NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
287 reportsClear category filter53,000 miles · May 25, 2017
Vehicle Speed ControlCrash
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE PARKING THE VEHICLE, IT UNEXPECTEDLY ACCELERATED AND STRUCK ANOTHER VEHICLE BEFORE CRASHING INTO AN APARTMENT UNIT. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE…
Read full complaint
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE PARKING THE VEHICLE, IT UNEXPECTEDLY ACCELERATED AND STRUCK ANOTHER VEHICLE BEFORE CRASHING INTO AN APARTMENT UNIT. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS CALLED AND PROVIDED THE CONTACT WITH AN INVESTIGATOR WHO REMOVED A BOX FROM THE VEHICLE, WHICH WOULD DETERMINE IF THE FAILURE WAS DUE TO DRIVER ERROR OR A SAFETY DEFECT. THE MANUFACTURER DETERMINED THAT IT WAS DRIVER ERROR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 53,000.
NHTSA ODI #10991685
60,000 miles · Dec 13, 2016
Unknown Or OtherVehicle Speed Control
IN THE PAST YEAR I HAVE HAD 2 OCCURRENCES OF UNINTENDED ACCELERATION. THE FIRST IN FEBRUARY OF 2016. I WAS EXITING A PARKING RAMP UP HILL AND STEPPING ON THE ACCELERATOR. I WAS DRIVING STRAIGHT THEN TURNING TO THE LEFT (90 DEGREE TURN). WHEN I TOOK MY FOOT OFF THE ACCELERATOR, THE CAR CONTINUED TO ACCELERATE AND I WAS UNABLE …
Read full complaint
IN THE PAST YEAR I HAVE HAD 2 OCCURRENCES OF UNINTENDED ACCELERATION. THE FIRST IN FEBRUARY OF 2016. I WAS EXITING A PARKING RAMP UP HILL AND STEPPING ON THE ACCELERATOR. I WAS DRIVING STRAIGHT THEN TURNING TO THE LEFT (90 DEGREE TURN). WHEN I TOOK MY FOOT OFF THE ACCELERATOR, THE CAR CONTINUED TO ACCELERATE AND I WAS UNABLE TO GET IT SLOWED/STOPPED FOR ABOUT A BLOCK EVEN THOUGH I WAS APPLYING HEAVY BRAKE PRESSURE. THE CAR WAS REVVING AGAINST THE BRAKE PRESSURE. NO DAMAGE OR INJURIES OCCURRED. I TOOK THE CAR TO THE DEALERSHIP WHERE I PURCHASED IT (PURCHASE DATE 8/3/13). THEY CHECKED THE CAR OVER AND FOUND NO APPARENT CAUSE FOR THE ACCELERATION. I TOOK THE CAR HOME, AND IT DROVE NORMALLY UNTIL 11/26/16. ON THAT DATE I WAS DRIVING VERY SLOWLY IN A FLAT PARKING LOT, AND THE CAR BEGAN ACCELERATING WITHOUT MY PUSHING THE GAS PEDAL. I WAS DRIVING STRAIGHT AND THEN TURNING TO THE RIGHT (90 DEGREE. I GOT THE CAR STOPPED IN A FEW FEET BY PRESSING EXTREMELY HARD ON THE BRAKE. MY CAR DID NOT HIT ANYTHING. TECHNICIANS FROM THE DEALERSHIP HAVE NOT BEEN ABLE TO FIND A CAUSE AND I HAVE NOT BEEN ABLE TO GET PAST TOYOTA'S CUSTOMER SERVICE DEPARTMENT TO ESCALATE THE ISSUE FOR MORE DETAILED DIAGNOSTICS. I HAVE ATTACHED THE TIMELINE OF TRYING TO GET THE CAR DIAGNOSED AND THE ISSUE ESCALATED AS WELL AS WHY I DON'T THINK USER ERROR IS A FACTOR. *TR
NHTSA ODI #10935037
127,000 miles · Jul 16, 2016
Service BrakesVehicle Speed ControlCrash
I WAS IN A PARKING STRUCTURE GOING APPROXIMATELY 15 MPH WHEN I REMOVED MY FOOT FROM THE ACCELERATOR TO PRESS THE BRAKE. BEFORE I COULD GET MY FOOT TO THE BRAKE, THE CAR QUICKLY ACCELERATED. IT TOOK AT LEAST TWO ATTEMPTS AT PUSHING THE BRAKE PEDDLE BEFORE THE CAR CAME TO A STOP. AND, TO BE HONEST, THE GUARDRAIL THE CAR HIT HELPED…
Read full complaint
I WAS IN A PARKING STRUCTURE GOING APPROXIMATELY 15 MPH WHEN I REMOVED MY FOOT FROM THE ACCELERATOR TO PRESS THE BRAKE. BEFORE I COULD GET MY FOOT TO THE BRAKE, THE CAR QUICKLY ACCELERATED. IT TOOK AT LEAST TWO ATTEMPTS AT PUSHING THE BRAKE PEDDLE BEFORE THE CAR CAME TO A STOP. AND, TO BE HONEST, THE GUARDRAIL THE CAR HIT HELPED ACTUALLY STOP THE VEHICLE. IT WAS TOTALLY UNEXPECTED AND EXTREMELY SCARY. IN HINDSIGHT, I SHOULD HAVE SUSPECTED THAT THERE MAY BE A PROBLEM WHEN I NOTICED THAT SOMETIMES WHEN APPLYING THE BRAKES TO COME TO A STOP THERE WOULD BE A FEELING OF THE BRAKES SLIPPING AND THE CAR LURCHING FORWARD A BIT. THE DEALERSHIP HAD THE CAR TOWED IN TO GET CHECKED OUT, AND I HAVE BEEN TOLD THAT THEY WILL NOTIFY TOYOTA. IN THE MEANTIME I AM CONCERNED ABOUT THE SAFETY OF THIS CAR!
NHTSA ODI #10885303
85,000 miles · May 25, 2016
Electrical SystemService BrakesVehicle Speed ControlCrashInjury
ON 05/25/2016 AT ABOUT 9AM, WHILE IN MOTION AT A RATE OF SPEED APPROX 25 MPH ON A STREET DURING CONSTRUCTION (DON'T KNOW IF THE BUMPY ROAD HAD ANYTHING TO DO WITH IT), THE CHANGE OIL SOON LIGHT APPEARED AND SECONDS LATER ALL THE LIGHTS ON THE DASH CAME ON WITH THE MESSAGE TO CHECK THE "CHECK HYBRID SYSTEM" . I TRIED TO STOP THE …
Read full complaint
ON 05/25/2016 AT ABOUT 9AM, WHILE IN MOTION AT A RATE OF SPEED APPROX 25 MPH ON A STREET DURING CONSTRUCTION (DON'T KNOW IF THE BUMPY ROAD HAD ANYTHING TO DO WITH IT), THE CHANGE OIL SOON LIGHT APPEARED AND SECONDS LATER ALL THE LIGHTS ON THE DASH CAME ON WITH THE MESSAGE TO CHECK THE "CHECK HYBRID SYSTEM" . I TRIED TO STOP THE VEHICLE AND IT KEPT ACCELERATING. I PRESSED ON THE BREAKS REALLY HARD AND THE TRACTION CONTROL LIGHT KEPT FLASHING ON AND OFF LIKE CRAZY BUT IT BARELY HAD ANY IMPACT. ALTHOUGH THE VEHICLE SLOWED, IT DID NOT COME TO A FULL STOP. I ENDED UP HITTING THE VEHICLE IN FRONT OF ME. THANK GOD IT WAS A TRUCK AND AS ABLE TO STOP THE CAR FROM MOVING FURTHER OR I COULD OF ENDED UP IN THE MIDDLE OF AN INTERSECTION. AFTER THE COLLISION, THE CAR WOULD NOT STOP ALTHOUGH THE PARK BUTTON WAS PRESSED AND LIGHT WAS ON. I EVEN TRIED TURNING OFF THE VEHICLE AND THE VEHICLE STAYED ON AND IN DRIVE. I ENDED UP IN THE HOSPITAL AND DON'T KNOW HOW IT EVENTUALLY GOT TURNED OFF BUT THAT WAS VERY FRIGHTENING. I HAD MY CHILDREN IN THE CAR. ON IMPACT, THE SEAT BELTS DID NOT EVEN TIGHTEN.
NHTSA ODI #10870866
187,000 miles · Feb 22, 2016
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
BRAKE BOOSTER PUMP ASSEMBLY VEHICLE IN MOTION WHEN ON HIGHWAY WHEN LOSS OF BREAKING AND STEERING TOOK PLACE. VEHICLE LIGHTED ICONS APPEARED ON DASH ALONG WITH ALARM SOUND. (ABS) (!) (BRAKE) (SS). THIS UNSAFE CONDITION COULD HAVE BEEN AVOIDED IF NHTSA WOULD HAVE FORCED TOYOTA TO RECALL THIS DEFECTIVE PART IN 2013 WHEN TOYO…
Read full complaint
BRAKE BOOSTER PUMP ASSEMBLY VEHICLE IN MOTION WHEN ON HIGHWAY WHEN LOSS OF BREAKING AND STEERING TOOK PLACE. VEHICLE LIGHTED ICONS APPEARED ON DASH ALONG WITH ALARM SOUND. (ABS) (!) (BRAKE) (SS). THIS UNSAFE CONDITION COULD HAVE BEEN AVOIDED IF NHTSA WOULD HAVE FORCED TOYOTA TO RECALL THIS DEFECTIVE PART IN 2013 WHEN TOYOTA NOTIFIED NHTSA OF THE DEFECTIVE BRAKING SYSTEM. OR TOYOTA MAILED NOTICE TO CUSTOMERS AS STATED BACK IN 2013, WHICH PREVENTION COULD PREVENT LOSS OF LIFE OR HARM. OR CLASS ACTION. HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM442011/RCMN-13V235-0909.PDF
NHTSA ODI #10837510
95,000 miles · Feb 21, 2016
Vehicle Speed Control
MY PRIUS SUDDENLY ACCELERATED TODAY. MY WIFE WAS NOT IN AN ACCIDENT. MY VIN IS [XXX]. I SPOKE WITH MY WIFE AND THE INCIDENT OCCURRED UP A HILL WHEN SHE WAS PARKING (DECELERATING), SHE DIDN'T NOTICE THAT THE FLOOR MAT WAS NOT STUCK AT THE TIME AND THERE WAS NO WARNING OF A PROBLEM. ALSO, THIS HAS NOT HAPPENED BEFORE. VEHICLE…
Read full complaint
MY PRIUS SUDDENLY ACCELERATED TODAY. MY WIFE WAS NOT IN AN ACCIDENT. MY VIN IS [XXX]. I SPOKE WITH MY WIFE AND THE INCIDENT OCCURRED UP A HILL WHEN SHE WAS PARKING (DECELERATING), SHE DIDN'T NOTICE THAT THE FLOOR MAT WAS NOT STUCK AT THE TIME AND THERE WAS NO WARNING OF A PROBLEM. ALSO, THIS HAS NOT HAPPENED BEFORE. VEHICLE WAS GOING UP A HILL ON A CITY STREET, NO ICE, GOING STRAIT, NO DAMAGE TO THE CAR, UNKNOWN TO WHAT FAILED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).? *TR
NHTSA ODI #10837378
15,000 miles · Jun 18, 2015
Service BrakesVehicle Speed Control
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE CONTACT DROVE OVER A POTHOLE AND THE VEHICLE VEERED TO THE RIGHT. IN ADDITION, THE VEHICLE ACCELERATED IN EXCESS. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE V…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE CONTACT DROVE OVER A POTHOLE AND THE VEHICLE VEERED TO THE RIGHT. IN ADDITION, THE VEHICLE ACCELERATED IN EXCESS. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 10V039000 (SERVICE BRAKES, AIR). THE FAILURE MILEAGE WAS 15,000.
NHTSA ODI #10725959
53,000 miles · Apr 23, 2015
Vehicle Speed Control
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING AT APPROXIMATELY 20 MPH AND SLOWING DOWN AT A STOP LIGHT, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD WHILE THE RPMS INCREASED AND THE VEHICLE FAILED TO STOP. THE VEHICLE EVENTUALLY CAME TO A STOP. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING AT APPROXIMATELY 20 MPH AND SLOWING DOWN AT A STOP LIGHT, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD WHILE THE RPMS INCREASED AND THE VEHICLE FAILED TO STOP. THE VEHICLE EVENTUALLY CAME TO A STOP. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE WAS EXPERIENCED IN MAY OF 2010 AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.
NHTSA ODI #10712471
180,000 miles · Mar 17, 2015
Exterior LightingVehicle Speed Control
THE HEADLIGHT HID START TO GO ON AND OFF FINALLY THE LEFT SIDE WENT OFF . ALSO WHILE DRIVING THE CAR DESACELERATED AND INCREASED SPEED BY ITSELF. *TR
NHTSA ODI #10694918
55 miles · Feb 12, 2015
Vehicle Speed Control
TODAY FEB 12, 2015 AT APPROXIMATELY 11:40 AM A WHITE SPORTS CAR LICENSE PLATE [XXX] WAS DANGEROUSLY WEAVING IN AND OUT OF CARS AND COULD HAVE CAUSED A CRASH. LOCATION WAS ON REDMOND WAY 202 GOING TOWARDS THE 520 HIGHWAY GOING TOWARDS SEATTLE. THIS PERSON IS A RECKLESS DRIVER, PLEASE KEEP AN EYE OUT FOR THIS CAR. THANK YOU. …
Read full complaint
TODAY FEB 12, 2015 AT APPROXIMATELY 11:40 AM A WHITE SPORTS CAR LICENSE PLATE [XXX] WAS DANGEROUSLY WEAVING IN AND OUT OF CARS AND COULD HAVE CAUSED A CRASH. LOCATION WAS ON REDMOND WAY 202 GOING TOWARDS THE 520 HIGHWAY GOING TOWARDS SEATTLE. THIS PERSON IS A RECKLESS DRIVER, PLEASE KEEP AN EYE OUT FOR THIS CAR. THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10683119
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration