NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
287 reportsClear category filterMileage unknown · Jun 30, 2021
Electrical SystemFuel/propulsion SystemVehicle Speed ControlInjury
Check hybrid system light ignites, slows down vehicle in middle of high speed highway. First incident November of 2020 then several incidents after. Repair shops don't assure problem according to error codes & they recommend possibilities they cannot assure will resolve the problem. Car was taken into local dealership after rece…
Read full complaint
Check hybrid system light ignites, slows down vehicle in middle of high speed highway. First incident November of 2020 then several incidents after. Repair shops don't assure problem according to error codes & they recommend possibilities they cannot assure will resolve the problem. Car was taken into local dealership after receiving recall notice for software and airbags prior to November 2020 when the issue began. Software update took a couple of hours. Restart/reboot temporarily allowed driving again. Most recently the system entirely shut down & the car will not start or run. Abandoned car on side of the road and got heat exhaustion from walking the rest of the way home and had vehicle towed. Error lights come on including "check hybrid system" says "shift to P position when starting" and will not allow start.
NHTSA ODI #11422908
139,000 miles · Oct 4, 2020
Service BrakesVehicle Speed Control
MY CAR IS ACCELERATING WHILE BRAKING. WHENEVER I TRY TO BRAKE ON THE ROAD WHILE CURBING OR STOPPING AT THE TRAFFIC SIGNALS, THE CAR SKIPS/SLIDE FORWARD. IT'S GETTING WORSE ON THE RAINY TIME THOUGH.
NHTSA ODI #11362616
Mileage unknown · Apr 29, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
DEFECT WITHIN THE BRAKE BOOSTER PUMP ASSEMBLY. IF THIS DEFECT OCCURS, VARIOUS WARNING LAMPS ON THE INSTRUMENT PANEL MADE ILLUMINATE, I EXPERIENCE INCREASED STOPPING DISTANCE, REDUCED HYDRAULIC PRESSURE WITHIN YOUR BRAKE SYSTEM, THE DEACTIVATION OF BRAKE ASSIST, AND/OR THE DEACTIVATION OF VEHICLE STABILITY CONTROL. TOYOTA HAS …
Read full complaint
DEFECT WITHIN THE BRAKE BOOSTER PUMP ASSEMBLY. IF THIS DEFECT OCCURS, VARIOUS WARNING LAMPS ON THE INSTRUMENT PANEL MADE ILLUMINATE, I EXPERIENCE INCREASED STOPPING DISTANCE, REDUCED HYDRAULIC PRESSURE WITHIN YOUR BRAKE SYSTEM, THE DEACTIVATION OF BRAKE ASSIST, AND/OR THE DEACTIVATION OF VEHICLE STABILITY CONTROL. TOYOTA HAS PREVIOUSLY ISSUED AT LEAST TWO SAFETY RECALLS ' D0H AND K0L ' DESIGNED TO PREVENT SIMILAR DANGEROUS OCCURRENCES. HOWEVER, HUNDREDS OF THOUSANDS OF GENERATION III PRIUS VEHICLES (2010-2015 MODEL YEARS) WERE EXCLUDED FROM THOSE SAFETY RECALLS.
NHTSA ODI #11322702
125,000 miles · Oct 7, 2019
Vehicle Speed Control
AS I WAS DRIVING ON A ROAD, ABOUT 25 MPH, WHILE MY FOOT WAS ON THE ACCELERATOR PEDAL THE CAR JUST DECREASED IT'S SPEED TO A STOP AS I CONTINUALLY PUSHED MY FOOT ON THE PEDAL.
NHTSA ODI #11266939
213,492 miles · Jun 18, 2019
Electrical SystemFuel/propulsion SystemVehicle Speed Control
CAR WORKED FLAWLESSLY AND WE MAINTAINED IT REGULARLY. TOOK IT IN TO ADDRESS RECALL OF JOV UPDATE PWR MGMT ECU AT DEALER. DEALER COMPLETED RECALL WORK. 2 DAYS LATER ENGINE LITE CHECK HYBRID SYSTEM AND THE ! ON AND TRIANGLE ON. THE CAR CONTINUED RUN BUT NOW WAS STUDDERING WHEN WAS NOT BEFORE THE RECALL WORK. TOOK IT BACK TO T…
Read full complaint
CAR WORKED FLAWLESSLY AND WE MAINTAINED IT REGULARLY. TOOK IT IN TO ADDRESS RECALL OF JOV UPDATE PWR MGMT ECU AT DEALER. DEALER COMPLETED RECALL WORK. 2 DAYS LATER ENGINE LITE CHECK HYBRID SYSTEM AND THE ! ON AND TRIANGLE ON. THE CAR CONTINUED RUN BUT NOW WAS STUDDERING WHEN WAS NOT BEFORE THE RECALL WORK. TOOK IT BACK TO THE DEALER AND HE SAID WE NEED A NEW HYBRID BATTERY. WE BELIEVE THE SOFTWARE UPDATE THEY DID CREATED A THIS ISSUE. DEALER ACTING IGNORANT AND SAYING IT NEEDS NEW BATTERY BECAUSE OF NUMBER OF MILES ON CAR. ASKED FOR DIAGNOSTIC PRINT OUT FROM WHEN THEY DID RECALL WORK TO THEY NEW DIAGNOSIS AND THEY WOULD NOT PROVIDE. WE BELIEVE THE RECALL UPDATE CREATED A TECHNICAL PROBLEM WITH OUR HYBRID BATTERY. WE ALSO BELIEVE THAT DEALER NOT BEING HONEST REGARDING ISSUES WITH THIS RECALL UPDATE AND IS USING IT AS AN OPPORTUNITY TO REDUCE LIABILITY FOR TOYOTA ON FAILED RECALL WORK AND TO USE IT AS AN OPPORTUNITY TO BRING IN LARGE TICKET SALES REPAIR IE THEY QUOTED US A NEW HYBRID BATTERY FOR 5,500.
NHTSA ODI #11221081
191,087 miles · Dec 1, 2018
EnginePower TrainVehicle Speed Control
I HAVE BEEN EXPERIENCING THE SAFETY RISKS OUTLINED IN THE FOLLOWING MANUFACTURER RECALL NUMBER: J1V NHTSA RECALL NUMBER: 18V684 I HAVE BEEN DEALING WITH THIS ISSUE FOR THE PAST 2 - 3 YEARS AND UNKNOWINGLY MAY HAVE BEEN SPENDING HUNDREDS OF DOLLARS ON REPAIRS THAT MAY NOT HAVE NEEDED TO BE REPLACED. CURRENTLY, MY CAR IS NOT R…
Read full complaint
I HAVE BEEN EXPERIENCING THE SAFETY RISKS OUTLINED IN THE FOLLOWING MANUFACTURER RECALL NUMBER: J1V NHTSA RECALL NUMBER: 18V684 I HAVE BEEN DEALING WITH THIS ISSUE FOR THE PAST 2 - 3 YEARS AND UNKNOWINGLY MAY HAVE BEEN SPENDING HUNDREDS OF DOLLARS ON REPAIRS THAT MAY NOT HAVE NEEDED TO BE REPLACED. CURRENTLY, MY CAR IS NOT RUNNING AS I EXPERIENCED A STALL (11/09/2018) WHILE EXITING THE FREEWAY AT A HIGH SPEED WITH THE SCREEN READING "CHECK HYBRID SYSTEM" AND THE DASH LIT UP WITH THE YELLOW TRIANGLE AND EXCLAMATION POINT. I AM NOT ABLE TO ACCELERATE DURING THE STALL, BRAKES ARE WORKING. THIS HAS HAPPENED TO ME COUNTLESS TIMES, ALMOST ALWAYS ON THE FREEWAY OR EXITING AND WHILE TRAVELING AT A HIGH SPEED. SOMETIMES THE VEHICLE WOULD START BACK UP AFTER A FEW MINUTES OF BEING TURNED OFF. THIS PARTICULAR TIME (11/09/2018), I COASTED THE VEHICLE TO A SAFE SPOT AND THE VEHICLE ENGINE NEVER TURNED ON AGAIN. I TOWED THE VEHICLE TO MY RESIDENCE AND THEN TO MY MECHANIC. I AM ONLY ABLE TO PUT THE VEHICLE IN NEUTRAL. THE MOTOR WILL NOT COME ON AT ALL AND THE SCREEN READS "CHECK HYBRID SYSTEM". THE CAR HAD OVER 1/4 TANK OF GAS AT THE TIME. I CURRENTLY USE MY VEHICLE FOR MY LIVELIHOOD DOING INDEPENDENT DELIVERY SERVICES SUCH AS INSTACART, DOORDASH, POSTMATES ETC. SINCE THERE IS YET TO BE A REMEDY FOR THIS SITUATION I WANT TO KNOW WHAT MY OPTIONS ARE TO GET BACK THE MONEY I'VE SPENT OR COMPENSATION FOR THIS VEHICLE SINCE IT IS NOT USABLE AND UNABLE TO BE FIXED BY THE MANUFACTURER IN A TIMELY MANNER. I CAN PROVIDE DOCUMENTATION IN REGARDS TO REPAIRS MADE AS WELL AS VISITS TO TOYOTA IN WHICH THEY WERE UNAWARE OF THE ISSUE.
NHTSA ODI #11155334
102,000 miles · Sep 4, 2018
Vehicle Speed Control
ON TWO OCCASIONS, JUNE 22, 2018 AND AUGUST 15, 2018 THIS VEHICLE SUDDENLY ACCELERATED WHILE USING CRUISE CONTROL AND TRAVELING AT SPEED ON GENERALLY FLAT, STRAIGHT, 4 LANE ROAD IN GOOD WEATHER. I HAVE ATTACHED DOCUMENTS WITH SUMMARIES OF EACH EVENT AND MAPS SHOWING ROUTE AND TERRAIN DURING THE EVENTS. HARD BRAKING SLOWED BUT DID…
Read full complaint
ON TWO OCCASIONS, JUNE 22, 2018 AND AUGUST 15, 2018 THIS VEHICLE SUDDENLY ACCELERATED WHILE USING CRUISE CONTROL AND TRAVELING AT SPEED ON GENERALLY FLAT, STRAIGHT, 4 LANE ROAD IN GOOD WEATHER. I HAVE ATTACHED DOCUMENTS WITH SUMMARIES OF EACH EVENT AND MAPS SHOWING ROUTE AND TERRAIN DURING THE EVENTS. HARD BRAKING SLOWED BUT DID NOT STOP THE VEHICLE EITHER TIME. BOTH TIMES, AFTER TRAVELING SOME DISTANCE WHILE BRAKING BUT CONTINUING TO ACCELERATE WITHOUT MY FOOT ON THE ACCELERATOR, THE VEHICLE MADE A THUNKING NOISE FELT THROUGH THE FLOOR OF THE CAR AND SUDDENLY STOPPED ACCELERATING. IN THE FIRST INCIDENT THIS WAS AFTER ABOUT 2 MILES, THE SECOND TIME AFTER ABOUT A MILE. AFTER EACH INCIDENT I PHONED THE LOCAL DEALERSHIP AND WAS TOLD THAT IF THEY COULD REPLICATE THE EVENT THEY MIGHT BE ABLE TO FIGURE IT OUT. I REPORTED THE EVENTS TO CORPORATE TOYOTA AND AN INVESTIGATION WAS OPENED. THE VEHICLE WAS TAKEN TO FRED ANDERSON TOYOTA OF ASHEVILLE WHERE THEY SPENT SEVERAL DAYS WITH THE CAR, INTERACTING WITH TOYOTA, WHO WAS ASKING THEM TO EXPLORE AND TEST VARIOUS THINGS RELATED TO THE DUAL PEDAL FAIL SAFE, THE COMPUTER, SNAPSHOTS OF EVENTS ON THE COMPUTER ETC. THEIR FINAL JUDGEMENT WAS THAT FLOOR MATS MAY HAVE INTERFERED, THOUGH IT WAS THE FIRST THING I CHECKED WHEN I REGAINED CONTROL OF THE CAR.
NHTSA ODI #11124223
60,600 miles · May 24, 2018
Fuel/propulsion SystemService BrakesVehicle Speed Control
BRAKE ACTUATOR HAS FAILED. TRACTION CONTROL, ABS, BRAKE LIGHTS ILLUMINATED ON DASH. MORE EFFORT NEEDED TO ENGAGE BRAKES. THIS AFFECTS THE REGENERATIVE BRAKING AS IT NO LONGER CHARGES ON BRAKING AS IT WAS DESIGNED. CHECKED TOYOTA WEBSITE FOR RECALLS SINCE THIS IS SAFETY RELATED, AND THERE ARE NONE. WHICH IS QUITE DISTURBING. I'V…
Read full complaint
BRAKE ACTUATOR HAS FAILED. TRACTION CONTROL, ABS, BRAKE LIGHTS ILLUMINATED ON DASH. MORE EFFORT NEEDED TO ENGAGE BRAKES. THIS AFFECTS THE REGENERATIVE BRAKING AS IT NO LONGER CHARGES ON BRAKING AS IT WAS DESIGNED. CHECKED TOYOTA WEBSITE FOR RECALLS SINCE THIS IS SAFETY RELATED, AND THERE ARE NONE. WHICH IS QUITE DISTURBING. I'VE RESEARCHED PRIUS FORUMS AND THIS SEEMS TO BE AN ONGOING PROBLEM. TOYOTA ISSUED A RECALL FOR THE GENERATION 2 MODEL, HOWEVER THIS SEEMS TO BE A PROBLEM FOR GENERATION 3 MODELS AS WELL. THE PROBLEM DID OCCUR WHEN ON THE HIGHWAY TRAVELING AT 60 MPH.
NHTSA ODI #11097727
170,000 miles · Jul 6, 2017
Electrical SystemVehicle Speed Control
I WAS DRIVING ON THE FREEWAY AT ABOUT 70 MPH WHEN THE "CHECK HYBRID SYSTEM" LIGHT CAME ON AND THE CAR LOST ALL POWER AND ABILITY TO ACCELERATE. IT COMPLETELY BEGAN TO DESCEND IN SPEED AND WITHIN 2 MINUTES CAME TO A COMPLETE SHUT DOWN. I COULD HAVE EASILY BEEN REAR ENDED HAD I NOT MOVED TO THE SIDE OF THE FREEWAY AS QUICKLY AS I …
Read full complaint
I WAS DRIVING ON THE FREEWAY AT ABOUT 70 MPH WHEN THE "CHECK HYBRID SYSTEM" LIGHT CAME ON AND THE CAR LOST ALL POWER AND ABILITY TO ACCELERATE. IT COMPLETELY BEGAN TO DESCEND IN SPEED AND WITHIN 2 MINUTES CAME TO A COMPLETE SHUT DOWN. I COULD HAVE EASILY BEEN REAR ENDED HAD I NOT MOVED TO THE SIDE OF THE FREEWAY AS QUICKLY AS I DID.
NHTSA ODI #11003313
Mileage unknown · Jun 8, 2017
Service BrakesVehicle Speed Control
I CHANGE THE BRAKE BOOSTER TWICE AND HACE THE SAME PROBLEM. MY BRAKE PEDAL LOSS OF BRAKING ABILITY OR SLIPPING BRAKES AND THE WARNING BRAKE, ABS AND TRACTION LIGHT PERMANENTLY ON, AND NO CRUISE CONTROL WORKS AT ALL
NHTSA ODI #10993977
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration