NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
262 reportsClear category filter167,000 miles · Jun 27, 2019
Service Brakes
THE EMERGENCY BRAKE LIGHT, ABS, AND TRACTION LIGHTS ILLUMINATED ON THE DASHBOARD. TOOK THE CAR INTO THE DEALER AND THEY REPORTED THAT THE BRAKE BOOSTER AND MASTER CYLINDER NEEDED TO BE REPLACED. THE CAR WAS STATIONARY WHEN THE LIGHTS INITIALLY CAME ON AND THE LIGHTS STAYED ON WHILE IT WAS MOVING (HIGHWAY AND CITY STREETS). …
Read full complaint
THE EMERGENCY BRAKE LIGHT, ABS, AND TRACTION LIGHTS ILLUMINATED ON THE DASHBOARD. TOOK THE CAR INTO THE DEALER AND THEY REPORTED THAT THE BRAKE BOOSTER AND MASTER CYLINDER NEEDED TO BE REPLACED. THE CAR WAS STATIONARY WHEN THE LIGHTS INITIALLY CAME ON AND THE LIGHTS STAYED ON WHILE IT WAS MOVING (HIGHWAY AND CITY STREETS). THE 2010 TOYOTA PRIUS WAS RECALLED FOR THE SAME PROBLEM. IT SEEMS THE 2011 CONTINUES TO HAVE THE SAME PROBLEM.
NHTSA ODI #11222966
169,000 miles · Jun 13, 2019
Service Brakes
MY CAR WAS PARKED ON THE STREET,I GOT INTO IT, TURNED IT ON, SHIFTED TO DRIVING AND STARTED PROCEEDING FORWARD. I THEN NOTICED 3 LIGHTS (THE ABS LIGHT, BRAKE LIGHT, AND TRACTION CONTROL LIGHT) SUDDENLY APPEARED ON THE DASHBOARD. NOTHING OUT OF THE ORDINARY OCCURRED PRIOR TO THE LIGHT COMING ON, IT JUST SUDDENLY APPEARED. …
Read full complaint
MY CAR WAS PARKED ON THE STREET,I GOT INTO IT, TURNED IT ON, SHIFTED TO DRIVING AND STARTED PROCEEDING FORWARD. I THEN NOTICED 3 LIGHTS (THE ABS LIGHT, BRAKE LIGHT, AND TRACTION CONTROL LIGHT) SUDDENLY APPEARED ON THE DASHBOARD. NOTHING OUT OF THE ORDINARY OCCURRED PRIOR TO THE LIGHT COMING ON, IT JUST SUDDENLY APPEARED. THE ERROR CODE IN THE COMPUTER SYSTEM READ C1391. THE DETAILS READ THERE WAS "ABNORMAL LEAK IN ACCUMULATOR". THE CAR NO LONGER DRIVES SAFELY. IF THE BRAKES ARE PRESSED SUDDENLY THE CAR SKIDS INSTEAD OF SLOWING DOWN. IN ORDER FOR THE CAR TO COME TO A COMPLETE STOP A LOT MORE PRESSURE HAS TO BE APPLIED TO THE BRAKE COMPARED TO BEFORE ABS PROBLEM. THE STOPPING DISTANCE HAS INCREASED BY APPROXIMATELY TWICE ITS LENGTH. THE CAR IS NO LONGER CAPABLE OF SHARP TURNS, THE BACK END OF THE CAR SKIDS DANGEROUSLY LEFT OR RIGHT WHILE TURNING, DEPENDING ON THE DIRECTION THE DRIVER IS TURNING. THE BRAKING, HANDLING AND CONTROL OF THE CAR DECREASES SO MUCH WHEN THE ROADS ARE WET THAT AT TIMES THE CAR SKIDS EVEN WHEN GOING AT A CAUTIOUS SPEED IN RAIN. FOR MY SAFETY AND FOR OTHERS I DRIVE IN "B" INSTEAD OF "D" WHEN IT RAINS.
NHTSA ODI #11219901
180,000 miles · May 26, 2019
Electronic Stability Control (esc)Service Brakes
BRAKE LIGHT, ANTILOCK LIGHT, VEHICLE STABILITY LIGHT, AND YELLOW TRAINS CAME ON. HAVING PROBLEM WITH BRAKING. DOES NOT NOT SEEM TO BRAKE AS GOOD. IT IS VERY DANGEROUS WHEN DRIVING.
NHTSA ODI #11210091
Mileage unknown · May 14, 2019
Service BrakesUnknown Or Other
THE FOLLOWING DASHBOARD LIGHTS CAME ON ON OUR VEHICLE AT THE SAME TIME:TRACTION MODE, EMERGENCY BRAKE, ABS, AND BRAKE SYSTEM WARNING LIGHT. SINCE THE LIGHTS HAVE CAME ON, I HAVE NOTICED THAT I HAVE TO PRESS DOWN FURTHER DOWN ON THE BRAKE TO STOP THE VEHICLE. MY STOPPING DISTANCE IS FURTHER NOW AS WELL.
NHTSA ODI #11207630
Mileage unknown · Apr 25, 2019
Power TrainService BrakesVehicle Speed Control
WHEN BREAKING AND STILL MOVING, THE CAR WILL ACCELERATE MOMENTARILY RESULTING IN GOING FASTER FOR A SECOND OR TWO. THIS HAPPENED RANDOMLY OVER THE YEARS AND MAY IN SOME INSTANCES BE RELATED TO HITTING AN IRREGULARITY IN THE ROAD, BUT I CANNOT BE SURE. IT HAS NOT CAUSED AN ACCIDENT, BUT IS STRONG ENOUGH THAT IT COULD. I'M A PRETT…
Read full complaint
WHEN BREAKING AND STILL MOVING, THE CAR WILL ACCELERATE MOMENTARILY RESULTING IN GOING FASTER FOR A SECOND OR TWO. THIS HAPPENED RANDOMLY OVER THE YEARS AND MAY IN SOME INSTANCES BE RELATED TO HITTING AN IRREGULARITY IN THE ROAD, BUT I CANNOT BE SURE. IT HAS NOT CAUSED AN ACCIDENT, BUT IS STRONG ENOUGH THAT IT COULD. I'M A PRETTY SAFE DRIVER SO TEND NOT TO RIDE ON THE TAIL OF THE CAR IN FRONT OF ME. I HAVE NOT KEPT TRACK OF WHEN IT HAPPENS.
NHTSA ODI #11203669
Mileage unknown · Apr 7, 2019
Electronic Stability Control (esc)Service BrakesSteering
THE CAR STOP WORKING ALL THE DASH LIGHTS STOP WORKING ,THE BRAKES START GETTING HARDER AND THE DON'T STOP AT ALL AND BEEPING WITHOUT STOP THAT NOISE AND THE HIBRYD SYSTEM STOP WORKING AFTER I LIVING FOR SOME RECALLS REPAIRS AND THE WANT ME TO FIX THE CAR TO PAY AND I KNOW IS NOT MY FAULT EVERYTHING IS BECAUSE IS THIS CAR IS ALL …
Read full complaint
THE CAR STOP WORKING ALL THE DASH LIGHTS STOP WORKING ,THE BRAKES START GETTING HARDER AND THE DON'T STOP AT ALL AND BEEPING WITHOUT STOP THAT NOISE AND THE HIBRYD SYSTEM STOP WORKING AFTER I LIVING FOR SOME RECALLS REPAIRS AND THE WANT ME TO FIX THE CAR TO PAY AND I KNOW IS NOT MY FAULT EVERYTHING IS BECAUSE IS THIS CAR IS ALL ELECTRONIC SYSTEM.NEVER ON MY LIVE I HAVE THIS PROBLEM WITH MY OTHER CARS.ONLY WITH THIS ONE AND NOW THEY ONE ME TO PAY FOR SOMETHING THE COMPANY MAKES WRONG.THIS IS NOT FAIR AT ALL.BEFORE I WAS RECOMENDED THIS CAR BUT RIGHT NOW PEOPLE ASK ME AND I HAVE TO TALK NEGATIVE SITUATION ABOUT IT.
