NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
593 reportsClear category filterMileage unknown · Jul 8, 2025
Service Brakes
What component or system failed or malfunctioned, and is it available for inspection upon request? Brake Actuator failed requiring replacement of booster assembly with master cylinder and booster pump assembly How was your safety or the safety of others put at risk? This greatly impacted braking and stopping distance Has the p…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? Brake Actuator failed requiring replacement of booster assembly with master cylinder and booster pump assembly How was your safety or the safety of others put at risk? This greatly impacted braking and stopping distance Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, Toyota Dealership Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, Toyota Dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. These lights appeared after the failure - Brake, ABS, Traction Control
NHTSA ODI #11671942
Mileage unknown · Jun 12, 2025
Service Brakes
While driving on the freeway the Traction control light, ABS light, Brake System Light and Brake light all came on. Fortunately I haven't had any issues but when I took it to the a dealership I was told that the Brake booster and pump need to be replaced as the master cylinder was leaking into the brake fluid and given an estima…
Read full complaint
While driving on the freeway the Traction control light, ABS light, Brake System Light and Brake light all came on. Fortunately I haven't had any issues but when I took it to the a dealership I was told that the Brake booster and pump need to be replaced as the master cylinder was leaking into the brake fluid and given an estimate of $3500 for the repair. People online have said that after having this issue the brakes can go out at any time. I am unable to pay for the repairs at the moment so I have to drive with the knowledge of having my brakes going out at any time.
NHTSA ODI #11666573
Mileage unknown · Jun 11, 2025
Electrical SystemService Brakes
Toyota issued a recall with a limited time for Prius brake booster/actuator failures. This issue is known to present brake failures and necessarily place drivers, passengers, and pedestrians at risk in the case of such brake failures. Toyota made no effort to proactively remedy this problem and further neglected customer safety …
Read full complaint
Toyota issued a recall with a limited time for Prius brake booster/actuator failures. This issue is known to present brake failures and necessarily place drivers, passengers, and pedestrians at risk in the case of such brake failures. Toyota made no effort to proactively remedy this problem and further neglected customer safety by excluding Priuses with the same manufacturing issue from the recall, under its 10 year 150,000 mile requirement. Whether or not the Priuses have been driven 150,000 miles or 10 years the nature with which the malfunction presents represents a safety for any driver.
NHTSA ODI #11666335
Mileage unknown · May 14, 2025
Service Brakes
C1391 error, "Abnormal Leak of ACC PRESS". This is a common failure in many prius and requires the replacement of the brake master cylinder and brake accumulator. Toyota has an expired customer support program but no actual recall. Parts were replaced to bring braking system back into working condition.
NHTSA ODI #11660987
Mileage unknown · May 10, 2025
Service Brakes
I purchased a used 2010 Prius on May 1, 2025. On May 5, the car would not turn on. Thought it was the battery. Replaced the battery on May 6. On May 8, the battery was dead again. I jumped the car and tried driving it to the Toyota dealership to have it looked at. On the way a loud beeping sound started and the ABS light came on…
Read full complaint
I purchased a used 2010 Prius on May 1, 2025. On May 5, the car would not turn on. Thought it was the battery. Replaced the battery on May 6. On May 8, the battery was dead again. I jumped the car and tried driving it to the Toyota dealership to have it looked at. On the way a loud beeping sound started and the ABS light came on. I pulled over and noticed the brakes felt strange. After having it towed to Ourisman Toyota, the told me the brake booster was broken causing the battery to drain. The cost for repair is a little over $4,000. This almost half of what I paid for the vehicle.
NHTSA ODI #11660115
Mileage unknown · May 5, 2025
Service Brakes
Code diagnostic C1391 ABS system. I have replaced this in my previous 2009 Toyota Prius, it has been replaced in this 2010 Toyota Prius, and now needs to be replaced AGAIN in the 2010 Toyota Prius. It’s incredibly dangerous, no warning signs, spongy brakes all of the sudden that barely feel like they’re going to work. It puts n…
Read full complaint
Code diagnostic C1391 ABS system. I have replaced this in my previous 2009 Toyota Prius, it has been replaced in this 2010 Toyota Prius, and now needs to be replaced AGAIN in the 2010 Toyota Prius. It’s incredibly dangerous, no warning signs, spongy brakes all of the sudden that barely feel like they’re going to work. It puts not only myself in danger, but others especially when it just happens without warning and all of the lights come on as you are driving and the brakes become extremely wonky.
NHTSA ODI #11659119
Mileage unknown · May 1, 2025
Service Brakes
We have a 2010 Toyota Prius. All the sudden we got errors/warnings on our dash about ABS and traction lights, and brake light, staying on all the time. Brakes extremely sluggish, and from doing research advised not to drive it. Toyota did a diagnostic test which came up as C1391, bad ABS booster pump and master cylinder. This is…
Read full complaint
We have a 2010 Toyota Prius. All the sudden we got errors/warnings on our dash about ABS and traction lights, and brake light, staying on all the time. Brakes extremely sluggish, and from doing research advised not to drive it. Toyota did a diagnostic test which came up as C1391, bad ABS booster pump and master cylinder. This is a huge safety issue, others have reported brakes completely going out on the highway, and also reporting Toyota is not paying for fixing the issue, and only "certain Priuses" meet their criteria to pay for repairs. There supposedly was a recall at some point but we NEVER received it. I have contacted Toyota America and waiting to hear back. It is going to be very expensive to repair, about $3500-$4500. Yes, it is a 2010, but from what I'm reading and hearing is a MAJOR safety issue and Toyota needs to be held responsible and honor/extend any and all recalls. Again, I'm waiting to hear back from them, but was advised by many other Prius owners to file a complaint with NHTSA.
NHTSA ODI #11658300
Mileage unknown · Apr 21, 2025
Service Brakes
My brake booster master cylinder and pump assembly went out while driving on the freeway. My brakes became soft and unresponsive, though I was able to exit the freeway without incident. My ABS light, brake light, and traction control lights all came on. The lights have since remained on and my brakes continue to malfunction. My …
Read full complaint
My brake booster master cylinder and pump assembly went out while driving on the freeway. My brakes became soft and unresponsive, though I was able to exit the freeway without incident. My ABS light, brake light, and traction control lights all came on. The lights have since remained on and my brakes continue to malfunction. My local repair show diagnoses the issue with the diagnostic trouble code: C1391 Back in 2018, before I owned the car, Toyota offered an "extended warranty" to have the parts replaced for free for 10 years or 150,000 miles, whichever came first. I'm past the year threshold but well short of the mileage one. I feel a recall should be made and the repair covered, as this is clearly a safety issue.
NHTSA ODI #11655931
Mileage unknown · Apr 3, 2025
Forward Collision AvoidanceService Brakes
My ABS system light is on. The Toyota mechanic has determined that it is due to Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid. As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could aff…
Read full complaint
My ABS system light is on. The Toyota mechanic has determined that it is due to Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid. As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash. Toyota recalled model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009. I took my Prius to Toyota to fix this ABS recall problems but they are refusing to fix the problem for free. They are charging me $4000 to fix it.
NHTSA ODI #11652694
Mileage unknown · Apr 1, 2025
Service Brakes
ABS, traction, and brake warning lights came on. No OBD code reading. Mechanic says needs brake booster pump; brake booster master cylinder. Theoretically mine were serviced but no way for me to actually verify it happened on the recall. Vehicle located in Kamuela, Hawaii.
NHTSA ODI #11652185
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration