NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
60 reportsClear category filter67,000 miles · Aug 23, 2018
Electrical SystemEngineFuel/propulsion System
RECALL NOTICE EOE WAS PERFORMED ON MY 2010 PRIUS TO CORRECT AN INVERTOR PROBLEM. A SOFTWARE UPDATE WAS PERFORMED. ACCORDING TO MY DEALER AT CAPISTRANO TOYOTA AS WELL AS OTHER DEALERS THIS WAS JUST A BANDAID AND NOT A TRUE FIX. THE OWNER OF CAPISTRANO TOYOTA AS WELL AS OTHER TOYOTA DEALERS HAVE WRITTEN TO TOYOTA THAT THE INVER…
Read full complaint
RECALL NOTICE EOE WAS PERFORMED ON MY 2010 PRIUS TO CORRECT AN INVERTOR PROBLEM. A SOFTWARE UPDATE WAS PERFORMED. ACCORDING TO MY DEALER AT CAPISTRANO TOYOTA AS WELL AS OTHER DEALERS THIS WAS JUST A BANDAID AND NOT A TRUE FIX. THE OWNER OF CAPISTRANO TOYOTA AS WELL AS OTHER TOYOTA DEALERS HAVE WRITTEN TO TOYOTA THAT THE INVERTOR NEEDS TO BE REPLACED. THE DEALER H,S HAD MANY CARS COME BACK AFTER THE SOFTWARE FIX AND HAD TO HAVE THE INVERTOR CHANGED. IF THE INVERTOR FAILS WHILE DRIVING, THE CAR CAN POSSIBLY JUST STOP RUNNING OR SLOW DOWN TO 15 MILES. THIS WILL BE VERY DANGEROUS AND POSSIBLY DEADLY.
NHTSA ODI #11121917
100,000 miles · Aug 13, 2018
EngineFuel/propulsion SystemUnknown Or Other
VEHICLE HAS LOST POWER ON THE FREEWAY MULTIPLE TIMES FORCING ME TO PULL OVER. IN ONE INSTANCE I WAS ALMOST REAR ENDED BY A SEMI. THE VEHICLE WILL SHOW A TEMPERATURE WARNING AND WILL THEN SHUT DOWN AND READ, "CHECK HYBRID SYSTEM". THE TOYOTA DEALERSHIP CLAIMS IT NEEDS A NEW ENGINE. THIS IS A WELL KNOWN ISSUE AND WILL GO IN FRONT …
Read full complaint
VEHICLE HAS LOST POWER ON THE FREEWAY MULTIPLE TIMES FORCING ME TO PULL OVER. IN ONE INSTANCE I WAS ALMOST REAR ENDED BY A SEMI. THE VEHICLE WILL SHOW A TEMPERATURE WARNING AND WILL THEN SHUT DOWN AND READ, "CHECK HYBRID SYSTEM". THE TOYOTA DEALERSHIP CLAIMS IT NEEDS A NEW ENGINE. THIS IS A WELL KNOWN ISSUE AND WILL GO IN FRONT OF A JUDGE IN JANUARY. I HAVE CONTACTED TOYOTA ABOUT THIS AND THEY TELL ME IT IS OUT OF WARRANTY AND NOT ELIGIBLE FOR THE WARRANTY ENHANCEMENT. THIS SHOULD HAVE BEEN AN UNLIMITED MILEAGE RECALL BUT TOYOTA REFUSES TO DO ANYTHING ABOUT IT. THIS HAPPENED AGAIN THIS MORNING TO MY WIFE WHO WAS ON A FREEWAY WHERE THE SPEED LIMIT IS 70MPH. THIS IS AN EXTREMELY DANGEROUS ERROR AND I WOULD HATE TO SEE SOMEONE DIE BECAUSE THEIR CAR STOPS ON THE FREEWAY. THIS VEHICLE HAS ALSO HAD SEVERAY P0401 CODES, THERE IS AN WARRANTY ENHANCEMENT FOR THIS AS WELL BUT LIMITED TO 150K MILES. I WAS TOLD BY THE TOYOTA DEALERSHIP IT WAS ALSO A CULPRIT FOR A BLOWN HEAD GASKET.
NHTSA ODI #11119570
160,000 miles · Jul 26, 2018
Fuel/propulsion System
TOYOTA INVERTER FAILURE. MY SPECIFIC VIN WASN'T INCLUDED IN THE RECALL, BUT THE IPM DID FAIL, IN THE MIDDLE OF THE STREET, WHILE DRIVING, MY CAR LOST ALL POWER & WENT INTO LIMP HOME MODE. FORTUNATELY THE STREET WASN'T BUSY & I WASN'T STRUCK BY ANOTHER VEHICLE AS I HAD MY 6 WEEK OLD NEWBORN IN THE CAR WITH ME. I HAD DUTIFULLY CHE…
Read full complaint
TOYOTA INVERTER FAILURE. MY SPECIFIC VIN WASN'T INCLUDED IN THE RECALL, BUT THE IPM DID FAIL, IN THE MIDDLE OF THE STREET, WHILE DRIVING, MY CAR LOST ALL POWER & WENT INTO LIMP HOME MODE. FORTUNATELY THE STREET WASN'T BUSY & I WASN'T STRUCK BY ANOTHER VEHICLE AS I HAD MY 6 WEEK OLD NEWBORN IN THE CAR WITH ME. I HAD DUTIFULLY CHECKED TO SEE IF MY CAR WAS INVOLVED IN THE RECALL & IT WASN'T, EVEN THOUGH IT FAILED. THEY ONLY FIX IT AFTER IT FAILS, WHICH IS OUTRAGEOUS. SOMEONE IS GOING TO DIE WHEN THEIR PRIUS LOSES ALL POWER WHILE DRIVING AT HIGHWAY SPEEDS.
NHTSA ODI #11113922
152,510 miles · Jul 20, 2018
Fuel/propulsion System
LEAVING A PARKING LOT DRIVING AT UNDER 20 MPH, 'CHECK HYBRID SYSTEM' FLASHED WITH ENGINE ICON APPEARING; AMBIENT TEMPERATURE AT 104 DEGREES. DROVE HOME AND CONNECTED WIFI ELM 327 THAT DISPLAYED P0A080 DTC. FAILURE MILEAGE 152510 JUST OUTSIDE 150K CALIFORNIA EMISSIONS WARRANTY BUT BELOW 10 YEAR WARRANTY AT 9 YEARS AND 2 DAYS FA…
Read full complaint
LEAVING A PARKING LOT DRIVING AT UNDER 20 MPH, 'CHECK HYBRID SYSTEM' FLASHED WITH ENGINE ICON APPEARING; AMBIENT TEMPERATURE AT 104 DEGREES. DROVE HOME AND CONNECTED WIFI ELM 327 THAT DISPLAYED P0A080 DTC. FAILURE MILEAGE 152510 JUST OUTSIDE 150K CALIFORNIA EMISSIONS WARRANTY BUT BELOW 10 YEAR WARRANTY AT 9 YEARS AND 2 DAYS FAILING 07-16-18. DROVE TO NEAREST TOYOTA DEALERSHIP 07-17-18 WHO DIAGNOSED DTC P0A80 P0A3000 TO BATTERY BLOCKS V06 12.67 VOLTS, V07 13.91 VOLTS. V05 14.14 VOLTS, V09 14.18 VOLTS, V10 14.18 VOLTS. DETAIL CODE 1 IS 123. POOR FUEL MILEAGE AND OSCILLATING CHARGE DISCHARGE OF HYBRID BATTERY PACK BEGAN 02-09-2015 AT 91,036 MILES TYPICALLY 42.7 MPG. TOYOTA MOTOR SALES DENIED GOOD WILL ASSISTANCE REQUEST CITING OUT OF WARRANTY CASE # 1807172401. REMEDY IS REPLACE HYBRID BATTERY PACK AT NEAR $4K WITH CORE EXCHANGE.
NHTSA ODI #11112520
154,000 miles · Jul 18, 2018
Fuel/propulsion System
ON 05/12/2018, THE VEHICLE WAS IN MOTION, MERGING ONTO THE FREEWAY, WHEN THE CHECK ENGINE LIGHT CAME ON AND THE MESSAGE "CHECK HYBRID SYSTEM" WAS DISPLAYED. THE VEHICLE WAS NOT DRIVEABLE AT NORMAL STREET SPEEDS AND HAD TO BE TOWED OFF THE FREEWAY ONRAMP. THE VEHICLE WAS TOWED TO A TOYOTA DEALERSHIP ON 05/16/2018, WHERE THE DIAGN…
Read full complaint
ON 05/12/2018, THE VEHICLE WAS IN MOTION, MERGING ONTO THE FREEWAY, WHEN THE CHECK ENGINE LIGHT CAME ON AND THE MESSAGE "CHECK HYBRID SYSTEM" WAS DISPLAYED. THE VEHICLE WAS NOT DRIVEABLE AT NORMAL STREET SPEEDS AND HAD TO BE TOWED OFF THE FREEWAY ONRAMP. THE VEHICLE WAS TOWED TO A TOYOTA DEALERSHIP ON 05/16/2018, WHERE THE DIAGNOSTIC FOUND THAT THE INVERTER NEEDED TO BE REPLACED. THE DIAGNOSTIC DID NOT FIND ANY OTHER FAULT CODES. THE INVERTER WAS REPLACED UNDER WARRANTY. THEN, 3 WEEKS AFTER THE COMPLETED REPAIR (LESS THAN 200 MILES), ON 06/11/2018, THE VEHICLE WAS STATIONARY AND IDLING WHEN THE CHECK ENGINE LIGHT CAME ON AND THE MESSAGE "CHECK HYBRID SYSTEM" WAS DISPLAYED. THE VEHICLE WAS TOWED TO THE SAME TOYOTA DEALERSHIP, WHERE THE DIAGNOSTIC FOUND THAT THE FAULT CODE WAS WITH THE HYBRID BATTERY THIS TIME, WHEN IT PREVIOUSLY HAD NOT BEEN AN ISSUE. AFTER THE CODE WAS CLEARED, THE VEHICLE WAS 100% DRIVEABLE AND TAKEN HOME WHILE WE CONSULTED OPTIONS FOR ALTERNATIVE REPAIR OR DIAGNOSTICS.
NHTSA ODI #11112064
60,600 miles · May 24, 2018
Fuel/propulsion SystemService BrakesVehicle Speed Control
BRAKE ACTUATOR HAS FAILED. TRACTION CONTROL, ABS, BRAKE LIGHTS ILLUMINATED ON DASH. MORE EFFORT NEEDED TO ENGAGE BRAKES. THIS AFFECTS THE REGENERATIVE BRAKING AS IT NO LONGER CHARGES ON BRAKING AS IT WAS DESIGNED. CHECKED TOYOTA WEBSITE FOR RECALLS SINCE THIS IS SAFETY RELATED, AND THERE ARE NONE. WHICH IS QUITE DISTURBING. I'V…
Read full complaint
BRAKE ACTUATOR HAS FAILED. TRACTION CONTROL, ABS, BRAKE LIGHTS ILLUMINATED ON DASH. MORE EFFORT NEEDED TO ENGAGE BRAKES. THIS AFFECTS THE REGENERATIVE BRAKING AS IT NO LONGER CHARGES ON BRAKING AS IT WAS DESIGNED. CHECKED TOYOTA WEBSITE FOR RECALLS SINCE THIS IS SAFETY RELATED, AND THERE ARE NONE. WHICH IS QUITE DISTURBING. I'VE RESEARCHED PRIUS FORUMS AND THIS SEEMS TO BE AN ONGOING PROBLEM. TOYOTA ISSUED A RECALL FOR THE GENERATION 2 MODEL, HOWEVER THIS SEEMS TO BE A PROBLEM FOR GENERATION 3 MODELS AS WELL. THE PROBLEM DID OCCUR WHEN ON THE HIGHWAY TRAVELING AT 60 MPH.
NHTSA ODI #11097727
185,673 miles · Apr 5, 2018
Electrical SystemFuel/propulsion System
I HAD A SUDDEN LOSS OF POWER WITH A POPPING SOUND. THE FAILURE NEARLY CAUSED AN ACCIDENT BECAUSE I WAS TURNING INTO A TRAFFIC LANE. THIS LEFT ME STALLED IN THAT LANE OF TRAFFIC. THE FAILURE TURNED OUT TO BE THE INVERTER OVER HEATING WAS CAUSED BY THE COOLING PUMP IN THE INVERTER FAILING, WHICH CAUSED THE INVERTER TO OVERHEAT.…
Read full complaint
I HAD A SUDDEN LOSS OF POWER WITH A POPPING SOUND. THE FAILURE NEARLY CAUSED AN ACCIDENT BECAUSE I WAS TURNING INTO A TRAFFIC LANE. THIS LEFT ME STALLED IN THAT LANE OF TRAFFIC. THE FAILURE TURNED OUT TO BE THE INVERTER OVER HEATING WAS CAUSED BY THE COOLING PUMP IN THE INVERTER FAILING, WHICH CAUSED THE INVERTER TO OVERHEAT. THIS WAS NOT COVERED BY WARRANTY AND WAS A VERY EXPENSIVE REPAIR. I CHOSE NOT TO HAVE THE DEALER REPAIR IT AT THEIR EXTREME PRICES. I PAID THE DEALER TO DIAGNOSE THE PROBLEM. THEN I HAD GREENTEC IN OLATHE KS. REPAIR THE SYSTEM AT 1/2 THE COST THAT THE DEALER WANTED
NHTSA ODI #11083530
125,000 miles · Feb 10, 2018
EngineFuel/propulsion System
AT ABOUT 125K MILES, MY PRIUS NEARLY RAN OUT OF OIL BETWEEN SERVICES, AND I RELIGIOUSLY SERVICE MY VEHICLE. I BURNED 1 TO 2 QUARTS BETWEEN SERVICES SINCE. AT 272,408 MILES, I JUST PAID $5751.59 FOR A COMPLETE ENGINE REBUILD... REST OF CAR IS IN GREAT SHAPE. OIL CONSUMPTION PROBLEMS WERE KNOWN BY THE DEALERSHIPS, BUT I WAS GIVE…
Read full complaint
AT ABOUT 125K MILES, MY PRIUS NEARLY RAN OUT OF OIL BETWEEN SERVICES, AND I RELIGIOUSLY SERVICE MY VEHICLE. I BURNED 1 TO 2 QUARTS BETWEEN SERVICES SINCE. AT 272,408 MILES, I JUST PAID $5751.59 FOR A COMPLETE ENGINE REBUILD... REST OF CAR IS IN GREAT SHAPE. OIL CONSUMPTION PROBLEMS WERE KNOWN BY THE DEALERSHIPS, BUT I WAS GIVEN NO RECOURSE EXCEPT DEALING WITH IT. LATEST ISSUE..CHECK ENGINE LIGHT ON, MISFIRE ON CYLINDERS 1 AND 4 (PROGRESSING TO ALL), HORRIFIC KNOCKING NOISE WITH SOUND OF RUSHING WATER UPON START-UP. EVENTUALLY, (ONCE THE CYLINDERS FIRED SIGNIFICANTLY) THE ENGINE COULD RUN SATISFACTORILY FOR THE REMAINDER OF THE DRIVE... UNTIL THE NEXT START. EARLY ON I READ THAT TOYOTA KNEW OF THE UNDER-ENGINEERED MOTOR OF THE 2010S, BUT I HAVE NOT RECEIVED ANYTHING ANNOUNCING A RECALL OR CARE TO FIX THEIR ENGINEERING ISSUE. I HAVE MY SERVICE RECORDS TO VALIDATE THE CARE I'VE GIVEN TO MY CAR. THE DATE OF THE ENGINE REBUILD IS WHAT I WILL PROVIDE AS TO WHEN THIS HAPPENED, BUT THE OIL CONSUMPTION BEGAN YEARS AGO.
NHTSA ODI #11072119
130,000 miles · Nov 26, 2017
Fuel/propulsion System
48 MPG WHEN PURCHASED NEW IN JULY 2009. 30 MPG AT 130,000 MILES IN 2016. GUMOUT AND SEAFOAM HELPED CLEAN OUT FUEL INJECTORS WITH IMPROVED 35 MPG.
NHTSA ODI #11048514
163,500 miles · Sep 6, 2017
Electrical SystemEngineFuel/propulsion System
WATER LEAKING FROM ENGINE COWEL GETTING INTO IGNITION COILS WHICH IS CAUSING ENGINE TO SHUDDER AND STOP SOMETIMES TOO. SEEMS TO BE A KNOWN TOYOTA ISSUE YET NOT BEING RECTIFIED BY MANUFACTURER. SEALS SEEM TO ALLOW WATER TO GET INTO THE IGNITION COILS HENCE THE ISSUE. VEHICLE IS STATIONARY WHEN FIRST OBSERVED THEN SHUDDERING AND M…
Read full complaint
WATER LEAKING FROM ENGINE COWEL GETTING INTO IGNITION COILS WHICH IS CAUSING ENGINE TO SHUDDER AND STOP SOMETIMES TOO. SEEMS TO BE A KNOWN TOYOTA ISSUE YET NOT BEING RECTIFIED BY MANUFACTURER. SEALS SEEM TO ALLOW WATER TO GET INTO THE IGNITION COILS HENCE THE ISSUE. VEHICLE IS STATIONARY WHEN FIRST OBSERVED THEN SHUDDERING AND MISFIRING OCCURRING AS VEHICLE IS BEING DRIVEN ALSO LEADING TO LOSS OF POWER AS ITS BEING DRIVEN WHICH IS QUITE DANGEROUS ON HIGHWAYS.
NHTSA ODI #11021849
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration