NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,822 reports53,000 miles · May 25, 2017
Vehicle Speed ControlCrash
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE PARKING THE VEHICLE, IT UNEXPECTEDLY ACCELERATED AND STRUCK ANOTHER VEHICLE BEFORE CRASHING INTO AN APARTMENT UNIT. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE…
Read full complaint
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE PARKING THE VEHICLE, IT UNEXPECTEDLY ACCELERATED AND STRUCK ANOTHER VEHICLE BEFORE CRASHING INTO AN APARTMENT UNIT. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS CALLED AND PROVIDED THE CONTACT WITH AN INVESTIGATOR WHO REMOVED A BOX FROM THE VEHICLE, WHICH WOULD DETERMINE IF THE FAILURE WAS DUE TO DRIVER ERROR OR A SAFETY DEFECT. THE MANUFACTURER DETERMINED THAT IT WAS DRIVER ERROR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 53,000.
NHTSA ODI #10991685
Mileage unknown · May 22, 2017
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 30-40 MPH, THE CONTACT CRASHED INTO THE REAR OF A POLICE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S CHEST AND FACE STRUCK THE STEERING WHEEL. THE CONTACT RECEIVED INJURIES TO THE CLAVICLE AREA, SHOULDERS, FACE, EYES, HEAD/BRAIN, AND NECK AREA. EXTENS…
Read full complaint
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 30-40 MPH, THE CONTACT CRASHED INTO THE REAR OF A POLICE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S CHEST AND FACE STRUCK THE STEERING WHEEL. THE CONTACT RECEIVED INJURIES TO THE CLAVICLE AREA, SHOULDERS, FACE, EYES, HEAD/BRAIN, AND NECK AREA. EXTENSIVE MEDICAL ATTENTION WAS NEEDED. THE VEHICLE WAS NOT TOWED; HOWEVER, A POLICE REPORT WAS FILED THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG SENSOR WAS MISSED BY A COUPLE OF MILLIMETERS, WHICH PREVENTED THEM FROM DEPLOYING. THE VEHICLE WAS DEEMED TOTALED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. UPDATED 07/13/17*LJ *JS
NHTSA ODI #10990891
140,000 miles · May 17, 2017
Electronic Stability Control (esc)
BECAUSE OF,AS DEALERSHIP SAID,THE CAR WAS STALLED AT THE HIGHWAY. I DON'T HAVE ANY STICKER ABOUT RECALL, BUT MOST PRIUS 2010 OWNERS SAID THAT OWNERS RECEIVING NOTIFICATION ABOUT INVERTER PROBLEM. I'M HEADING TO THE DEALERSHIP, WHO OFFERED ME TO FIX THE CAR FOR $3,500. COULD YOU PLEASE TAKE A LOOK, DO I HAVE ANY WARRANTY OR RECAL…
Read full complaint
BECAUSE OF,AS DEALERSHIP SAID,THE CAR WAS STALLED AT THE HIGHWAY. I DON'T HAVE ANY STICKER ABOUT RECALL, BUT MOST PRIUS 2010 OWNERS SAID THAT OWNERS RECEIVING NOTIFICATION ABOUT INVERTER PROBLEM. I'M HEADING TO THE DEALERSHIP, WHO OFFERED ME TO FIX THE CAR FOR $3,500. COULD YOU PLEASE TAKE A LOOK, DO I HAVE ANY WARRANTY OR RECALLS ON THIS PARTICULAR VEHICLE PLEASE. THANK YOU.
NHTSA ODI #10986159
60,000 miles · May 16, 2017
Service Brakes
WHEN DRIVING OVER BUMPY OR ROUGH SURFACES OR POT HOLES, WHILE APPLYING THE BRAKES, THE BRAKES OFTEN SEEM TO STOP WORKING. AND THE CAR SEEMS TO HAVE A LITTLE BOOST FORWARD. IT HAPPENS WHEREVER THE ROAD SURFACE HAS BUMPY AREAS ON STRAIGHTAWAYS OR CURVES. AND MOSTLY WHEN APPLYING LIGHT PRESSURE TO THE BREAK, LIKE SLOWING FOR AN UPC…
Read full complaint
WHEN DRIVING OVER BUMPY OR ROUGH SURFACES OR POT HOLES, WHILE APPLYING THE BRAKES, THE BRAKES OFTEN SEEM TO STOP WORKING. AND THE CAR SEEMS TO HAVE A LITTLE BOOST FORWARD. IT HAPPENS WHEREVER THE ROAD SURFACE HAS BUMPY AREAS ON STRAIGHTAWAYS OR CURVES. AND MOSTLY WHEN APPLYING LIGHT PRESSURE TO THE BREAK, LIKE SLOWING FOR AN UPCOMING TURN. IT HAS BEEN HAPPENING SINCE I GOT THE CAR IN 2013. I HAVE TAKEN IT TO A MECHANIC, BUT THEY COULDN'T FIND THE PROBLEM. THIS HAS HAPPENED MANY TIMES OVER LAST 3 1/2 YEARS.
NHTSA ODI #10986058
148,000 miles · May 10, 2017
Unknown Or OtherFire
THIS CAR FIRE BURNED
NHTSA ODI #10984796
Mileage unknown · May 4, 2017
Service Brakes
I AM THE ORIGINAL OWNER OF A 2010 PRIUS. WITHIN THE FIRST MONTH, I CONTACTED TOYOTA, COMPLAINING OF THE BRAKES, WHICH WERE NOT CONSISTENTLY SMOOTH. IN GENERAL, THE BRAKES WORK FINE, BUT IF I HIT A BUMP OR DITCH, THE BRAKES SUDDENLY STOP WORKING FOR A SPLIT SECOND, AND THE CAR FEELS LIKE IT IS LURCHING FORWARD, BEFORE THE BRAKE…
Read full complaint
I AM THE ORIGINAL OWNER OF A 2010 PRIUS. WITHIN THE FIRST MONTH, I CONTACTED TOYOTA, COMPLAINING OF THE BRAKES, WHICH WERE NOT CONSISTENTLY SMOOTH. IN GENERAL, THE BRAKES WORK FINE, BUT IF I HIT A BUMP OR DITCH, THE BRAKES SUDDENLY STOP WORKING FOR A SPLIT SECOND, AND THE CAR FEELS LIKE IT IS LURCHING FORWARD, BEFORE THE BRAKES SUDDENLY START WORKING AGAIN. TOYOTA SERVICE WAS NEVER ABLE TO "REPRODUCE" THE PROBLEM, AND EVENTUALLY I GAVE UP. A COUPLE YEARS AGO, THE CAR WAS RECALLED FOR THIS PROBLEM, AND I BROUGHT THE CAR IN TO BE FIXED. UNFORTUNATELY, THE RECALL WORK HAS NOT REMEDIED THE PROBLEM. THE BRAKES STILL SEEM TO OCCASIONALLY MALFUNCTION WHEN THE CAR DRIVES OVER A ROUGH PATCH. TOYOTA SEEMS TO BELIEVE THE PROBLEM HAS BEEN SOLVED, BUT IT HAS NOT BE SOLVED. THERE IS NO DIFFERENCE SINCE THE RECALL.
NHTSA ODI #10983583
Mileage unknown · May 4, 2017
Air BagsElectrical System
AIRBAG WARNING LIGHT ILLUMINATES. TOYOTA SERVICE TECHIE'S DIAGNOSTIC SHOWED A DISCONNECTED SPIRAL CABLE. TECHIE EXPLAINED THAT THE SPIRAL CABLE HAS ELECTRICAL CONNECTIONS TO THE DRIVER'S AIRBAG MODULE AND THE DRIVER'S AIR BAG WOULD NOT DEPLOY IN AN ACCIDENT. HE SAID I SHOULD INSTALL A NEW CABLE SPIRAL ASSEMBLY KIT (AKA "CLOCK S…
Read full complaint
AIRBAG WARNING LIGHT ILLUMINATES. TOYOTA SERVICE TECHIE'S DIAGNOSTIC SHOWED A DISCONNECTED SPIRAL CABLE. TECHIE EXPLAINED THAT THE SPIRAL CABLE HAS ELECTRICAL CONNECTIONS TO THE DRIVER'S AIRBAG MODULE AND THE DRIVER'S AIR BAG WOULD NOT DEPLOY IN AN ACCIDENT. HE SAID I SHOULD INSTALL A NEW CABLE SPIRAL ASSEMBLY KIT (AKA "CLOCK SPRING"), PART # 8430747020 AT A COST OF NEARLY $1000, INCLUDING OVER $700 FOR THE PART. I DID SOME RESEARCH. PART # 8430747020 WAS INSTALLED IN MANY TOYOTA VEHICLES, AND HAS BEEN RECALLED FOR THE SAME PROBLEM IN THE COROLLA, MATRIX, HIGHLANDER, TACOMA, RAV4, AND YARIS. SEE SAFETY RECALL E0M (E1M) APRIL 2015, UPDATE 5/12/14. THE PRIUS IS NOT MENTIONED IN THE RECALL, ALTHOUGH MY CAR HAS THE SAME EXACT PROBLEM WITH THE IDENTICAL PART, AND THE TOYOTA SERVICE SUPERVISOR AGREES IT IS THE SAME PROBLEM AND PART. I EXPLAINED THIS TO THE SERVICE TECHNICIAN AND SUPERVISOR, WHO CALLED TOYOTA, AND TOYOTA OFFERED TO COVER 50% OF THE COST OF THE PART, AND NONE OF THE LABOR COST. I ASKED WHETHER THEY COULD DO THE SAME FIX IN MY CAR AS THEY DO ON THE RECALLED VEHICLES, NAMELY INSTALLING PART # 04004-07122, AND THEY DECLINED. SEE TECHNICAL INSTRUCTIONS FOR SAFETY RECALL E0M SPIRAL CABLE REPLACEMENT. TOYOTA SHOULD BE RECALLING MY CAR AND FIXING THIS PROBLEM AT THEIR EXPENSE, NOT JUST REDUCING THE COST OF THE PART. SECOND, THEY SHOULD NOT BE REPLACING THIS DEFECTIVE PART WITH THE SAME DEFECTIVE PART. THEY SHOULD DO A FIX THAT WILL LAST. I ASSUME THE FIX THEY'VE DONE ON ALL OTHER VEHICLES, WITH PART # 04004-07122, WOULD WORK FOR MY PRIUS. THEY REFUSE. FYI- THE AIRBAG LIGHT HAS BEEN ON AND OFF FOR YEARS, AND SEEN BY TOYOTA DURING THAT PERIOD. THIS PARTICULAR PROBLEM WAS DIAGNOSED MAY 1, 2017. THEY BELIEVE THE PREVIOUS AIRBAG WARNING LIGHTS WERE UNRELATED TO THIS PARTICULAR ISSUE.
NHTSA ODI #10983573
137,000 miles · May 1, 2017
Structure
WENT TO SWAP THE LICENSE PLATE IN MY PRIUS AFTER REGISTERING IN NEW STATE. BACK LICENSE PLATE BOLT ON UPPER-RIGHT SIDE UNSCREWED PARTIALLY AND THEN THE BOLT HOUSING DETACHED FROM THE VEHICLE. AS A RESULT, THE SCREW CANNOT BE UNSCREWED AND THE LICENSE PLATE CANNOT BE REMOVED. CALLED TOYOTA AND THEY KNEW WHAT I WAS TALKING ABOUT. …
Read full complaint
WENT TO SWAP THE LICENSE PLATE IN MY PRIUS AFTER REGISTERING IN NEW STATE. BACK LICENSE PLATE BOLT ON UPPER-RIGHT SIDE UNSCREWED PARTIALLY AND THEN THE BOLT HOUSING DETACHED FROM THE VEHICLE. AS A RESULT, THE SCREW CANNOT BE UNSCREWED AND THE LICENSE PLATE CANNOT BE REMOVED. CALLED TOYOTA AND THEY KNEW WHAT I WAS TALKING ABOUT. SAID THE REPAIR WOULD TAKE ONE HOUR AND COST $110'FOR A BOLT THAT MALFUNCTIONED. THE VEHICLE ISN'T TECHNICALLY STREET LEGAL NOW AND THEY CAN'T SEE ME FOR SEVERAL DAYS. I SAID THAT I DIDN'T THINK A COMPONENT LIKE THAT SHOULD JUST BREAK OFF, AND I WAS TOLD IT MAY HAVE BEEN A RESULT OF THE WRONG BOLT SIZE BEING USED. THAT'S UNLIKELY AS THIS CAR HAS ONLY EVER SEEN TOYOTA DEALERSHIPS AND THAT WAS WHERE IT WAS PURCHASED. VERY DISAPPOINTED AND IT SOUNDS LIKE TOYOTA KNOWS ABOUT THIS ISSUE.
NHTSA ODI #10981602
1 miles · Apr 30, 2017
EngineService Brakes
THIS AFTERNOON, MY WIFE WAS DRIVING DOWN A TWO LANE, PAVED STREET AT ABOUT 25 MPH. THE STREET HAS A SLIGHT DECLINE AND SHE BEGAN TO APPLY THE BREAKS TO SLOW DOWN SLIGHTLY. JUST A SECOND OR TWO LATER, SHE HIT A SMALL BUMP IN THE ROAD AND THE CAR ACCELERATED (WHILE SHE HAD HER FOOT ON THE BREAK) FOR A FRACTION OF A SECOND. WE DI…
Read full complaint
THIS AFTERNOON, MY WIFE WAS DRIVING DOWN A TWO LANE, PAVED STREET AT ABOUT 25 MPH. THE STREET HAS A SLIGHT DECLINE AND SHE BEGAN TO APPLY THE BREAKS TO SLOW DOWN SLIGHTLY. JUST A SECOND OR TWO LATER, SHE HIT A SMALL BUMP IN THE ROAD AND THE CAR ACCELERATED (WHILE SHE HAD HER FOOT ON THE BREAK) FOR A FRACTION OF A SECOND. WE DIDN'T HEAR THE SOUND OF THE ENGINE REVVING. THANKFULLY, THERE WERE NO OTHER CARS ON THE ROAD AT THIS TIME AND THERE WAS TIME TO PRESS THE BREAK AGAIN. BASED ON LOOKING AROUND ONLINE, MANY PEOPLE HAVE REPORTED SIMILAR ISSUES (HTTP://WWW.CONSUMERREPORTS.ORG/CRO/NEWS/2010/02/TOYOTA-ADDS-2010-PRIUS-BRAKING-PROBLEM-TO-THE-LIST-RECALL-POSSIBLE/INDEX.HTM).
NHTSA ODI #10981509
Mileage unknown · Apr 30, 2017
EngineUnknown Or Other
EXCESSIVE OIL CONSUMPTION STARTING AT 100,000 WHICH WORSENED. I NOW HAVE TO PUT A QUART OF OIL EVERY 750-1000 MILES IN MY 2010 PRIUS. NO ONE AT TOYOTA WILL ADMIT THIS IS A PROBLEM, ALBEIT THERE ARE AN EXTREME AMOUNT OF THESE COMPLAINTS ONLINE THROUGH DIFFERENT BLOGS AND WEB SITES. REALLY, WE TOYOTA OWNERS BOUGHT THIS CAR TO D…
Read full complaint
EXCESSIVE OIL CONSUMPTION STARTING AT 100,000 WHICH WORSENED. I NOW HAVE TO PUT A QUART OF OIL EVERY 750-1000 MILES IN MY 2010 PRIUS. NO ONE AT TOYOTA WILL ADMIT THIS IS A PROBLEM, ALBEIT THERE ARE AN EXTREME AMOUNT OF THESE COMPLAINTS ONLINE THROUGH DIFFERENT BLOGS AND WEB SITES. REALLY, WE TOYOTA OWNERS BOUGHT THIS CAR TO DECREASE OUR CARBON FOOTPRINT...IRONIC, RIGHT?
NHTSA ODI #10981496
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration