2011 Toyota Prius

The contact owns a 2011 Toyota Prius. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, the vehicle had unexpectedly shut off. Additionally, the transmission failed to shift into the intended gear. The vehicle was towed to the local dealer who replaced the catalytic converter, but the failure persisted. The vehicle was towed back to the dealer who diagnosed that the inverter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V053000 (HYBRID PROPULSION SYSTEM, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 117,000.

There were not any prior problem with my 2011 Toyota Prius' brake but it started making air pumping noises when I brake which makes me very nervous to drive my car. A local mechanic confirmed that the problem is the faulty brake booster assembly and pump. Toyota issued Customer Support Program for this problem but covered only up to 10 years from the first date of use. Although my car has less than 120,000 mileage, I have to pay for this repair and it will cost me close to $2500 at a local repair shop! I want to go to Toyota dealership to fix but their cost is going to be even more! According to online research, many Prius owners have this same problem and have to pay out of their own pockets. This is unacceptable. Toyota should put a recall on this problem and cover the repair cost!!

Brake warning came on and wouldn’t go off. Followed by continuous beeping and now the brakes are no longer working properly. You have to force the brake all the way to the ground to even come to a rolling stop. The problem first occurred on 3/8/25. The brake actuator seems to be a reoccurring problem that Toyota addressed but is no longer fixing. It is dangerous to drive my vehicle and others have said their brakes have completely failed when this problem arose.

My brakes suddenly stopped responding correctly as I was pulling up to a busy road. My car went part way into traffic and I was nearly hit. After speaking to my mechanic and my local Toyota dealership, I was informed that there was a know issue with the Brake Booster and Hydraulic Accumulator on this vehicle and that Toyota had extended the warranty several times but that it no longer covered my vehicle. They never once acknowledged the safety issue and I was never notified of the risk. I believe the extended warranty was setup to avoid a recall and hide the risk. I firmly believe a recall should be done on these parts and owners should be notified of known safety risks this presents.

While driving on the interstate, the "brake", "TCS", and "ABS" lamps lit up. The brake pedal was stiff and couldn't be depressed. The vehicle initially did not decelerate while attempting to push down on the brake pedal. While maneuvering off the interstate on to the exit lane, the pedal remained stiff however, the vehicle did begin to decelerate. Critically, the amount of time needed to bring the vehicle to a stop was significantly longer than normal. This brake failure could have resulted in a catastrophic, life threatening and/or deadly accident. The DTC associated with this brake booster and pump failure is C1391 which is referenced in TSB-0024-19. This is a known problem that exists in Priuses manufactured between 2010-2015 and addressed by Toyota with CSP(s). The CSP takes a reactive approach to this serious safety concern as owners who "have not experienced the condition described" were informed that "there is no action necessary at this time". The extended warranty of 10 years or 150,000 miles is not applicable to countless drivers who are experiencing this failure caused by "internal malfunctions" outside of this arbitrary time/mileage frame. A letter was sent to the NHTSA on 9/19/19 by the president of Claremont and Capistrano Toyota to petition for the initiation of a Defect Investigation regarding this issue. The letter notes that this brake defect is "causing crashes that are injuring people- and Toyota is mishandling it". The advisor assigned to this repair estimated that they see this issue 1-2 times a month and increasingly, drivers are not covered by the CSP. Toyota is failing to take a proactive approach to this dangerous safety issue by telling owners to essentially wait and see if they experience this failure and then failing to take responsibility for said costly failure should it occur outside of their arbitrary time/mileage frame. This approach to safety is egregious, irresponsible, and unethical and it is putting countless lives at risk.

In 11/2024, I started experiencing intermittent noises coming from the engine compartment of my 2011 Toyota Prius. The initial sound resembled the buzzing noise generated when first starting the vehicle. Then the noise started to persist for extended periods after the vehicle was turned off. It would oscillate between buzzing for approximately 10 seconds & remaining dormant for about 1 minute, repeating this cycle. The duration of these cycles could extend for up to 20 minutes. Concurrently, I experienced several instances where the brake pedal would abruptly become stiff & difficult to press. Notably, no warning lights were illuminated on the dashboard. Recognizing these symptoms as unusual, I conducted online research and discovered that the issue could potentially stem from a malfunction in the “brake booster pump and assembly.” Given the potential for a loss of braking power and the risk of personal/public safety, I scheduled a diagnostic inspection at Toyota of Poway, Poway, CA, on 12/18/2024. It confirmed the presence of a problem with the brake booster pump and associated components. In light of this diagnosis, I made the decision to refrain from driving the vehicle until the repairs were completed. The repair costs amounted to $3,475.47. I found I had received a notification from Toyota’s Customer Support Program, designated as “Customer Support Program Notification-ZJB.” This notification explicitly acknowledged this defect & provided a repair coverage policy that stipulated a coverage policy of which I’m no longer entitled to. Despite not meeting the eligibility criteria for the repair coverage program, I am deeply troubled by the fact that this recognized defect persists in vehicles currently on the road, such as mine, without any corresponding recall action and subsequent repair costs covered by Toyota. Fortunately, I was spared from any accidents as a direct consequence of this issue. Many similar complaints here support this dangerous issue!

The contact owns a 2011 Toyota Prius. The contact stated while driving at various speeds, the vehicle lost motive power temporarily. The contact stated that upon depressing the accelerator pedal, the vehicle continued driving; however, the vehicle was operating on gasoline. The contact related the failure to NHTSA Campaign Number: 18V684000 (Hybrid Propulsion System). The vehicle was taken to the dealer for the recall repair. The dealer determined that the hybrid battery needed to be replaced. The dealer provided an estimate for the repair. The contact declined to pay for the repair and advised the dealer to perform the recall repair; however, the dealer failed to acknowledge the recall. The vehicle was not repaired. Additionally, the contact stated while driving 25 MPH downhill, the vehicle stalled. The check engine and several unknown warning lights were illuminated. The contact was able to restart the vehicle, and the contact pulled into the driveway of the nearby residence. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 116,000.

All brake lights on Dashboard came on. Almost got into an accident because brakes were not responding. Brakes started responding but lights remained on. At time it will contibue to beep and Brakes do not respond. I am seeing that this is a common issue happening to most Prius vehicles after a certain period. It is extremely expensive to repair. Since this is happening on quite a lot of Prius vehicles, I feel this should still be covered by Toyota. This appears to be a faulty Brake Pump and Brake Booster. This has not been inspected by a dealer but being that the car is a 2011, I'm afraid they will decline from what I have been reading.

Attached is a report from the Florida Attorney General's project office. Vehicle front headlight bulbs burn out prematurely and frequently and without warning causing reduced visibility at night on dark roads. This is a common and on-going problem for Toyota and other manufacturers and me. Toyota recognized this and issued its own recall ending in 2019, but my car was missed. The 'fix' for me is advice that I should drive my car with high beams on, but in bad weather or on-coming traffic this fix is also a safety hazard. My fear is that one night both bulbs will go out and I will be unable to see the roadway. My car is available for inspection. Constantly replacing bulbs has been and continues to be an expensive issue.