NHTSA ODI #11194409
30,000 miles · Mar 29, 2019
Service Brakes
WHEN I BRAKE ON AN UNEVEN SURFACE (POTHOLES, BUMPS, ETC) THE CAR WILL SOMETIMES JUMP FORWARDS. I AM UNSURE WHETHER IT IS REFERRED TO AS BRAKES SLIPPING BUT IT IS EXACTLY THE SAME THING THAT I'VE READ HAPPENING TO MANY PEOPLE. IT WAS AN ISSUE IN THE 2010, WHICH LED TO A RECALL, YET THERE IS NO RECALL ON THE 2011. IT DOESN'T MA…
Read full complaint
WHEN I BRAKE ON AN UNEVEN SURFACE (POTHOLES, BUMPS, ETC) THE CAR WILL SOMETIMES JUMP FORWARDS. I AM UNSURE WHETHER IT IS REFERRED TO AS BRAKES SLIPPING BUT IT IS EXACTLY THE SAME THING THAT I'VE READ HAPPENING TO MANY PEOPLE. IT WAS AN ISSUE IN THE 2010, WHICH LED TO A RECALL, YET THERE IS NO RECALL ON THE 2011. IT DOESN'T MAKE ANY SENSE, PEOPLE HAVE SAID THAT THE ACTUATOR WAS THE PART THAT NEEDED REPLACING, YET IT IS A $3-4K PART AND SHOULD NOT BE LEFT UP TO THE CONSUMER. THIS IS A SAFETY ISSUE AND IS A KNOWN PROBLEM AND NEEDS TO BE ADDRESSED BY TOYOTA. IT HAS BEEN HAPPENING EVER SINCE I'VE OWNED THE CAR. I HAVE BEEN LUCKY SO FAR THAT IT HASN'T ACCELERATED ME INTO ANOTHER CAR OR PERSON.
NHTSA ODI #11192342
4,000 miles · Mar 28, 2019
Service Brakes
WHILE DEPLOYING BRAKES IF YOU GO OVER BUMPS THEY FAIL TO BRAKE PROPERLY. FEELS LIKE A SPEED UP. THIS HAS HAPPENED NUMEROUS TIME WHILE BRAKING FOR TRAFFIC LIGHT OR MAKING TURNS.
NHTSA ODI #11192179
90,000 miles · Mar 21, 2019
Service Brakes
ALL OF THE BRAKE LIGHTS ON MY DASH LIT UP, BRAKES WEREN'T WORKING WELL, TOOK IT TO THE REPAIR SHOP AND WAS TOLD IT WAS MY BRAKE ACTUATOR.
NHTSA ODI #11190607
47,000 miles · Mar 7, 2019
Service Brakes
I'M CONSTANTLY HEARING A BARKING/ PURGING NOISE COMING FROM THE BRAKE ACCUMULATOR PUMP WHENEVER I DO HARD BRAKING. WHENEVER I HIT POTHOLES OR ROUGH ROADS, THE CAR WOULD STILL ROLLS DURING BRAKING AS IF THE ABS IS GETTING TRIGGERED. I WAS QUOTED BY TOYOTA DEALER OF AN ESTIMATE OF $3000 TO REPLACE THE BRAKE ACCUMULATOR PUMP AND BO…
Read full complaint
I'M CONSTANTLY HEARING A BARKING/ PURGING NOISE COMING FROM THE BRAKE ACCUMULATOR PUMP WHENEVER I DO HARD BRAKING. WHENEVER I HIT POTHOLES OR ROUGH ROADS, THE CAR WOULD STILL ROLLS DURING BRAKING AS IF THE ABS IS GETTING TRIGGERED. I WAS QUOTED BY TOYOTA DEALER OF AN ESTIMATE OF $3000 TO REPLACE THE BRAKE ACCUMULATOR PUMP AND BOOSTER. I'M AFRAID THAT THE BRAKES WOULD FAIL WHILE DRIVING.
NHTSA ODI #11184751
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration