Service Brakes. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

37 crash reports7 fire reports16 injury reports

What owners actually said

518 reports

24,000 miles · Jul 26, 2013

TiresWheelsCrashInjury

WAS DRIVING A 2011 PRIUS WITH JUST UNDER 25,000 MILES ON OCTOBER 18, 2012 ON A 2 LANE HIGHWAY. A REAR TIRE SIDEWALL BLEW OUT. THERE WAS A ROLLOVER END FOR END DOWN A VERY STEEP AND LONG DITCH. THERE WERE SEVERE BACK INJURIES. *TR

NHTSA ODI #10532003

56,000 miles · Jul 10, 2013

Visibility

Read full complaint

I WAS DRIVING ON INTERSTATE 20 WITH MY WIFE WHEN THE SUNROOF EXPLODED. THERE ARE TWO PANES OF GLASS AND THE EXTERIOR PANE SENT SHARDS OF GLASS OUT ONTO THE HIGHWAY. THE INTERNAL PANE OF GLASS STAYED IN PLACE BUT SOME SHARDS OF GLASS FELL ON MY WIFE AND MYSELF. THE TOYOTA DEALER SAYS THIS WAS DUE TO A CRACK FROM DEBRIS WHICH HIT THE CAR AND COMPROMISED THE INTEGRITY OF THE SUNROOF. THEY COULD NOT PROVE OR SHOW ANY MARK INDICATING THIS AS A FACT. IT WAS A VERY SCARY SITUATION AND I FEEL OUR SUNROOF WAS MATERIALLY FLAWED AND TOYOTA SHOULD BE RESPONSIBLE FOR THE PROBLEM. *TR

NHTSA ODI #10524176

Mileage unknown · May 23, 2013

Electrical SystemElectronic Stability Control (esc)Service Brakes

Read full complaint

VEHICLE LOSES BRAKING FUNCTION WHILE TRAVELING OVER POTHOLES, RECESSED MANHOLE COVERS, AND ALL OTHER TYPES OF ROUGH ROAD SURFACES. BRAKING FUNCTION IS DELAYED AND DOES NOT RETURN TO PREVIOUS POWER/BRAKING STRENGTH AFTER TRAVERSING THE OBSTACLE; THIS RESULTS IN THE NEED TO DEPRESS THE BRAKE PEDAL FURTHER TO RE-ENGAGE ENOUGH BRAKING FUNCTION TO STOP THE VEHICLE SAFELY. SERIOUS CONCERN IS THAT IF THE VEHICLE IS UNDER HARD BRAKING AT THE TIME OF THE EVENT WILL THERE BE ENOUGH TRAVEL LEFT IN THE BRAKE PEDAL TO REENGAGE THE BRAKES ENOUGH TO STOP. I HAVE EXPERIENCED THIS REGULARLY, ONE OR MORE TIMES PER MONTH, SINCE I PURCHASED THE CAR. UP UNTIL NOW MOST OCCURRENCES HAVE BEEN JUST A MINOR ANNOYANCE. I RESEARCHED THE PHENOMENON ON THE WEB AND MANY JUST WRITE IT OFF AS A NUISANCE / MINOR QUIRK OF THE VEHICLE SO I ACCEPTED THAT OPINION AND CONTINUED ON ENJOYING THE CAR. THAT IS UNTIL MAY 21, 2013 WHEN UNDER HARD BRAKING (30-35MPH DRIVING SPEED THEN HEAVY BRAKING TO 0MPH) THE VEHICLE TRAVELED OVER A RECESSED MANHOLE COVER AND IT FELT LIKE IT FULLY LOST ALL OF ITS BRAKING POWER AND NEARLY SENT ME INTO THE BACK OF THE VEHICLE STOPPING HARD AHEAD OF ME. I HAD TO FLOOR THE BRAKES BEFORE I FELT ANY BRAKING POWER RETURN AFTER THE BUMP. THIS ISSUE WILL LEAD TO AN ACCIDENT IF IT HAS NOT ALREADY. PLEASE KEEP AN EYE ON IT. *TR

NHTSA ODI #10513264

36,000 miles · May 18, 2013

Electronic Stability Control (esc)Service Brakes

HAPPEN TWICE HIT THE BRAKES FAIRLY HARD ON ROUGH PAVEMENT NOT REAL ROUGH DIDN'T BOUNCE JUST FELT LIKE I WAS ON ICE NOTHING THERE JUST A SECOND OR SO BUT FELT LIKE A LONG TIME IF A CAR WOULD HAVE BEEN IN FRONT OF ME DON'T KNOW IF I COULD HAVE STOPPED IN TIME. *TR

NHTSA ODI #10512632

30,000 miles · May 2, 2013

Exterior Lighting

WITHIN 2 YEARS OF PURCHASING NEW 2011 PRIUS VEHICLE, HID HEADLIGHT LAMP FAILED. *TR

NHTSA ODI #10510462

40 miles · May 2, 2013

Exterior Lighting

WITHIN 2 YEARS OF PURCHASING NEW 2011 PRIUS VEHICLE, BOTH HID HEADLIGHT LAMPS FAILED (ON DIFFERENT OCCASIONS) WITHIN ABOUT 3 MONTHS OF EACH OTHER. NO WARRANTY AVAILABLE, AT CUSTOMER EXPENSE. *TR

NHTSA ODI #10510461

25,434 miles · Apr 8, 2013

Service Brakes

I WAS APPLYING MY BRAKES AS I WAS GOING DOWN A SLIGHT INCLINE OVER A BRIDGE THAT IS UNDER CONSTRUCTION SO THE ROAD IS BUMPY. THE CAR ACTED LIKE THE GAS WAS APPLIED INSTEAD OF THE BRAKES. IT LURCHED FORWARD A LITTLE BEFORE THE BRAKES FULLY ENGAGED. *TR

NHTSA ODI #10507516

17,000 miles · Mar 31, 2013

Service Brakes

Read full complaint

I HAVE EXPERIENCED BRAKE ISSUES WITH MY 2011 PRIUS MODEL SINCE I LEASED THE CAR IN DECEMBER 2011. WHEN I AM TRAVELING AT LOW SPEEDS AND I TRY TO BREAK GOING DOWN HILL AND /OR BREAK OVER A BUMP IN THE ROAD, THE CAR ACCELERATES PRIOR TO FULLY STOPPING. THIS HAS HAPPENED A TOTAL OF 5 TIMES SINCE I LEASED THE VEHICLE. IT ALWAYS SEEMS TO HAPPEN WHILE I TRAVEL AT LOWER SPEEDS AND THE CAR LURCHES FORWARD AS I HIT THE BREAKS. I BELIEVE THIS IS AN ISSUE THAT WAS EXPERIENCED WITH 2010 MODELS OF THE PRIUS AND APPEARS TO BE ANOTHER ACCELERATION ISSUE WITH TOYOTA MODELS IN GENERAL. WHILE THERE HAVE BEEN RECALLS ON THE 2011 PRIUS FOR DEFICIENT AIRBAGS, THIS IS AN EQUALLY CONCERNING FAULT IN THE CAR THAT SHOULD BE REVIEWED. *TR

NHTSA ODI #10505147

40,000 miles · Mar 24, 2013

Service Brakes

Read full complaint

CAR WAS OFF AND PARKED. WHEN I ENTERED THE VEHICLE TO TURN THE CAR ON, I HELD THE BRAKE AND PRESSED THE POWER BUTTON IN ORDER TO START THE CAR. AND WITH MY FOOT STILL ON THE BRAKE, I SHIFTED THE CAR INTO REVERSE TO PULL OUT OF THE PARKING SPOT. AS SOON AS THE CAR WAS SHIFTED INTO REVERSE, THE CAR MOVED BACKWARDS WITH MY FOOT FULLY PRESSED ON THE BRAKE. THE CAR FELT LIKE THE BRAKES WERE NOT ENGAGED. I LOOKED DOWN TO MAKE SURE I WAS PRESSING ON THE BRAKE, AND THE BRAKE WAS COMPLETELY DEPRESSED. I COULD EVEN FEEL THE HILL ASSIST THRESHOLD BUT THE BRAKES WERE NOT ENGAGING. IN A PANIC I PRESSED THE "P" (PARK) BUTTON TO TRY TO STOP THE VEHICLE. THE VEHICLE ROCKED BACK AND FORTH AS IF THE VEHICLE WAS IN MOTION WHEN THE "P" BUTTON WAS PRESSED. I GOT OUT OF THE VEHICLE TO SEE IF I WAS ON A POTHOLE OR HILL, ANYTHING TO EXPLAIN THE MOVE, BUT NOTHING WAS THERE, COMPLETELY FLAT ROAD. THIS HAS HAPPEN QUITE A FEW TIMES WHEN AT A PARK AND I HAD TO CONTACT CDSP OVER ELECTRONIC ISSUES OVER THIS VEHICLE. I AM NO LONGER GOING TO CONTINUE WITH THIS VEHICLE. *TR

NHTSA ODI #10504303

2,156 miles · Mar 13, 2013

Service BrakesVehicle Speed Control

Read full complaint

FIRST INCIDENT: WAS TRAVELING APPROX. 68 MPH ON 405 FREEWAY IN LOS ANGELES (DOWNHILL INTO THE SAN FERNANDO VALLEY). DRY CONDITIONS. ATTEMPTED TO STOP AS CARS AHEAD OF ME BEGAN TO SLOW/HALT AND CAR LURCHED FORWARD, CARRYING ME TO ALMOST HIT THE CAR AHEAD OF ME, STOPPING ONLY INCHES BEHIND. DEALERSHIP COULD NOT REPLICATE AND DISMISSED MY CONCERNS. MULTIPLE SIMILAR INCIDENTS ALL IN GOOD WEATHER HAVE OCCURRED. MOST RECENTLY ON SURFACE ROAD WITH UNEVEN PAVEMENT, TRAVELING AT LESS THAN 15 MPH. BRAKING FOR STOPPED VEHICLES AHEAD, RESULTED IN CAR LURCHING AHEAD. *TR

NHTSA ODI #10502597

Official recalls

18V684000 · Hybrid Propulsion System

Oct 4, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

Consequence & remedy

Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.

Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

16V487000 · Air Bags:side/window

Jun 30, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

Consequence & remedy

Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.

Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

14V743000 · Seats:front Assembly:seat Heater/cooler

Nov 19, 2014

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence & remedy

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter

Feb 12, 2014

Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

Consequence & remedy

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

Electrical System:software

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Seats

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP23005 · Brake Actuator Valve Wear

Opened Nov 22, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist

The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components

Service Brakes, Hydraulic:power Assist

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP19004 · Brake Actuator Valve Wear

Opened Sep 30, 2019 · Closed Jan 21, 2021

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist

On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.