NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
593 reportsClear category filter6,000 miles · Apr 26, 2014
Service Brakes
CONTINUAL BRAKING PROBLEMS WITH MY CAR. AT LOW SPEEDS APPLYING THE BRAKES ON A SLIPPERY OR BUMPY SURFACE, THERE IS A COMPLETE LACK OF BRAKING FOR A VERY SHORT PERIOD OF TIME. THE CAR SEEMS TO ACCELERATE. THIS WAS SUPPOSEDLY FIXED BY A TOYOTA RECALL. (SSC AOB) WHICH I HAD PERFORMED. STILL HAVE THE PROBLEM. I HAVE COMPLAINED MANY…
Read full complaint
CONTINUAL BRAKING PROBLEMS WITH MY CAR. AT LOW SPEEDS APPLYING THE BRAKES ON A SLIPPERY OR BUMPY SURFACE, THERE IS A COMPLETE LACK OF BRAKING FOR A VERY SHORT PERIOD OF TIME. THE CAR SEEMS TO ACCELERATE. THIS WAS SUPPOSEDLY FIXED BY A TOYOTA RECALL. (SSC AOB) WHICH I HAD PERFORMED. STILL HAVE THE PROBLEM. I HAVE COMPLAINED MANY TIMES TO DIFFERENT TOYOTA SERVICE DEPARTMENTS. THE ANSWER IS ALWAYS THEY CANNOT DUPLICATE THE PROBLEM. (THIS LAST TIME THEY TOLD ME THAT, AND THEY DIDN'T EVEN ROAD TEST IT.) HAVE COMPLAINED TO TOYOTA CORPORATE 5/26/2010, FILE #[XXX]. THEY CALLED ME BACK, ON 6/7/2010, STILL NO FIX YET, WILL CONTACT ME WHEN A FIX IS AVAILABLE. I USUALLY DRIVE THIS CAR, MY WIFE DROVE IT TODAY, AND IT HAPPENED TO HER. SCARED HER TO DEATH, DOES NOT WANT TO DRIVE THE CAR ANYMORE. HELP! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10585067
Mileage unknown · Apr 21, 2014
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
IF THE VEHICLE HITS A POT HOLE WHILE SLOWING DOWN, THERE'S A SUDDEN LOSS OF BRAKING POWER AND THE VEHICLE MOVES A FEW FEET FORWARD. THE VSC LIGHT COMES ON AT THE SAME TIME. I'D NOTICED THIS A FEW TIMES IN THE PAST BUT WITH THE ROADS DETERIORATING AFTER A BAD WINTER, THE POT HOLES ARE BIGGER AND THIS IS VERY PROMINENT AND SCARY. …
Read full complaint
IF THE VEHICLE HITS A POT HOLE WHILE SLOWING DOWN, THERE'S A SUDDEN LOSS OF BRAKING POWER AND THE VEHICLE MOVES A FEW FEET FORWARD. THE VSC LIGHT COMES ON AT THE SAME TIME. I'D NOTICED THIS A FEW TIMES IN THE PAST BUT WITH THE ROADS DETERIORATING AFTER A BAD WINTER, THE POT HOLES ARE BIGGER AND THIS IS VERY PROMINENT AND SCARY. GOING TO TAKE TO THE DEALER FOR INSPECTION. I FEEL IT'S DEFINITELY AN ISSUE WITH THE BRAKING SYSTEM. *TR
NHTSA ODI #10584074
Mileage unknown · Apr 16, 2014
Electrical SystemService Brakes
ODI # 10556900 FURTHER INCIDENTS WITH MY PRIUS.
NHTSA ODI #10583175
23,717 miles · Apr 15, 2014
Service BrakesVehicle Speed Control
WHEN PARKING, MY 2010 PRIUS ACCELERATED FORWARD CAUSING IT TO GO OVER A CURB FORM DAMAGING THE FRONT BUMPER. UNEXPECTED ACCELERATION HAS CAUSED FOUR ACCIDENTS DAMAGING MY CAR. I HAVE RECORDS OF THESE REPAIRS. THE HYBRID SYSTEM WENT OUT 8/30/2013 AND IN MARCH,2014 THE BACK BRAKES FELL OFF: NO BOLTS, PADS, CALIBER, FLUID …
Read full complaint
WHEN PARKING, MY 2010 PRIUS ACCELERATED FORWARD CAUSING IT TO GO OVER A CURB FORM DAMAGING THE FRONT BUMPER. UNEXPECTED ACCELERATION HAS CAUSED FOUR ACCIDENTS DAMAGING MY CAR. I HAVE RECORDS OF THESE REPAIRS. THE HYBRID SYSTEM WENT OUT 8/30/2013 AND IN MARCH,2014 THE BACK BRAKES FELL OFF: NO BOLTS, PADS, CALIBER, FLUID WERE IN PLACE WHEN IT WAS TOWED TO ROBBINS TOYOTA IN TEXARKANA, TX. THE FRONT RIGHT BOOSTER WAS BLOWN OUT WHILE IN THIS SHOP. MY VEHICLE THERE OVER A MONTH FOR VARIOUS REASONS. *TT
NHTSA ODI #10582801
500 miles · Apr 11, 2014
Service Brakes
THIS HAS OCCURRED ON MULTIPLE INCIDENTS. THIS CAR DOES NOT STOP PROPERLY ON ROUGH ROADS. WHEN HITTING A POTHOLE, BUMP, MANHOLE COVER, ROUGH ROAD WHILE APPLYING THE BRAKES, INSTEAD OF STOPPING, THE CAR SURGES FORWARDS APPROXIMATELY 5-10 FEET AS THOUGH THERE WERE NO BRAKES. EVENTUALLY, THE BRAKES WORK AND THE CAR STOPS. BUT IT…
Read full complaint
THIS HAS OCCURRED ON MULTIPLE INCIDENTS. THIS CAR DOES NOT STOP PROPERLY ON ROUGH ROADS. WHEN HITTING A POTHOLE, BUMP, MANHOLE COVER, ROUGH ROAD WHILE APPLYING THE BRAKES, INSTEAD OF STOPPING, THE CAR SURGES FORWARDS APPROXIMATELY 5-10 FEET AS THOUGH THERE WERE NO BRAKES. EVENTUALLY, THE BRAKES WORK AND THE CAR STOPS. BUT IT CAN BE REALLY SCARY. I HAVE TAKEN IT TO TOYOTA SEVERAL TIMES, BUT THEY CANNOT "REPLICATE THE INCIDENT." BASICALLY, I THINK THEY DRIVE IT AROUND THE BLOCK AND IT DOESN'T HAPPEN. IT IS ALWAYS WORSE WITH THE SUMMER TIRES VS THE STUDDED WINTER TIRES. THEY SAY IT HAS TO DO WITH THE REGEN BRAKES SWITCHING TO THE ANTI-LOCKS, BUT I REGULARLY DRIVE RENTAL CARS WITH ANTI-LOCKS FOR WORK IN OTHER CITIES, AND I KNOW WHAT ANTI-LOCKS FEEL LIKE. I HAVE NEVER FELT THE "CHATTER" ONE FEELS WHEN THE ANTI-LOCKS KICK ON. I DO NOT BELIEVE THE ANTI-LOCKS WORK PROPERLY ON THIS CAR. ON MAY 3, 2012, I HAD TO REPLACE THE RIGHT REAR BRAKE (ROTOR, PLATE, PADS) DUE TO UNEXPECTED CORROSION. MY CAR HAD ~17-18,000 MILES ON IT AND WAS ONLY 1.5 YEARS OLD! I HAVE NEVER HAD TO DO THIS ON ANY OTHER CAR. NOW AT 27, 000 MILES, MENDENHALL TOYOTA SAYS I NEED TO REPLACE THE REAR BRAKES AGAIN . I JUST REPLACED THE FRONT BRAKE PADS LAST WEEK. BUT THERE IS A NASTY SQUEAL THAT I REPORTED TO THEM LAST WEEK AND THEY DID NOTHING. EITHER THEY ARE RIPPING ME OFF OR THE BRAKES ON THESE CARS ARE DEFECTIVE AND DANGEROUS. PLEASE DO SOMETHING. TOYOTA REFUSES TO LISTEN. *JS
NHTSA ODI #10579172
45,000 miles · Apr 10, 2014
Service Brakes
APPLYING BRAKES, EITHER GRADUALLY OR WITH FORCE, WHILE FRONT LEFT OR FRONT RIGHT TIRE TRAVELS OVER A POTHOLE OR SUNKEN MANHOLE COVER RESULTS IN TEMPORARY (< 1 SECOND) COMPLETE LOSS OF BRAKING POWER. BRAKE PEDAL IS DEPRESSED THROUGH THE ENTIRE DURATION OF THE INCIDENT. LOSS OF BRAKING POWER RESULTS IN DRIVER APPLYING BRAKE WITH M…
Read full complaint
APPLYING BRAKES, EITHER GRADUALLY OR WITH FORCE, WHILE FRONT LEFT OR FRONT RIGHT TIRE TRAVELS OVER A POTHOLE OR SUNKEN MANHOLE COVER RESULTS IN TEMPORARY (< 1 SECOND) COMPLETE LOSS OF BRAKING POWER. BRAKE PEDAL IS DEPRESSED THROUGH THE ENTIRE DURATION OF THE INCIDENT. LOSS OF BRAKING POWER RESULTS IN DRIVER APPLYING BRAKE WITH MORE FORCE. WHEN BRAKES RESUME POWER, THE INCREASED FORCE RESULTS IN A SUDDEN DROP IN SPEED. THIS INCIDENT INCREASES THE RISK OF A REAR END COLLISION EITHER TO A VEHICLE IN FRONT OR FROM A VEHICLE BEHIND THE PRIUS. *TR
NHTSA ODI #10578852
1,200 miles · Apr 6, 2014
Service Brakes
WHEN APPLYING LIGHT TO MODERATE BRAKING IN PREPARATION TO MAKE A RIGHT TURN, I WENT OVER SOME BUMPY PAVEMENT AND THE CAR SEEMED TO LURCH FORWARD. IT WAS PROBABLY A LOSS OF BRAKING RATHER THAN ACTUAL ACCELERATION, BUT IT WAS VERY DISCONCERTING AND I'M LUCKY IT DIDN'T CAUSE AN ACCIDENT. I NOW HAVE OVER 49,000 MILES ON THE CAR AND …
Read full complaint
WHEN APPLYING LIGHT TO MODERATE BRAKING IN PREPARATION TO MAKE A RIGHT TURN, I WENT OVER SOME BUMPY PAVEMENT AND THE CAR SEEMED TO LURCH FORWARD. IT WAS PROBABLY A LOSS OF BRAKING RATHER THAN ACTUAL ACCELERATION, BUT IT WAS VERY DISCONCERTING AND I'M LUCKY IT DIDN'T CAUSE AN ACCIDENT. I NOW HAVE OVER 49,000 MILES ON THE CAR AND THIS HAS HAPPENED ON QUITE A FEW OCCASIONS. I KNOW THERE WAS A RECALL ON SOME 2010 PRIUS VEHICLES FOR THIS PROBLEM BUT MY CAR WAS NOT RECALLED. MY DEALER SAYS THERE IS NO "SOFTWARE FIX" FOR THIS PROBLEM. I FIND IT UNACCEPTABLE THAT TOYOTA DOESN'T HAVE A SOLUTION FOR THIS AS IT IS A REAL SAFETY ISSUE. IT'S JUST PURE LUCK THAT I HAVEN'T BEEN INVOLVED IN AN ACCIDENT WITH POSSIBLE INJURIES OR WORSE. I INTEND TO PURSUE THIS AGAIN WHEN I BRING THE CAR IN FOR THE 50,000 MILE SERVICE AND INVERTER RECALL, BUT I'M NOT VERY HOPEFUL. MAYBE IF MORE OWNERS LODGE A COMPLAINT ON THIS SITE, TOYOTA WILL BE FORCED TO CORRECT THIS ISSUE. *TR
NHTSA ODI #10577736
Mileage unknown · Apr 1, 2014
Service BrakesVehicle Speed ControlCrash
AS I WAS APPROACHING A RED LIGHT I APPLIED THE BRAKES AND THEN SHORTLY AFTER HIT A POT HOLE AND THE CAR LUNGED FORWARD AS IF ACCELERATING ON IT'S OWN. FORTUNATELY THERE WASN'T ANOTHER VEHICLE IN FRONT OF ME AS I WOULD HAVE MOST DEFINITELY REAR-ENDED IT. I ALMOST SHOT INTO THE INTERSECTION AND MOST CERTAINLY SHOT PAST THE NORMA…
Read full complaint
AS I WAS APPROACHING A RED LIGHT I APPLIED THE BRAKES AND THEN SHORTLY AFTER HIT A POT HOLE AND THE CAR LUNGED FORWARD AS IF ACCELERATING ON IT'S OWN. FORTUNATELY THERE WASN'T ANOTHER VEHICLE IN FRONT OF ME AS I WOULD HAVE MOST DEFINITELY REAR-ENDED IT. I ALMOST SHOT INTO THE INTERSECTION AND MOST CERTAINLY SHOT PAST THE NORMAL STOPPING SPOT FOR WAITING AT A RED LIGHT. SCARY INCIDENT TO SAY THE LEAST. *TR
NHTSA ODI #10576420
5,000 miles · Mar 31, 2014
Service Brakes
BRAKES ON VEHICLE OCCASIONALLY MOMENTARILY DISENGAGES WHEN I HIT A BUMP, PARTICULARLY ON A SLIPPER SURFACE, WHILE BRAKING AT LOW OR MODERATE BRAKING. THIS HAS HAPPENED MULTIPLE TIMES. IT IS VERY OBVIOUS WHEN THIS HAPPENS. RECENTLY IT HAPPENED WITH MY WIFE IN THE CAR, I WAS BRAKING MODERATELY, THE BRAKES FULLY DISENGAGED FOR AB…
Read full complaint
BRAKES ON VEHICLE OCCASIONALLY MOMENTARILY DISENGAGES WHEN I HIT A BUMP, PARTICULARLY ON A SLIPPER SURFACE, WHILE BRAKING AT LOW OR MODERATE BRAKING. THIS HAS HAPPENED MULTIPLE TIMES. IT IS VERY OBVIOUS WHEN THIS HAPPENS. RECENTLY IT HAPPENED WITH MY WIFE IN THE CAR, I WAS BRAKING MODERATELY, THE BRAKES FULLY DISENGAGED FOR ABOUT A SECOND, WHEN THEY DID I INCREASED PRESSURE ON THE BRAKE PEDAL AND THE CAR SEVERELY LURCHED WHEN THE BRAKES RE-ENGAGED. THE 2010 PRIUS HAD A RECALL FOR THIS, BUT MINE IS LATE IN THE MODEL YEAR AND WAS NOT SUBJECT TO THAT RECALL. TOYOTA USA AND THE DEALER, OF COURSE, SAYS THERE IS NOT A PROBLEM AND THAT THEY CANNOT DO ANYTHING ABOUT IT. *TR
NHTSA ODI #10575840
80,000 miles · Mar 26, 2014
Service BrakesVehicle Speed Control
I CAME TO A RED LIGHT AND WAS BRAKING AND AS IT ALMOST CAME TO A COMPLETE STOP IT JERKED FORWARD. THANKFULLY THERE WASN'T A CAR IN FRONT OF ME OTHERWISE I WOULD OF HIT IT. I'M TAKING IT IN SOON. I DON'T DRIVE IT EVERYDAY AND WHEN I DO IT'S LESS THAN A MILE. *TR
NHTSA ODI #10574998
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration