CAR. MY CAR ONLY HAS 30K MILES ON IT AND HAS BEEN WELL-MAINTAINED.
PIVOT BOLT INSIDE STEERING WHEEL CAME LOOSE, WAS WARNED IT HAD DROPPED TO WHERE IT COULD INTERFERE WITH BRAKE LINKAGES. FILED COMPLAINT WITH TOYOTA AND NEVER HEARD BACK SO FILING THIS COMPLAINT. (1) A LARGE BOLT INSIDE A SEALED AREA SHOULD NOT BE ABLE TO COME LOOSE IF INSTALLED CORRECTLY (MANUFACTURING ERROR - SINGLE INSTANCE…
Read full complaint
PIVOT BOLT INSIDE STEERING WHEEL CAME LOOSE, WAS WARNED IT HAD DROPPED TO WHERE IT COULD INTERFERE WITH BRAKE LINKAGES. FILED COMPLAINT WITH TOYOTA AND NEVER HEARD BACK SO FILING THIS COMPLAINT. (1) A LARGE BOLT INSIDE A SEALED AREA SHOULD NOT BE ABLE TO COME LOOSE IF INSTALLED CORRECTLY (MANUFACTURING ERROR - SINGLE INSTANCE OR SYSTEMATIC?) AND (2) A LOOSE BOLT SHOULD NOT BE A RISK FOR A POSSIBLE CATASTROPHIC OUTCOME - LOSS OF BRAKES (DESIGN FLAW, LINKAGES SHOULD NOT BE SUSCEPTIBLE TO BEING JAMMED - THAT'S WHAT THEY WARNED ME ABOUT WHEN THEY ASKED FOR THE $330 TO FIX IT). THIS WAS DISCOVERED WHEN I TOOK THE VEHICLE IN FOR REGULAR SERVICING, THEY TOLD ME THE STEERING FELT FUNNY.
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE VEHICLE HESITATED PRIOR TO ACCELERATING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE VEHICLE HESITATED PRIOR TO ACCELERATING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE DRIVING 20 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO ENGAGE. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AWAY …
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE DRIVING 20 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO ENGAGE. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE CRASH SCENE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Official recalls
618V684000 · Hybrid Propulsion System
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
16V487000 · Air Bags:side/window
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V123000 · Equipment:other:labels
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.