NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
262 reportsClear category filterMileage unknown · Jun 1, 2023
Forward Collision AvoidanceService Brakes
Three lights appeared on the dashboard…code C1391. This has affected the braking system, and the traction control…and the brakes no longer regenerate the battery. The mechanic said “YOU MUST NOT DRIVE THIS CAR” until a $2,700 repair is made. There was, apparently, a service bulletin sent out in 2019, and was then extended until …
Read full complaint
Three lights appeared on the dashboard…code C1391. This has affected the braking system, and the traction control…and the brakes no longer regenerate the battery. The mechanic said “YOU MUST NOT DRIVE THIS CAR” until a $2,700 repair is made. There was, apparently, a service bulletin sent out in 2019, and was then extended until 2022…which we did not receive, although we’ve been at the same address since we bought the car. But our car did not develop this common issue until now…2023, and Toyota says it was not a safety recall, so they don’t need to fix it, or help us get it fixed. We believe it IS obviously a safety issue….since my brakes can go out at any moment.
NHTSA ODI #11524788
105,000 miles · May 16, 2023
Service Brakes
On April 25, 2023 I started my Prius and as soon as I braked I knew something was not right. I noted that warning light were on. When I pushed on brake pedal, the resistance was very soft for about 2 inches of pedal travel. At that point the brakes grabbed very quickly. I drove to the Toyota dealership (Huntington Beach Toyota) …
Read full complaint
On April 25, 2023 I started my Prius and as soon as I braked I knew something was not right. I noted that warning light were on. When I pushed on brake pedal, the resistance was very soft for about 2 inches of pedal travel. At that point the brakes grabbed very quickly. I drove to the Toyota dealership (Huntington Beach Toyota) and was informed later that day that the master and pump master cylinder needed to be replaced. The dealer said that Toyota did have a program to replace these assemblies, but had not issued a recall, which (in my opinion) it should have. I've had quite a few cars, most of which lasted for more than 200,000 miles. I've never had such a failure nor have I heard of one. Clearly there was a manufacturing defect that should have required a recall.
NHTSA ODI #11522335
133,000 miles · Apr 29, 2023
Service Brakes
Brake actuator failed while driving down the road on Friday, 04/14/2023. The car became hard to slow down/brake. Brake light, traction control light, ABS warning lamp came on, and tire pressure lamp came on. Next day lights went out. Then again all lights as above came on while driving down the highway. That was Wednesday 04/1…
Read full complaint
Brake actuator failed while driving down the road on Friday, 04/14/2023. The car became hard to slow down/brake. Brake light, traction control light, ABS warning lamp came on, and tire pressure lamp came on. Next day lights went out. Then again all lights as above came on while driving down the highway. That was Wednesday 04/18/2033. Took to Toyota dealership who confirmed brake actuator had failed. Car has 133,000 miles on it. Prius was in the repair shop at Norton Toyota of Tulsa, OK, from Thursday 04/27/2023 until Saturday 04/29/2023.
NHTSA ODI #11519612
128,435 miles · Apr 13, 2023
Service Brakes
on 4/12/2023, I was driving near an intersection and the e-brake and abs light both came on and the brakes on my car were suddenly twice as hard to apply, with a "soft" feeling to them. I was able to pull into a nearby brakes plus location. My younger sister and friend were in the car at the time. The problem has been reported b…
Read full complaint
on 4/12/2023, I was driving near an intersection and the e-brake and abs light both came on and the brakes on my car were suddenly twice as hard to apply, with a "soft" feeling to them. I was able to pull into a nearby brakes plus location. My younger sister and friend were in the car at the time. The problem has been reported by a Toyota dealership in California. The component was inspected by a repair associate at Brakes Plus and he confirmed that the electric brake booster on my prius was shot. There were zero warning signs of the problem prior to the incident.
NHTSA ODI #11516943
120,000 miles · Mar 6, 2023
Service Brakes
Brake booster and brake booster pump failure
NHTSA ODI #11510445
Mileage unknown · Mar 4, 2023
Service Brakes
It is very unfortunate that the brake booster extended warranty was declined by Tustin of Toyota specially after having my vehicle in their hands for another recall when the warranty was active. This is something I can not wrap my head around. I would like to speak to someone in regards to this dealer. Who can I speak with?
NHTSA ODI #11510163
Mileage unknown · Jan 18, 2023
Service Brakes
Reporting an issue related to Toyota's CUSTOMER SUPPORT PROGRAM BULLETIN (ZJB): REPAIR COVERAGE FOR BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES ON CERTAIN 2010 MY PRIUS AND CERTAIN 2010 MY PRIUS PHV VEHICLES. Finally got a C1391 error with the respective dash lights. Increased hissing/pumping was occuring from the brake …
Read full complaint
Reporting an issue related to Toyota's CUSTOMER SUPPORT PROGRAM BULLETIN (ZJB): REPAIR COVERAGE FOR BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES ON CERTAIN 2010 MY PRIUS AND CERTAIN 2010 MY PRIUS PHV VEHICLES. Finally got a C1391 error with the respective dash lights. Increased hissing/pumping was occuring from the brake assembly for about a year before hand until the code/lights happened. Customer Support Program Bulletin is closed but hoping it reopens.
NHTSA ODI #11502405
Mileage unknown · Jan 14, 2023
Electrical SystemService Brakes
After approximately 6 1/2 years of owning this 2011 Toyota Prius Hybrid (purchased in 2012), the brake pedal went completely to the floor and there was no braking. The brake fluid was completely FULL. Intermittently, this would occur, but brakes would come back operational in a few minutes. In 2022, the brake lights on dashboard…
Read full complaint
After approximately 6 1/2 years of owning this 2011 Toyota Prius Hybrid (purchased in 2012), the brake pedal went completely to the floor and there was no braking. The brake fluid was completely FULL. Intermittently, this would occur, but brakes would come back operational in a few minutes. In 2022, the brake lights on dashboard started lighting up intermittently and go off. I had the complete brake pads, etc. replaced in June 2022. Last 1/2 of 2022 the entire brake dash lit up. I got into Toyota dealership 1/12/2023. They said the complete brake Master Cyclinder and Brake Pump replacement was required. They got the dash lights off. This car has only 133,023 miles. I finally checked the internet to see this is a TOYOTA issue! A recall on this brake assembly should be issued! I was unaware of this 5 years ago. This could cause a serious accident and should be fixed at Toyota's expense!
NHTSA ODI #11501780
Mileage unknown · Jan 11, 2023
Service Brakes
As I'm sure you have heard from the numerous complaints on the internet the ABS on this vehicle is having issues. The repair is over 3,000 dollars. Toyota needs to recall this brake pump. I can't pay 3,000$ to stay safe in my vehicle. They made a defective part and were somehow allowed to extend the warranty instead of re…
Read full complaint
As I'm sure you have heard from the numerous complaints on the internet the ABS on this vehicle is having issues. The repair is over 3,000 dollars. Toyota needs to recall this brake pump. I can't pay 3,000$ to stay safe in my vehicle. They made a defective part and were somehow allowed to extend the warranty instead of recall it. My vehicle is under the mileage but over the years so I was pretty much told too bad. This needs to be addressed at a actual road safety level which is why I am writing you. Thank you for your time.
NHTSA ODI #11501295
Mileage unknown · Jan 11, 2023
Service Brakes
ABS actuator and pump failing, which requires much harder pushing on the brake pedal to come to a complete stop. This part is supposed to last for the lifetime of the car and is now failing roughly 11 years after purchase. I took it to the Toyota dealership and was quoted $2,500 to repair it.
NHTSA ODI #11501196
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration