IllustrationLIGHTS KEEP GOING OUT. I'VE REPLACED 5 TIMES IN THE LAST YEAR. STILL KEEP GOING OUT EVERY 2 TO 3 MONTHS.
2011 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2011 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
4125–50K
4450–75K
5075–100K
74100–150K
49150K+
330 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports7 fire reports16 injury reports
Exterior Lighting complaints
48 reportsTL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING AT A LOW SPEED, THE HEADLAMPS FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
I OWN A 2011 TOYOTA PRIUS WHICH I PURCHASED IN NOVEMBER OF THAT YEAR FROM ARLINGTON TOYOTA IN ARLINGTON, VA. SINCE THAT TIME I HAVE HAD TO REPLACE THE HEADLIGHTS THREE TIMES. AS OF NOV 2015, THE CAR HAD 29,105 MILES ON IT WHICH INDICATES I DO NOT PUT A LOT OF MILES ON THE CAR. ON ALL THREE OCCASIONS, BOTH LOW BEAMS WERE INOPER…
Read full complaint
I OWN A 2011 TOYOTA PRIUS WHICH I PURCHASED IN NOVEMBER OF THAT YEAR FROM ARLINGTON TOYOTA IN ARLINGTON, VA. SINCE THAT TIME I HAVE HAD TO REPLACE THE HEADLIGHTS THREE TIMES. AS OF NOV 2015, THE CAR HAD 29,105 MILES ON IT WHICH INDICATES I DO NOT PUT A LOT OF MILES ON THE CAR. ON ALL THREE OCCASIONS, BOTH LOW BEAMS WERE INOPERABLE WHEN I STARTED THE CAR. FORTUNATELY, I WAS NOT ON THE ROAD DRIVING. ON EVERY OCCASION, THE DEALER TOLD ME THE BULBS WERE BURNED OUT. THE MOST RECENT OCCURRENCE WAS THE NIGHT OF SEPT 10, 2015. THIS TIME THE DEALER TOLD ME TOYOTA HAS A WIRING SOLUTION THAT WOULD EXTEND THE LIFE OF THE HEADLIGHTS, BUT THAT I WOULD HAVE TO PAY FOR IT. THE "SOLUTION" WOULD BE EXPENSIVE. I TOLD THEM THAT STATEMENT TELLS ME THERE IS A DEFECT IN THE WIRING OR ELECTRICAL SYSTEM, AND THE FIX SHOULD BE PAID FOR BY TOYOTA UNDER A RECALL NOTICE. I HAVE NOTED THAT PRIUS OWNERS HAVE BEEN COMPLAINING OF THIS SAME ISSUE SINCE 2007 AND A RECALL HAD HAPPENED IN 2011 FOR EARLIER YEAR CARS. THE PROBLEM REMAINS, AND THERE IS DEFECT IN THE CAR'S WIRING OR PERFORMANCE. GIVEN THE CURRENT VW DIESEL FIASCO, I HOPE THIS ISSUE CAN BE ADDRESSED BY THE NHSTA AND FORCE TOYOTA TO PROVIDE SAFE LIGHTING TO US PRIUS OWNERS.
I WAS PULLED OVER BY THE POLICE, (WHILE ON A VILLAGE STREET) BECAUSE MY HEADLIGHT BULB WAS BURNED OUT. (AGAIN!) I HAVE HAD 4 HEADLIGHT BULBS REPLACED ON THE 2011 PRIUS AND IT IS ONLY 4 YEARS OLD! TOYOTA HAS A TECHNICAL SERVICE BULLETIN ON THE WIRING HARNESS, THAT SHORTS OUT THE BULBS PREMATURELY, BUT NO RECALL. PLEASE RECALL THE…
Read full complaint
I WAS PULLED OVER BY THE POLICE, (WHILE ON A VILLAGE STREET) BECAUSE MY HEADLIGHT BULB WAS BURNED OUT. (AGAIN!) I HAVE HAD 4 HEADLIGHT BULBS REPLACED ON THE 2011 PRIUS AND IT IS ONLY 4 YEARS OLD! TOYOTA HAS A TECHNICAL SERVICE BULLETIN ON THE WIRING HARNESS, THAT SHORTS OUT THE BULBS PREMATURELY, BUT NO RECALL. PLEASE RECALL THE PRIUS FOR THE WIRING HARNESS, SO I CAN STOP GETTING PULLED OVER BY THE POLICE! 09\15 THANK YOU! *TR
TOYOTA PRIUS 3 HEADLIGHTS QUIT WORKING ON LOW BEAM WITHOUT ANY INDICATION UPON STARTING CAR. IT APPEARS THAT IF ONE BULB BURNS OUT, BOTH HEADLIGHTS FAIL TO WORK, POSSIBLY DUE TO THE OTHER HEADLIGHT SHORTING OUT THE WORKING HEADLIGHT. EACH TIME THE LIGHTS HAVE WORKED JUST A FEW HOURS BEFORE AND WHEN WE RETURN TO CAR, THEY WILL NO…
Read full complaint
TOYOTA PRIUS 3 HEADLIGHTS QUIT WORKING ON LOW BEAM WITHOUT ANY INDICATION UPON STARTING CAR. IT APPEARS THAT IF ONE BULB BURNS OUT, BOTH HEADLIGHTS FAIL TO WORK, POSSIBLY DUE TO THE OTHER HEADLIGHT SHORTING OUT THE WORKING HEADLIGHT. EACH TIME THE LIGHTS HAVE WORKED JUST A FEW HOURS BEFORE AND WHEN WE RETURN TO CAR, THEY WILL NOT TURN ON.THIS HAS OCCURRED APPROX 3 TIMES NOW FORCING US TO DRIVE SIGNIFICANT DISTANCES WITH HIGH BEAMS ON. LIGHTS APPEAR TO WORK OK AFTER REPLACEMENT OF BOTH BULBS. PLEASE ISSUE A REPAIR RECALL TO FIX THIS ISSUE WHICH LEAVES A DRIVER WITH ABSOLUTELY NO LIGHTS.
VIN # [XXX] TOYOTA PRIUS 2011, DRIVING ON INTERSTATE 80 EAST, AT 65 MPH, SMOKE CAME OUT OF THE HOOD, HEADLIGHT AND WIRE SMELLED AND BURNED, CAR WAS ALMOST IN FIRE. SHUT OFF CAR AND HEADLIGHT AND SMOKE STOP. BOTH HEADLIGHT ARE DAMAGE DUE TO FIRE. KEPT BOTH HEAD LIGHT OFF, GOT HOME AND DID NOT USE THE CAR FOR A FEW MONTHS. CAR IS…
Read full complaint
VIN # [XXX] TOYOTA PRIUS 2011, DRIVING ON INTERSTATE 80 EAST, AT 65 MPH, SMOKE CAME OUT OF THE HOOD, HEADLIGHT AND WIRE SMELLED AND BURNED, CAR WAS ALMOST IN FIRE. SHUT OFF CAR AND HEADLIGHT AND SMOKE STOP. BOTH HEADLIGHT ARE DAMAGE DUE TO FIRE. KEPT BOTH HEAD LIGHT OFF, GOT HOME AND DID NOT USE THE CAR FOR A FEW MONTHS. CAR IS STILL UNDER WARRANTY BUT DEALER REFUSE TO REPAIR THE PROBLEM, TELLING ME I HAVE USE AN AFTERMARKET BULB. THE BULB THAT CAUSE THE PROBLEM WAS THE BULB THAT CAME WITH THE CAR AS NEW. I TRIED TO TAPE UP THE BURNED WIRE TO GET THE CAR SAFETY HOME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
BOTH HEAD LIGHTS STOPPED WORKING AT THE SAME TIME, ONLY HIGH BEAM WILL WORK, REGULAR BEAM STOPPED WORKING AND WILL NOT COME BACK ON. *TR
DRIVING IN RAIN IN DARK ON UNLIT ROAD. BOTH FRONT HEADLIGHTS WENT OUT. NOTHING WOULD MAKE THEM COME BACK ON - TURNING LIGHTS OFF AND ON, TURNING CAR OFF AND ON. VERY SCARY. VERY CLOSE TO DRIVING OFF ROAD INTO DITCH. THIS MUST BE A RECALL. TOYOTA AS USUAL WILL DENY THE PROBLEM SO THE NHTSA MUST ACT. *TR
THE HEADLAMPS BURNED OUT ON VEHICLE START-UP FOR THE FIFTH TIME IN 73,451 MILES. THE HEADLAMP BULBS LAST AN AVERAGE OF 14,700 MILES. I WEAR LATEX GLOVES AND AM CRITICALLY CAREFUL TO NEVER TOUCH THE BULBS, BUT THE ESSENCE OF THE PROBLEM IS THAT THE CAR CLEARLY HAS A POORLY REGULATED POWER SUPPLY THAT STRESSES THE BULBS AT START-…
Read full complaint
THE HEADLAMPS BURNED OUT ON VEHICLE START-UP FOR THE FIFTH TIME IN 73,451 MILES. THE HEADLAMP BULBS LAST AN AVERAGE OF 14,700 MILES. I WEAR LATEX GLOVES AND AM CRITICALLY CAREFUL TO NEVER TOUCH THE BULBS, BUT THE ESSENCE OF THE PROBLEM IS THAT THE CAR CLEARLY HAS A POORLY REGULATED POWER SUPPLY THAT STRESSES THE BULBS AT START-UP. MY PREVIOUS 2006 PRIUS ATE HID BULBS, SO I INTENTIONALLY PURCHASED A 2011 MODEL VARIANT THAT USED CONVENTIONAL HALOGEN BULBS TO ESCAPE THE CONSTANT BULB FAILURE ISSUES WITH PRIUS. TO NO AVAIL. CONSTANTLY BURNING OUT HEADLAMPS IS A CONTINUING TOYOTA SAFETY HAZARD THAT NHTSA NEEDS TO FINALLY ADDRESS. *TR
WEDNESDAY APRIL 30 2014 I WENT TO CHURCH, WHEN I CAME OUT AND GOT BACK IN MY CAR LIGHT WAS OUT. THEY WERE BURNING. *TR
Official recalls
618V684000 · Hybrid Propulsion System
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
16V487000 · Air Bags:side/window
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.