WHILE DRIVING BACK TO HOME FROM WORK IN DC TRAFFIC WHEN THE TRAFFIC STARTED GOING WHEN THE SIGNAL TURNED GREEN I PRESSED ACCELERATOR ALL OF A SUDDEN AFTER LITTLE SOUND DIFFERENT WARNING LIGHTS ILLUMINATED ON THE DASH ALONG WITH THE LARGE RECTANGULAR WARNING MESSAGE SAYING "CHECK HYBRID SYSTEM". THE CAR CAN GO ONLY UNDER 10 MPH A…
Read full complaint
WHILE DRIVING BACK TO HOME FROM WORK IN DC TRAFFIC WHEN THE TRAFFIC STARTED GOING WHEN THE SIGNAL TURNED GREEN I PRESSED ACCELERATOR ALL OF A SUDDEN AFTER LITTLE SOUND DIFFERENT WARNING LIGHTS ILLUMINATED ON THE DASH ALONG WITH THE LARGE RECTANGULAR WARNING MESSAGE SAYING "CHECK HYBRID SYSTEM". THE CAR CAN GO ONLY UNDER 10 MPH AND I PULLED ON TO CURB AND TOWED TO NEAR BY DEALER (OURISMAN CHANTILLY TOYOTA). TWO DAYS LATER I GOT CALL SAYING INVERTER IS AN ISSUE TAKES TWO TO THREE DAYS TO GET PART AND WILL BE REPLACED FOR FREE AS THE CAR HAS ONLY 36K MILES ON IT. WE HAVE TO RENT CAR (TOYOTA SHOULD PROVIDE THIS SERVICE AS IT IS THEIR COMMON DEFECTIVE PART AND THE REPAIR IS UNDER WARRANTY). *TR
NHTSA ODI #10507315
38,978 miles · Feb 25, 2013
Electrical SystemFuel System, Other
STARTING MY VEHICLE AND LEAVING MY GARAGE AT 2 MPH THE MASTER WARNING LIGHT, CHECK HYBRID SYSTEM LIGHT, AND MALFUNCTION INDICATOR/CHECK ENGINE LIGHT WERE ALL LIT UP. WITH A TERRIBLE SMELL ELECTRICAL/FUEL. I IMMEDIATELY SHUT THE CAR OFF AND LET IT SIT. AFTER A FEW SECONDS I TRIED AGAIN WITH THE SAME RESULT. THE OWNERS MANUAL …
Read full complaint
STARTING MY VEHICLE AND LEAVING MY GARAGE AT 2 MPH THE MASTER WARNING LIGHT, CHECK HYBRID SYSTEM LIGHT, AND MALFUNCTION INDICATOR/CHECK ENGINE LIGHT WERE ALL LIT UP. WITH A TERRIBLE SMELL ELECTRICAL/FUEL. I IMMEDIATELY SHUT THE CAR OFF AND LET IT SIT. AFTER A FEW SECONDS I TRIED AGAIN WITH THE SAME RESULT. THE OWNERS MANUAL SAYS TO NOT DRIVE AND CONTACT TOYOTA DEALER IMMEDIATELY. WHEN THE TOW TRUCK ARRIVED I AGAIN TRIED TO START THE VEHICLE AND THE WARNINGS WERE NOT PRESENT. THE DEALER INVESTIGATED AND SAID IT WAS OVER ETHANOL IN THE FUEL. THE FUEL HAS BEEN TESTED AND FOUND TO BE 6-8%, WHICH IS ACCEPTABLE. THE DEALER AT THE TIME OF THE REPAIR WANTED $450 TO DROP AND CLEAN THE TANK. INSTEAD I CHOSE TO GO WITH THE PHILLIPS TOYOTA (LEESBURG FLORIDA, PHONE 352-728-2030) DEALER SERVICE MANAGER, DAVID NEWTON TO THE CLOSEST GAS STATION AND FILL UP. SINCE THEN THERE HAS NOT BEEN A PROBLEM, BUT I AM CONCERNED FOR MY SAFETY IN NOW DRIVING THE VEHICLE. AS THIS IS A HYBRID WHICH I PURCHASED TO HELP OUR COUNTRY WITH ENERGY SECURITY (56 MPG) BUT AM AFRAID AS A RETIREE WITH MY WIFE THAT THIS COULD HAVE ENDED DIFFERENTLY IF WE WERE ON THE INTERSTATE TRAVELING. WITH THE REPUTATION OF TOYOTA AND THE UNEXPECTED ACCELERATION WE ARE CONCERNED THAT THE INITIAL PROBLEM HAS NOT BEEN FOUND AND WILL RECUR. THIS COULD HAPPEN ON THE INTERSTATE HIGHWAY WITH A MUCH DIFFERENT OUTCOME. I AM REPORTING THIS TO GO ON RECORD WITH THIS PROBLEM JUST IN CASE AN ACCIDENT OR FATALITY IS INVOLVED THE NEXT TIME, IF IT HAPPENS AGAIN. THANK-YOU AND I CAN EMAIL MY FILE WHICH HAS BEEN SENT TO SHELLCUSTOMERCARE@SHELL.COM UNDER THEIR REFERENCE#[XXX], AND FLORIDA DIVISION OF CONSUMER SERVICES, [XXX]. I HAVE ALSO REQUESTED A MEETING WITH THE TOYOTA CORPORATION REPRESENTATIVE THROUGH THE DEALER SERVICE MGR. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10499963
6,750 miles · May 7, 2010
Electrical SystemFuel System, Other
I WAS ON A TRIP TO ARIZONA AND WHEN DRIVING IN MY 2010 PRIUS FROM FLAGSTAFF TO PHOENIX DURING THE EVENING, THE BATTER DISPLAY'S TOP SEGMENT GLOWED RED MANY TIMES IN THE DESCENT FROM FLAGSTAFF. IT WAS A VERY DIFFICULT TO DRIVE TO KEEP THE TOP SEGMENT FROM TURNING RED AS THE VEHICLE WAS COASTING AND I DID NOT WANT TO EXCEED THE SP…
Read full complaint
I WAS ON A TRIP TO ARIZONA AND WHEN DRIVING IN MY 2010 PRIUS FROM FLAGSTAFF TO PHOENIX DURING THE EVENING, THE BATTER DISPLAY'S TOP SEGMENT GLOWED RED MANY TIMES IN THE DESCENT FROM FLAGSTAFF. IT WAS A VERY DIFFICULT TO DRIVE TO KEEP THE TOP SEGMENT FROM TURNING RED AS THE VEHICLE WAS COASTING AND I DID NOT WANT TO EXCEED THE SPEED LIMIT SO I REALLY DID NOT NOW WHAT TO DO. I DECIDED TO SHIFT TO NEUTRAL SO THE ENGINE WAS NOT BREAKING. HOWEVER IN NEUTRAL I WAS WEARING OUT MY VEHICLES BRAKES WHICH ALSO WORRIED ME BECAUSE OF THE POSSIBILITY OF OVERHEATING THE BRAKES. I LOOKED IN MY VEHICLE MANUAL BUT NOTHING AS IN THE BOOKLET ABOUT THIS TYPE OF OCCURRENCE. SO I ASKED MY TOYOTA SERVICE PERSONNEL AT RUDY LUTHER TOYOTA IN GOLDEN VALLEY, MN AND THEY HAD NOT HEARD OF THIS PROBLEM. HE GAVE ME A THE TELEPHONE NUMBER FOR CUSTOMER SERVICE REPRESENTATIVES AT TOYOTA AND AFTER DISCUSSING THIS INCIDENT WITH MANY PEOPLE IN CUSTOMER SERVICE AT TOYOTA, THE END RESULT WAS "THAT THE BATTERY WAS FULLY CHARGED AND WHEN THIS OCCURS THE TOP BAR WILL GLOW RED BUT THIS WILL NOT EFFECT THE BATTERY". I DO NOT KNOW IF THIS IS TRUE OR TOYOTA IS JUST PUTTING ME OFF BUT OTHERS AT THE FOLLOWING TOYOTA FORUM HAVE ALSO EXPERIENCED THIS PROBLEM. IS THIS A SAFETY PROBLEM, I DO NOT KNOW. IS IT A BATTERY WARRANTY PROBLEM, I DO NOT KNOW. BUT PLEASE LOOK AT THIS FORUM THREAD AND MAYBE YOU CAN DISCUSS THIS MORE FULLY WITH TOYOTA. HTTP://PRIUSCHAT.COM/FORUMS/GEN-III-2010-PRIUS-MAIN-FORUM/67994-ALL-BARS-BATTERY-INDICATOR-4.HTML ON THE RETURN TRIP AND HERE IN MINNESOTA I HAVE NOT HAD THIS PROBLEM OCCUR AS THERE ARE NOT MANY LONG DESCENTS. *TR
NHTSA ODI #10329299
10,000 miles · Feb 5, 2010
Fuel System, Other
I OWN A 2010 PRIUS. AFTER PUTTING 10K MILES ON IT, I HAVE YET TO SEE THE 50+ MPG. I COULD HAVE EASILY BOUGHT A HONDA CIVIC, SAVED $15,000+ AND STILL GOTTEN 38MPG. I HAVE TAKEN THE CAR TO THE DEALERSHIP ON A FEW OCCASIONS AND THEY CANNOT TELL ME WHY I HAVE LOST ALMOST 20MPG. ALL THEY CAN TELL ME IS THAT IT IS PROBABLY THE GAS…
Read full complaint
I OWN A 2010 PRIUS. AFTER PUTTING 10K MILES ON IT, I HAVE YET TO SEE THE 50+ MPG. I COULD HAVE EASILY BOUGHT A HONDA CIVIC, SAVED $15,000+ AND STILL GOTTEN 38MPG. I HAVE TAKEN THE CAR TO THE DEALERSHIP ON A FEW OCCASIONS AND THEY CANNOT TELL ME WHY I HAVE LOST ALMOST 20MPG. ALL THEY CAN TELL ME IS THAT IT IS PROBABLY THE GAS THAT I AM USING. I CAN SEE HOW THIS MIGHT MAKE A SLIGHT DIFFERENCE LIKE 3-4MPG, BUT NOT 20! I BELIEVE THE 50MPG BENCHMARK GIVEN BY TOYOTA IS BOGUS. I WANT MY MONEY BACK! *TR
NHTSA ODI #10306765
3,000 miles · Feb 3, 2010
Fuel System, OtherService Brakes, Electric
I OWN A 2010 TOYOTA PRIUS, 3RD GENERATION. WHEN I AM BRAKING AND HIT A POTHOLE OR A MANHOLE COVER, THE CAR SURGES FORWARD. I TOOK IT TO THE DEALERSHIP TODAY AND THEY CHECKED THE CAR AND SAID THEY COULDN'T FIND ANYTHING WRONG WITH IT. THEY ALSO SAID THEY HAD NO KNOWLEDGE OF ANY KIND OF BRAKING OR SURGING PROBLEMS WITH THIS VEH…
Read full complaint
I OWN A 2010 TOYOTA PRIUS, 3RD GENERATION. WHEN I AM BRAKING AND HIT A POTHOLE OR A MANHOLE COVER, THE CAR SURGES FORWARD. I TOOK IT TO THE DEALERSHIP TODAY AND THEY CHECKED THE CAR AND SAID THEY COULDN'T FIND ANYTHING WRONG WITH IT. THEY ALSO SAID THEY HAD NO KNOWLEDGE OF ANY KIND OF BRAKING OR SURGING PROBLEMS WITH THIS VEHICLE. OUR DEALER WAS EASTERN SHORE TOYOTA IN DAPHNE, AL. THIS HAS HAPPENED APPROXIMATELY 6 DIFFERENT TIMES SINCE WE BOUGHT THE CAR IN 2009. IT STARTED TO OCCUR APPROXIMATELY IN JULY 2009, WITH THE MOST RECENT EPISODE IN JANUARY 2010. *TR
NHTSA ODI #10304851
10,300 miles · Feb 3, 2010
Electrical SystemFuel System, Other
2010 TOYOTA PRIUS - WHEN BRAKING, IF YOU HIT A BUMP OR POT HOLE IN THE ROAD, THE CAR LUNGES FORWARD (ACCELERATES). YOU HAVE TO REALLY PAY ATTENTION FOR THIS OCCURRENCE OR YOU WILL REAR END SOMEONE. I HAS HAPPEN ABOUT 5 TIMES NOW. THIS SEEMS TO BE A ELECTRONICS ISSUE NOT A PEDAL PROBLEM. *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
2010 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration