NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
593 reportsClear category filter139,500 miles · Feb 18, 2016
Service Brakes
MY CAR AT 139,500 MILES DRIVING STRAIGHT ON A MAIN ROAD AT 45 MPH HAD THREE LIGHTS COME ON, RED 'BRAKE' LIGHT, YELLOW 'ABS' LIGHT AND THE YELLOW 'TCS' LIGHT. EARL STEWART TOYOTA DIAGNOSED PROBLEM AS BRAKE ACTUATOR NEEDS TO BE REPLACED AT A COST OF LABOR/PARTS OF 2,100$. I WAS ABLE TO FINANCIALLY AFFORD THE REPAIR SO I TOLD THEM …
Read full complaint
MY CAR AT 139,500 MILES DRIVING STRAIGHT ON A MAIN ROAD AT 45 MPH HAD THREE LIGHTS COME ON, RED 'BRAKE' LIGHT, YELLOW 'ABS' LIGHT AND THE YELLOW 'TCS' LIGHT. EARL STEWART TOYOTA DIAGNOSED PROBLEM AS BRAKE ACTUATOR NEEDS TO BE REPLACED AT A COST OF LABOR/PARTS OF 2,100$. I WAS ABLE TO FINANCIALLY AFFORD THE REPAIR SO I TOLD THEM TO PERFORM THE REPAIR. LESS THAN TWO DAYS LATER, DRIVING NORMALLY ON A MAIN ROAD, THE SAME THREE WARNINGS APPEARED, AND OF COURSE UPSET ME GREATLY. TOYOTA THIS TIME DIAGNOSED THE PROBLEM THIS TIME AS THE BRAKE BOOSTER NEEDS TO BE REPLACED. ANOTHER DEALER SAID THE BRAKE MASTER CYLINDER NEEDED TO BE REPLACED. I AM IN TALKS WITH THE DEALER TO FIGURE OUT HOW TO PROCEED.
NHTSA ODI #10836999
63,000 miles · Feb 17, 2016
Service Brakes
DRIVER MADE A SUDDEN STOP TO AVOID AN ACCIDENT ON 2/16/15, ENGAGING THE BRAKES. AFTERWARD THE BRAKES ALTERNATED BETWEEN BEING HARD TO PUSH AND BEING SOFT TO PUSH. DRIVER PARKED THE VEHICLE 5 MINUTES LATER. THE NEXT TIME THE CAR WAS TURNED ON(APPROXIMATELY 60M LATER), THE CAR BEGAN BEEPING AND SHOWING THREE ERROR LIGHTS - ABS,…
Read full complaint
DRIVER MADE A SUDDEN STOP TO AVOID AN ACCIDENT ON 2/16/15, ENGAGING THE BRAKES. AFTERWARD THE BRAKES ALTERNATED BETWEEN BEING HARD TO PUSH AND BEING SOFT TO PUSH. DRIVER PARKED THE VEHICLE 5 MINUTES LATER. THE NEXT TIME THE CAR WAS TURNED ON(APPROXIMATELY 60M LATER), THE CAR BEGAN BEEPING AND SHOWING THREE ERROR LIGHTS - ABS, (!), AND THE TRACTION CONTROL SYMBOL. AFTER RUNNING DIAGNOSTICS, THE DRIVER WAS TOLD BY A MECHANIC THAT THE PROBLEM SOUNDED EXACTLY LIKE A PREVIOUSLY ISSUED RECALL (TCP-D0H); HOWEVER, TOYOTA HAS INDICATED THAT OUR MODEL IS OUTSIDE THE SCOPE OF THEIR RECALL. GIVEN THAT WE HAVE THE SAME MAKE/MODEL/YEAR CAR AS THE RECALL AND THE SAME ISSUE DESCRIBED, THE SITUATION IS HIGHLY SUSPECT. IN ADDITION TO INSURING MY OWN FAMILY'S SAFETY, I'M HOPING TO MAKE SURE THIS POTENTIALLY DANGEROUS BRAKE ISSUE ISN'T MORE WIDESPREAD THAN TOYOTA HAS ADMITTED.
NHTSA ODI #10836630
800,000 miles · Feb 11, 2016
Service Brakes
WHEN BRAKING ON A BUMPY ROAD, OVER A POT HOLE OR ON SLIPPERY ROAD THE BRAKES SLIP AND THE CAR PROPELS FORWARD . THIS HAPPENS ON CITY STREETS WHILE IN MOTION.
NHTSA ODI #10825645
120,000 miles · Jan 26, 2016
Service Brakes
DRIVING ON HIGHWAY THE ABS AND BRAKE WARNING LIGHTS CAME ON AND AN ALARM STARTED SOUNDING. I WAITED UNTIL LIGHT TRAFFIC APPLIED BRAKES PEDAL FELT LIKE I WAS PRESSING ON A BRICK, NO BRAKING OCCURRED I PRESSED HARDER, THE BRAKES BECAME SOFTER WENT TO THE FLOOR AND THE BRAKE PADS GRABBED HARD ON THE WHEELS. THERE IS NO C…
Read full complaint
DRIVING ON HIGHWAY THE ABS AND BRAKE WARNING LIGHTS CAME ON AND AN ALARM STARTED SOUNDING. I WAITED UNTIL LIGHT TRAFFIC APPLIED BRAKES PEDAL FELT LIKE I WAS PRESSING ON A BRICK, NO BRAKING OCCURRED I PRESSED HARDER, THE BRAKES BECAME SOFTER WENT TO THE FLOOR AND THE BRAKE PADS GRABBED HARD ON THE WHEELS. THERE IS NO CONTROLLED BRAKING ON THE CAR. DEALERSHIP SAYS THE BRAKE BOOSTER PUMP FAILED, THIS IS THE SAME YEAR MODEL THAT HAD BRAKING PROBLEMS RELATED TO NITROGEN IN THE BREAK LINES CAUSED BY A FAILED BRAKE BOOSTER PUMP. THE VIN IS ALSO VERY CLOSE TO AFFECTED VEHICLES. FORTUNATELY WHEN THIS OCCURRED I WAS IN A POSITION TO NAVIGATE TO WHERE I COULD TEST THE BRAKES IN A FAIRLY CONTROLLED ENVIRONMENT. HAD IT HAPPENED IN HEAVY TRAFFIC IT WOULD HAVE ALMOST CERTAINLY RESULTED IN A SERIOUS ACCIDENT.
NHTSA ODI #10822316
68,840 miles · Jan 13, 2016
Service BrakesService Brakes, Hydraulic
AS I WAS DRIVING, I NOTICED THAT WHEN I PRESSED ON THE BRAKES, THE CAR WOULD JERK FORWARD BEFORE COMING TO A STOP. ONCE STOPPED (BUT STILL TURNED ON), THE CAR MADE A BUZZING NOISE I HAD NEVER HEARD BEFORE. NO WARNING LIGHTS CAME ON, AND THE BRAKES DID NOT SQUEAK. AN HOUR LATER, MY HUSBAND DROVE THE CAR HOME FOR ME (I RODE WITH A…
Read full complaint
AS I WAS DRIVING, I NOTICED THAT WHEN I PRESSED ON THE BRAKES, THE CAR WOULD JERK FORWARD BEFORE COMING TO A STOP. ONCE STOPPED (BUT STILL TURNED ON), THE CAR MADE A BUZZING NOISE I HAD NEVER HEARD BEFORE. NO WARNING LIGHTS CAME ON, AND THE BRAKES DID NOT SQUEAK. AN HOUR LATER, MY HUSBAND DROVE THE CAR HOME FOR ME (I RODE WITH A FRIEND), AND HE REPORTED THAT WARNING LIGHTS CAME ON AND THE BRAKES DID NOT WORK PROPERLY. IN ORDER FOR THE BRAKES TO WORK, HE HAD TO PRESS VERY HARD ON THEM AND ALSO ALLOW MUCH MORE DISTANCE FOR THE CAR TO STOP. HE COULD HAVE EASILY CRASHED INTO THE BACK OF ANOTHER VEHICLE. HE TOOK THE CAR TO THE TOYOTA DEALERSHIP AND WAS INFORMED THE BRAKE BOOSTER ASSEMBLY WOULD HAVE TO BE REPLACED. THIS IS THE SAME COMPLAINT AS A 2010 PRIUS RECALL, BUT MY VIN NUMBER WAS NOT INCLUDED IN THE RECALL, SO I DID NOT RECEIVE A NOTICE IN THE AIL. ALSO, WE HAD TO PAY $3008 TO HAVE THE BRAKE BOOSTER ASSEMBLY REPLACED. THE CONSUMER REFERENCED RECALL # 13V235000. UPDATED 02/11/16. *JB
NHTSA ODI #10838341
160,000 miles · Nov 12, 2015
Service Brakes
LOSS OF BRAKE PRESSURE, WITH INSUFFICIENT BREAKING TO HOLD AT A STOP WHILE IN DRIVE. WARNING LIGHTS FOR BRAKE SYSTEM, ABS, ELECTRONIC BRAKE SYSTEM (YELLOW EXCLAMATION POINT IN A CIRCLE), AND TRACTION CONTROL. DIAGNOSED BY BROWN TOYOTA IN CHARLOTTESVILLE VA AS FAULTY BRAKE BOOSTER, ACCUMULATOR, AND MASTER CYLINDER. BROWN TOYOTA …
Read full complaint
LOSS OF BRAKE PRESSURE, WITH INSUFFICIENT BREAKING TO HOLD AT A STOP WHILE IN DRIVE. WARNING LIGHTS FOR BRAKE SYSTEM, ABS, ELECTRONIC BRAKE SYSTEM (YELLOW EXCLAMATION POINT IN A CIRCLE), AND TRACTION CONTROL. DIAGNOSED BY BROWN TOYOTA IN CHARLOTTESVILLE VA AS FAULTY BRAKE BOOSTER, ACCUMULATOR, AND MASTER CYLINDER. BROWN TOYOTA SAID IT WAS A RECURRING PROBLEM THEY HAVE ENCOUNTERED AND THEY HAVE BEEN IN CONTACT WITH TOYOTA HEADQUARTERS ABOUT IT. ESTIMATE WAS $5800. TOYOTA CUSTOMER SERVICE WAS CONTACTED. WAS TOLD IT IS NOT ONE OF THE 2010 CARS COVERED BY THE RECALL DESPITE BEING THE SAME FAILURE AND NO COMPENSATION WAS OFFERED.
NHTSA ODI #10789992
96,000 miles · Oct 21, 2015
Service Brakes
VEHICLES BRAKES ARE SPONGY AND UNPREDICTABLE. THE DEALER RECOMMENDED TO DO A BRAKE FLUID EXCHANGE AND NOW THE PROBLEM HAS GONE AWAY. THIS ISSUE SEEMS VERY SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 13V235000, WHERE NITROGEN ENTERS THE BRAKE FLUID AND MAKES THE BRAKES LESS RESPONSIVE. HOWEVER, THE DEALER SAID THIS VEHICLE IS NOT COVE…
Read full complaint
VEHICLES BRAKES ARE SPONGY AND UNPREDICTABLE. THE DEALER RECOMMENDED TO DO A BRAKE FLUID EXCHANGE AND NOW THE PROBLEM HAS GONE AWAY. THIS ISSUE SEEMS VERY SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 13V235000, WHERE NITROGEN ENTERS THE BRAKE FLUID AND MAKES THE BRAKES LESS RESPONSIVE. HOWEVER, THE DEALER SAID THIS VEHICLE IS NOT COVERED BY THAT RECALL AND I WAS CHARGED $150 FOR THE REPAIR.....UPDATED 12/02/15 *BF THE CONSUMER STATED THE BRAKES FELT SPONGY AND WERE UNPREDICTABLE AT LOW SPEEDS OF LESS THAN 20 MPH. UPDATED 12/28/15. *JB
NHTSA ODI #10785232
72,000 miles · Oct 2, 2015
Air BagsService BrakesCrash
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE ATTEMPTING TO PARK THE VEHICLE WITH THE BRAKE PEDAL ENGAGED, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO THE CURB. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO A…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE ATTEMPTING TO PARK THE VEHICLE WITH THE BRAKE PEDAL ENGAGED, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO THE CURB. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED. THE BODY DAMAGE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000.
NHTSA ODI #10779310
130,000 miles · Sep 30, 2015
Service Brakes
WHILE DECELERATING DUE TO APPLICATION OF THE BRAKE PEDAL IF THE VEHICLE ENCOUNTERS A POTHOLE OR OTHER DEEP ROAD IMPERFECTION THE BRAKING CUTS OUT AND THE VEHICLE RESUMES COASTING IMMEDIATELY EVEN THOUGH THE BRAKE PEDAL IS DEPRESSED. HARDER APPLICATION OF THE BRAKE PEDAL IS NECESSARY TO RESUME VEHICLE BRAKING. SUBSEQUENT BRAKING …
Read full complaint
WHILE DECELERATING DUE TO APPLICATION OF THE BRAKE PEDAL IF THE VEHICLE ENCOUNTERS A POTHOLE OR OTHER DEEP ROAD IMPERFECTION THE BRAKING CUTS OUT AND THE VEHICLE RESUMES COASTING IMMEDIATELY EVEN THOUGH THE BRAKE PEDAL IS DEPRESSED. HARDER APPLICATION OF THE BRAKE PEDAL IS NECESSARY TO RESUME VEHICLE BRAKING. SUBSEQUENT BRAKING POWER IS MUCH REDUCED COMPARED TO NORMAL BRAKING AND SIGNIFICANTLY HARDER BRAKE PEDAL PRESSURE IS NECESSARY. NORMAL BRAKING MAY BE REESTABLISHED BY LIFTING THE FOOD OFF THE BRAKE PEDAL COMPLETELY AND RE-DEPRESSING THE BRAKE PEDAL. THE SEVERITY OF THE SUDDEN LOSS OF BRAKING (COMPLETE LOSS OF BRAKING) IS SHOCKING, ALARMING, AND PANIC ENDUCING AND RESULTS IN WHIPLASH TO THE VEHICLE OCCUPANTS AS THE PASSENGERS, BEING UNCONSCIOUSLY BRACED FOR DECELERATION, ARE SUDDENLY JOLTED BACK INTO THEIR SEATS. WHEN ANOTHER VEHICLE IS LOCATED IN FRONT OF THE VEHICLE THE SUDDEN LOSS OF BRAKING AND SUBSEQUENT WEAK BRAKING POWER DESPITE STRONG BRAKE PEDAL DEPRESSION IS HIGHLY ALARMING. THE MOST REPRODUCIBLE SITUATION IN WHICH THIS HAPPENS IS ON DRY PAVEMENT WHILE EXITING A HIGHWAY AND DECELERATING ON A STRAIGHT OR SLIGHTLY CURVED EXIT RAMP WITH ONE OR MORE POTHOLES. THE PHENOMENON OCCURS IN OTHER CIRCUMSTANCES AS WELL WHERE A POTHOLE IS ENCOUNTERED WHILE THE VEHICLE IS UNDER BRAKING.
NHTSA ODI #10778896
60,000 miles · Sep 30, 2015
Service Brakes
WHEN APPLYING THE BREAKS BEFORE AND OVER RAILROAD TRACKS, THE BREAKING WILL DISENGAGE AND THEN REENGAGE. IT WILL ALSO HAPPEN WITH POT HOLES. YOU GET THE FEELING THE CAR WON'T STOP. THIS HAS BEEN HAPPING FOR YEAR AND THE SERVICE DEPARTMENT GIVES DIFFERENT ANSWERS TO THE CAUSE.
NHTSA ODI #10778684
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration