NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
192 reportsClear category filterMileage unknown · Mar 31, 2022
Electrical SystemFuel/propulsion SystemUnknown Or Other
I was driving on the road and right before a stop light my car jumped as if someone hit me from behind. After looking in my rear view and seeing no one on me I realized something else happened. I look at my dash and check hybrid system light was on. I was in traffic at the light waiting and looked it up on my phone to find out w…
Read full complaint
I was driving on the road and right before a stop light my car jumped as if someone hit me from behind. After looking in my rear view and seeing no one on me I realized something else happened. I look at my dash and check hybrid system light was on. I was in traffic at the light waiting and looked it up on my phone to find out what to do. Some article said to pull over and turn it off and restart it. The light turned green and traffic started moving so I started to drive. I thought I could probably make it home but the car started driving a lot slower than usual. I really didn’t want to pull over because it was in a bad part of town but I felt like I had no choice because the car was barely moving. It seemed more dangerous to be on the road with other drivers. So I pulled over and parked and tried starting it again. It wouldn’t shift to drive so now I’m stuck and can’t get home unless I pay to get my car towed. I get my car towed to the house. I put a meter on the battery and it was fine. I put a diagnostics tester on it and came up with these codes POA1A and POA94. I contacted hybrid mechanic that doesn’t work at Toyota and he said to take it in to a dealership and sent me the ZE3 warranty letter and said they would fix it. I paid for it to be towed to the dealership. There were already a lot of cars waiting to be serviced when I got there. Anyway, they said they would fix it after they did their diagnostics after I paid $120 for it. That was 3/21/2022. I sent CSR the ZE3 letter and he said it wasn’t covered. It’s like he didn’t even read it. A day later he said he needed to talk to a warranty administrator then a day later he said it would be covered but I don’t qualify for a loaner but they can give me a rental for $45 a day. I friend let me borrow their car for a couple days. Now as of writing this it’s midnight 3/30/2022. I still don’t have my car and I’m about to be without a car unless I buy one or rent one. No ETA on the part being delivered either. I’m SOL.
NHTSA ODI #11459053
Mileage unknown · Dec 9, 2021
Electrical SystemService Brakes
Brake Booster Failure; has been inspected and confirmed. Warning lamps for traction control, ABS, Brake System Lights, Master Warning Light all came on during normal city driving. Immediate loss of Brake Assist causing sudden need for much more distance while stopping the vehicle. Clearly, sudden changes in brake behavior is a …
Read full complaint
Brake Booster Failure; has been inspected and confirmed. Warning lamps for traction control, ABS, Brake System Lights, Master Warning Light all came on during normal city driving. Immediate loss of Brake Assist causing sudden need for much more distance while stopping the vehicle. Clearly, sudden changes in brake behavior is a safety concern and this problem seems to be well documented as common issue in this era of Toyota vehicles. I believe Toyota has fallen short in its efforts to remmedy the situation. An extended warranty was issued but it was for a brief period of time that required this problem to occur within a narrow window. It's a wildly expensive repair to a critical system and it seems to be a common problem in these cars.
NHTSA ODI #11443264
Mileage unknown · Oct 8, 2021
Electrical SystemFuel/propulsion System
Last week I check hybrid system message appeared on the screen and orange triangle with check engine light. I took it to the shop and they said that there are code P0A94 wich is related to the inverted and that is needed replacement. I saw that there was recall on inverter and want to see if I can get it replaced. Thanks
NHTSA ODI #11436041
115,001 miles · Sep 20, 2021
Electrical SystemService Brakes, Hydraulic
The contact owns a 2010 Toyota Prius. The contact stated that while driving, the brake lights, ABS, and check engine warning lights illuminated. There was an abnormal noise detected. The vehicle was taken to the local dealer and diagnosed that the brake booster assembly needed to be replaced. Additionally, the contact was inform…
Read full complaint
The contact owns a 2010 Toyota Prius. The contact stated that while driving, the brake lights, ABS, and check engine warning lights illuminated. There was an abnormal noise detected. The vehicle was taken to the local dealer and diagnosed that the brake booster assembly needed to be replaced. Additionally, the contact was informed that the vehicle was not safe to drive. The manufacturer was notified of the failure and referred the contact to NHTSA. The failure mileage was approximately 115,000. The VIN was not available.
NHTSA ODI #11433671
Mileage unknown · Sep 15, 2021
Electrical SystemService BrakesUnknown Or Other
I have recently bought a 2010 Prius. The ABS (!) , traction control, and emergency brake light all illuminated three days after I transferred title with the dmv. This apparently is a very common problem with this car. I am told that these lights lead to a very expensive repair. My primary concern is my safety and of course t…
Read full complaint
I have recently bought a 2010 Prius. The ABS (!) , traction control, and emergency brake light all illuminated three days after I transferred title with the dmv. This apparently is a very common problem with this car. I am told that these lights lead to a very expensive repair. My primary concern is my safety and of course the safety of others. A car that has brakes that suddenly fail is lethal. I was advised by a helpful agent that these repairs would come out of my pocket. My complaint is that Toyota should be responsible for this. I cannot drive this vehicle at the moment because I refuse to endanger anyone.
NHTSA ODI #11433111
Mileage unknown · Sep 8, 2021
Electrical SystemExterior LightingVehicle Speed Control
The dash lights on my 2010 Prius went all dark, lost all information on my dash. No lights on dash, no fuel gauge, no speedometer, nothing. This is very dangerous to suddenly have happened and I don't see a recall from Toyota to address this problem.
NHTSA ODI #11432083
Mileage unknown · Jul 19, 2021
Electrical SystemService Brakes
While driving on a highway at night around 60 mph, brake light turned on then AB light then slip light. Nothing else happened but since this hadn’t happened before, I pulled over, turned off car, waited a bit then turned back on. Car still worked although these lights stayed on. Continued driving to get home at reduced speed (ar…
Read full complaint
While driving on a highway at night around 60 mph, brake light turned on then AB light then slip light. Nothing else happened but since this hadn’t happened before, I pulled over, turned off car, waited a bit then turned back on. Car still worked although these lights stayed on. Continued driving to get home at reduced speed (around 45-50) plus with blinkers on with mental note to take to the dealer next morning. A few miles out, a loud unchanging alarm went off and I couldn’t use my brakes no matter how hard I pressed on them. I was able to glide off an exit that was near and making right turns get into a lot. Also neither of the brake pad nor the parking button was working so I couldn’t stop the car but then I hit power to shut down and that was able to stop it. Called for towing to dealer the following day. They say it’s the brake booster and that I have to pay out of pocket since it passed a recall but this is a dangerous issue with the car. If the light had been red and a car crossing, without brakes I would have gotten into an accident and since I bought it used last year, I wouldn’t have even known about this being an issue. There shouldn’t be a date limit on this recall, if models of Toyota Prius needs the recall and it hadn’t been done by previous owner, it needs to be done as this is a really traumatizing and potentially deadly issue.
NHTSA ODI #11425436
Mileage unknown · Jul 7, 2021
Electrical SystemExterior Lighting
The headlights on my car would get very dim and would burnout within 4 to 6 months. As time has past the time between bulb replacement would get shorter and shorter. At this point when I plug replacement bulbs into my car the burnout instantly. Without low beam headlights I am required to drive with my high beams on at all tim…
Read full complaint
The headlights on my car would get very dim and would burnout within 4 to 6 months. As time has past the time between bulb replacement would get shorter and shorter. At this point when I plug replacement bulbs into my car the burnout instantly. Without low beam headlights I am required to drive with my high beams on at all times. The dealer and the manufacture know about the problem and there was a notification regarding this issue with the headlights, but I was not sent this notice. Had I been sent the notice from Toyota I would have brought my car into the dealership for them to inspect the light problem. From what I have learned from Toyota is that there was never a recall on this issue. Headlights on a car I would think would be considered a major safety feature and should not have an expiration date on such a repair issue. The program to fix the issue was called Customer Support Program ZHB which allowed the dealers to correct the problem. How would anyone know that there was a problem unless they get a notification.
NHTSA ODI #11423753
Mileage unknown · Jun 30, 2021
Electrical SystemFuel/propulsion SystemVehicle Speed ControlInjury
Check hybrid system light ignites, slows down vehicle in middle of high speed highway. First incident November of 2020 then several incidents after. Repair shops don't assure problem according to error codes & they recommend possibilities they cannot assure will resolve the problem. Car was taken into local dealership after rece…
Read full complaint
Check hybrid system light ignites, slows down vehicle in middle of high speed highway. First incident November of 2020 then several incidents after. Repair shops don't assure problem according to error codes & they recommend possibilities they cannot assure will resolve the problem. Car was taken into local dealership after receiving recall notice for software and airbags prior to November 2020 when the issue began. Software update took a couple of hours. Restart/reboot temporarily allowed driving again. Most recently the system entirely shut down & the car will not start or run. Abandoned car on side of the road and got heat exhaustion from walking the rest of the way home and had vehicle towed. Error lights come on including "check hybrid system" says "shift to P position when starting" and will not allow start.
NHTSA ODI #11422908
Mileage unknown · Jun 6, 2021
Electrical SystemEngineService Brakes
My problem began when I pressed my brakes and instead it accelerated. I thought maybe my foot slipped and didn’t know what it meant. It happened again a few weeks later and then all of the dash lights went on that indicated that I had to have the big brake recall repair. Being that my car is past the 10 year warranty and past th…
Read full complaint
My problem began when I pressed my brakes and instead it accelerated. I thought maybe my foot slipped and didn’t know what it meant. It happened again a few weeks later and then all of the dash lights went on that indicated that I had to have the big brake recall repair. Being that my car is past the 10 year warranty and past the extension for mileage, I had to pay out of pocket. This repair was done and upon receiving my car back, the gas mileage instantly began to drop. It went from averaging 42-48MPG in my town to 25-30MPG. I took it in the be looked at and they ensured me nothing was wrong with the car AT ALL. The battery wasn’t holding charge on top of this and it wasn’t reading the same on the dash about the 0-100 current gas mileage you’re getting as you go (the lines scale thing) that goes up when you let off the gas, and I could feel a strange shift while I was driving so I took it in again. They told me this time it’d be $110 to diagnose even though it was the same issue that started after the brake system repair, so I left extremely upset. A few days later my cars steering went out while I was driving and the whole hybrid system died. The car now only works in power mode. The consumer stated the car was taken in for a brake recall and had to pay $2800 in repairs. The consumer stated what they thought was a battery failure turned out to be the beginning of an electrical motor failure related to overheating.
NHTSA ODI #11419852
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration