NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
108 reportsClear category filter262,000 miles · Aug 24, 2015
Electrical SystemPower TrainUnknown Or Other
THE VEHICLE RUNS OK AND A FEW MINUTES LATER THE YELLOW TRIANGLE TURNS ON, AS WELL AS THE CHECK ENGINE LIGHT AND THE VEHICLE STARTS TO LOSE POWER. AFTER A FEW MORE MINUTES THE RED STEERING WHEEL LIGHT COMES ON ALONG WITH THE "CHECK HYBRID SYSTEM" MESSAGE AND THE REST OF THE LIGHTS AND THE VEHICLES LOSES ALL POWER AND STOPS. IT WI…
Read full complaint
THE VEHICLE RUNS OK AND A FEW MINUTES LATER THE YELLOW TRIANGLE TURNS ON, AS WELL AS THE CHECK ENGINE LIGHT AND THE VEHICLE STARTS TO LOSE POWER. AFTER A FEW MORE MINUTES THE RED STEERING WHEEL LIGHT COMES ON ALONG WITH THE "CHECK HYBRID SYSTEM" MESSAGE AND THE REST OF THE LIGHTS AND THE VEHICLES LOSES ALL POWER AND STOPS. IT WILL NORMALLY TURN BACK ON BUT THERE WAS ONE OCCASION WHERE IT DIDN'T AND MY HUSBAND HAD TO PUSH THE CAR TO A PARKING LOT. I TOOK THE CAR IN ON THE RECALL WHICH SHOULD COVER THIS BUT ALL THEY DID WAS UPDATE THE SOFTWARE AND BLAME THE ISSUE ON A CAR ACCIDENT. I DON'T KNOW IF THIS IS TRUE AS JUST PURCHASED THE VEHICLE BUT IT SOUNDS TO ME THAT THEY COULD HAVE FIXED THE ISSUE UNDER THE RECALL.
NHTSA ODI #10759023
92,000 miles · Aug 21, 2015
Fuel/propulsion SystemUnknown Or Other
THIS HAPPENED TWICE. THE FIRST TIME I WAS DRIVING 40MPH, THE CHECK ENGINE LIGHT CAME ON AND THEN THE ACCELERATOR STOPPED WORKING. THEN THE CHECK HYBRID SYSTEM LIGHT CAME ON AND I GUIDED THE CAR OVER TO THE SIDE OF THE ROAD. THE CAR WOULD START BUT THE ACCELERATOR WOULD NOT FUNCTION AND THE (DIGITAL) SPEEDOMETER NUMBERS DISAPP…
Read full complaint
THIS HAPPENED TWICE. THE FIRST TIME I WAS DRIVING 40MPH, THE CHECK ENGINE LIGHT CAME ON AND THEN THE ACCELERATOR STOPPED WORKING. THEN THE CHECK HYBRID SYSTEM LIGHT CAME ON AND I GUIDED THE CAR OVER TO THE SIDE OF THE ROAD. THE CAR WOULD START BUT THE ACCELERATOR WOULD NOT FUNCTION AND THE (DIGITAL) SPEEDOMETER NUMBERS DISAPPEARED. I BROUGHT THE CAR TO THE DEALERSHIP WHERE THEY REPLACED A VALVE AND TOLD ME IT WAS FIXED. TWO DAYS LATER (AFTER DRIVING THE CAR WITHOUT INCIDENT ON SEVERAL TRIPS FOR AT LEAST 40 MILES) THE SAME EXACT THING HAPPENED, HOWEVER THIS TIME I WAS TRAVELLING 50 MPH WHILE ENTERING A VERY BUSY HIGHWAY DURING RUSH HOUR.
NHTSA ODI #10750250
70,000 miles · Apr 16, 2015
EngineUnknown Or Other
ON MARCH 4TH 2015 AT 8:00 AM, MY WIFE WAS TRYING TO CHANGE A PARKING SPOT INTO ANOTHER ABOUT 50 FEET AWAY IN THE SAME CHURCH PARKING LOT. SHE STARTED THE ENGINE AND THE CAR WAS PUT ON DRIVE. WITHIN A FRACTION OF A SECOND, THE CAR ACCELERATED BEYOND CONTROL. SHE COULD NOT STEER OR STOP THE CAR. THE CAR JUMPED A CURB, HIT A LIGHT …
Read full complaint
ON MARCH 4TH 2015 AT 8:00 AM, MY WIFE WAS TRYING TO CHANGE A PARKING SPOT INTO ANOTHER ABOUT 50 FEET AWAY IN THE SAME CHURCH PARKING LOT. SHE STARTED THE ENGINE AND THE CAR WAS PUT ON DRIVE. WITHIN A FRACTION OF A SECOND, THE CAR ACCELERATED BEYOND CONTROL. SHE COULD NOT STEER OR STOP THE CAR. THE CAR JUMPED A CURB, HIT A LIGHT POOL AND LANDED ON A GRASSY AREA. TIRE MARKS REVEAL THAT THE CAR EXPERIENCED A SUDDEN RUSH OF ACCELERATION BEYOND CONTROL 'UNINTENDED ACCELERATION.' MY WIFE IS STILL UNDER DOCTOR'S OBSERVATION. THE CAR FRONT RIGHT; BUMPER, TIRE, FENDER, DOOR, "A" PILLAR, AND OTHER PARTS WERE DAMAGED. THE CAR WAS TOWED TO DAYTONA TOYOTA AND IS STILL THERE SINCE MARCH 4TH 2015. ON MARCH 6TH 2015 A REPORT WAS ELECTRONICALLY FILED WITH TOYOTA MOTOR SALES, U.S.A., INC. ON MARCH 20TH 2015, A "CDR" CRASH DATA RETRIEVAL WAS TAKEN. THE CAR HAS NOT BEEN REPAIRED. EVEN IF THE CAR IS REPAIRABLE, I WOULD HESITATE TO DRIVE IT, LET MY WIFE DRIVE IT OR WITH CLEAR CONSCIOUS SELL IT TO ANY OTHER HUMAN BEING. PLEASE HELP US TO MITIGATE THE SITUATION. *TR
NHTSA ODI #10706002
78,000 miles · Feb 6, 2015
Service BrakesUnknown Or Other
1 ORIGINAL RECALL DID NOTHING CONCERNING HITTING A POTHOLE AND LOSING BRAKES FOR 20 +- FEET..RESULT..ALWAY GIVE YOURSELF 20 EXTRA FEET AND PRAY. 2 ANTILOCK ON PACKED SNOW OR ICE RESULTS IN TOTAL LOST OF BRAKES..RESULT EITHER DRIVE INTO A SNOW BANK OR GO THROUGH THE RED LIGHT AND PRAY AGAIN. SO I GUESS TOYOTA ACCEPTS THE FACT…
Read full complaint
1 ORIGINAL RECALL DID NOTHING CONCERNING HITTING A POTHOLE AND LOSING BRAKES FOR 20 +- FEET..RESULT..ALWAY GIVE YOURSELF 20 EXTRA FEET AND PRAY. 2 ANTILOCK ON PACKED SNOW OR ICE RESULTS IN TOTAL LOST OF BRAKES..RESULT EITHER DRIVE INTO A SNOW BANK OR GO THROUGH THE RED LIGHT AND PRAY AGAIN. SO I GUESS TOYOTA ACCEPTS THE FACT THEY CHOOSE TO GIVE YOU STEERING CONTROL TO SAVE YOURSELF AND HOPE YOU ARE NOT AT A RAILROAD CROSSING! THERE IS NO PULSATING LIKE OTHER VEHICLES. 3 IF YOU ARE STOPPED ON ICE /SNOW...WITHOUT TRACTION CAR DOES NOT ROCK ..DOES NOT WANT TO MOVE... FOR STUDY CAN A METAL STUD TIRE BE MADE FOR PRIUSES???WOULD IT HELP OR SELL CAR ONLY IN FLORIDA.. *JS
NHTSA ODI #10681695
59,000 miles · Feb 4, 2015
Electrical SystemExterior LightingUnknown Or Other
THE DASH DISPLAY MPH AND MILEAGE TOTALLY WENT BLACK. LOOKED IT UP ON THE INTERNET AND SEEMS LIKE IT IS A COMMON PROBLEM FOR THE 2010 TOYOTA PRIUS. SOUNDS LIKE TOYOTA USE TO COVER THIS BEFORE THIS YEAR MODEL, BUT NOT NOW, EVEN THOUGH IT IS STILL HAPPENING. THEY MAY HAVE DONE THEIR DASH ALITTLE DIFFERENT, BUT IT IS STILL HAVING TH…
Read full complaint
THE DASH DISPLAY MPH AND MILEAGE TOTALLY WENT BLACK. LOOKED IT UP ON THE INTERNET AND SEEMS LIKE IT IS A COMMON PROBLEM FOR THE 2010 TOYOTA PRIUS. SOUNDS LIKE TOYOTA USE TO COVER THIS BEFORE THIS YEAR MODEL, BUT NOT NOW, EVEN THOUGH IT IS STILL HAPPENING. THEY MAY HAVE DONE THEIR DASH ALITTLE DIFFERENT, BUT IT IS STILL HAVING THE SAME PROBLEM. *TR
NHTSA ODI #10681133
Mileage unknown · Sep 10, 2013
Unknown Or Other
I RECEIVED AN URGENT SAFETY RECALL NOTICE FROM TOYOTA RE: MY 2010 TOYOTA PRIUS BRAKE BOOSTER PUMP ASSEMBLY (ACCUMULATOR). AT THE BOTTOM OF THE NOTICE THERE IS THIS INFORMATION: "IF YOU BELIEVE THAT THE DEALER OR TOYOTA HAS FAILED OR IS UNABLE TO REMEDY THE DEFECT WITHIN A REASONABLE TIME, YOU MAY SUBMIT A COMPLAINT TO...(LISTS…
Read full complaint
I RECEIVED AN URGENT SAFETY RECALL NOTICE FROM TOYOTA RE: MY 2010 TOYOTA PRIUS BRAKE BOOSTER PUMP ASSEMBLY (ACCUMULATOR). AT THE BOTTOM OF THE NOTICE THERE IS THIS INFORMATION: "IF YOU BELIEVE THAT THE DEALER OR TOYOTA HAS FAILED OR IS UNABLE TO REMEDY THE DEFECT WITHIN A REASONABLE TIME, YOU MAY SUBMIT A COMPLAINT TO...(LISTS SEVERAL OPTIONS, INCLUDING WWW.SAFERCAR.GOV)." MY CORVALLIS, OREGON DEALER NOTIFIED ME THAT I AM ON A WAITING LIST OF APPROXIMATELY 15 VEHICLE OWNERS WAITING FOR THIS REPAIR. I WAS TOLD THAT TOYOTA IS ONLY PROVIDING MATERIALS TO THIS DEALER TO MAKE TWO REPAIRS A WEEK. WAITING POTENTIALLY TWO MONTHS FOR REPAIR OF A PROBLEM THAT "COULD AFFECT STOPPING DISTANCE AND INCREASE THE RISK OF A CRASH" IS DISCONCERTING. *TR
NHTSA ODI #10542838
107,650 miles · Apr 2, 2013
Unknown Or Other
MADE APPOINTMENT AT FRED HAAS TOYOTA FOR ECT RECALL PENDING COURT ACTION SPOKE WITH SPARKY TWYFORD AND SERVICE MANAGER THAT TOLD ME THEY DON'T KNOW WHAT TO DO AND REFUSED SAFETY INSPECTION OR FIX TO POSSIBILITY UNSAFE CAR MENTION IN THE POST CARD NOTICE. I WAS NOT PLEASED BECAUSE OF RECENT MILEAGE DROP AND LEGAL NOTICE SENT T…
Read full complaint
MADE APPOINTMENT AT FRED HAAS TOYOTA FOR ECT RECALL PENDING COURT ACTION SPOKE WITH SPARKY TWYFORD AND SERVICE MANAGER THAT TOLD ME THEY DON'T KNOW WHAT TO DO AND REFUSED SAFETY INSPECTION OR FIX TO POSSIBILITY UNSAFE CAR MENTION IN THE POST CARD NOTICE. I WAS NOT PLEASED BECAUSE OF RECENT MILEAGE DROP AND LEGAL NOTICE SENT TO ME. IF THERE SHOULD BE AN ACCIDENTG FROM THEIR NEGLIGENCE OF MY EFFORT TO REMEDY CAR, I WOUKLD LIKE YOUR RECORDS TO REFLECT THEIR NEGLIGENCE.
NHTSA ODI #10506106
10,000 miles · Aug 26, 2011
Unknown Or Other
MY 2010 PRIUS LURCHES FORWARD WHEN THE BRAKES ARE APPLIED AND I HIT A BUMP OR OTHER UNEVEN SURFACES. *TT
NHTSA ODI #10421586
20,000 miles · Jun 30, 2011
Service Brakes, HydraulicUnknown Or OtherCrashInjury
I WAS MAKING A SHARP RIGHT TURN TO PULL INTO A PARKING SPACE, SLOWING TO A STOP. THE CAR SUDDENLY AND UNEXPECTEDLY ACCELERATED FORWARD OUT OF MY CONTROL. I APPLIED THE BRAKES AS HARD AS I COULD, WITH NO RESPONSE. AS THE CAR WAS RACING INTO A TREE, I SHUT OFF THE ENGINE BY PUSHING THE POWER BUTTON TO OFF. THE CAR KNOCKED DOWN A …
Read full complaint
I WAS MAKING A SHARP RIGHT TURN TO PULL INTO A PARKING SPACE, SLOWING TO A STOP. THE CAR SUDDENLY AND UNEXPECTEDLY ACCELERATED FORWARD OUT OF MY CONTROL. I APPLIED THE BRAKES AS HARD AS I COULD, WITH NO RESPONSE. AS THE CAR WAS RACING INTO A TREE, I SHUT OFF THE ENGINE BY PUSHING THE POWER BUTTON TO OFF. THE CAR KNOCKED DOWN A TREE AND CAME TO A STOP ON TOP OF IT.
NHTSA ODI #10411028
6,525 miles · Jun 17, 2011
Unknown Or Other
I WAS DRIVING WITH TO PASSENGERS ON THE NEW JERSEY TURNPIKE AT 65 MPH WHEN I HEARD A LOUD NOISE FROM UNDER THE CAR. THE PLASTIC FRONT ENGINE COVER HAD COME LOOSE AND WAS DRAGGING ON THE PAVEMENT. A AAA MECHANIC REMOVED THE PART AND THE TOYOTA DEALER IS REPLACING IT AT NOT CHARGE. I THINK IT IS A SAFETY DEFECT.
NHTSA ODI #10408114
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration