IllustrationI OWN A 2009 PRIUS, PURCHASE DEC 2008. I HAVE EXPERIENCED SIMILAR BRAKE PROBLEMS AS 2010. WHEN I HIT A ROUGH OR BUMPY ROAD, THE BRAKES GET SQUISHY & LESS EFFECTIVE. I NOTE THE ANTI-SKID CAUTION FLASHES, BRAKES DO BECOME SLIGHTLY LESS EFFECTIVE. I AM AN ENGINEER. I REPORTED THIS TO TOYOTA 2/8/2010.
2009 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1880–25K
4325–50K
4050–75K
4675–100K
52100–150K
33150K+
402 reports with mileage · 100 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
64 crash reports4 fire reports21 injury reports
What owners actually said
502 reportsACCELERATOR STICKING ON 2009 TOYOTA PRIUS
MY 2009 TOYOTA PRIUS IS EXHIBITING THE SAME BRAKING BEHAVIOR AS PREVIOUSLY IDENTIFIED IN THE 2010 MODELS. THERE IS A MANHOLE COVER ON A STREET I FREQUENTLY DRIVE NEAR A STOP LIGHT. ON NUMEROUS OCCASIONS WHEN I APPLY THE BRAKES TO STOP I HAVE HIT THE MANHOLE COVER AND AT WHICH POINT THE CAR SEEMS TO LOOSE CONTROL. WHILE MOST DAY…
Read full complaint
MY 2009 TOYOTA PRIUS IS EXHIBITING THE SAME BRAKING BEHAVIOR AS PREVIOUSLY IDENTIFIED IN THE 2010 MODELS. THERE IS A MANHOLE COVER ON A STREET I FREQUENTLY DRIVE NEAR A STOP LIGHT. ON NUMEROUS OCCASIONS WHEN I APPLY THE BRAKES TO STOP I HAVE HIT THE MANHOLE COVER AND AT WHICH POINT THE CAR SEEMS TO LOOSE CONTROL. WHILE MOST DAYS THIS IS NOT AN ISSUE BECAUSE THERE IS NO ONE IN FRONT OF ME, ON OCCASION I HAVE COME CLOSE TO REAR-ENDING THE CAR IN FRONT OF ME BECAUSE OF THIS ISSUE. AT FIRST I THOUGHT IT WAS DUE TO THE DESIGN OF THE HYBRID, BUT THE RECENT ARTICLES ABOUT THE 2010 MODELS HAVE PUSHED ME TO BRING THIS ISSUE TO THE FOREFRONT. IT MIGHT NOT BE SIMPLY THE 2010 MODELS. *TW
I HAVE THE BRAKE PROBLEM BEING REPORTED FOR THE PRIUS, BUT MINE IS A 2009 MODEL. WHEN BRAKING ON ROUGH SURFACES, THE BRAKES QUIT FOR A MOMENT. SINCE I DON'T TAILGATE, I'VE NEVER FELT IN DANGER. BUT IT IS A SLIGHTLY OUT OF CONTROL FEELING. I'VE FILLED IN THE DATE BELOW AS MAY 2009, WHEN I PURCHASED (LEASED) THE CAR. BUT THE SITUA…
Read full complaint
I HAVE THE BRAKE PROBLEM BEING REPORTED FOR THE PRIUS, BUT MINE IS A 2009 MODEL. WHEN BRAKING ON ROUGH SURFACES, THE BRAKES QUIT FOR A MOMENT. SINCE I DON'T TAILGATE, I'VE NEVER FELT IN DANGER. BUT IT IS A SLIGHTLY OUT OF CONTROL FEELING. I'VE FILLED IN THE DATE BELOW AS MAY 2009, WHEN I PURCHASED (LEASED) THE CAR. BUT THE SITUATION HAS BEEN CONTINUOUS. *TW
I OWN A 2009 TOYOTA PRIUS AND WHEN THE VEHICLE ENCOUNTERS A POT HOLE OR ANY ROUGH ROAD SERVICE, IT JUMPS AHEAD AND THERE IS A DELAY WHEN I ATTEMPT TO BRAKE. ON THE DASHBOARD THE ICY ROADWAY INDICATAOR APPEARS AT THESE TIMES. THIS SIITUATION HAS BEEN ONGOING SINCE I PURCHASED THE VEHICLE IN APRIL 2009 *CN
I OWN A 2009 PRIUS AND I HAVE NOTICED NUMEROUS TIMES WHEN I AM DRIVING AT A SLOW RATE OF SPEED AND I HIT A BUMP, I LOSE CONTROL OF THE CAR FOR A SPLIT SECOND. IT SEEMS THE BRAKES LOSE TRACTION. WHEN THIS HAPPENS, I NOTICE A ORANGE LIGHT ON THE DASH LIGHTS UP FOR A SECOND. *CN
BRAKE FAILURE WHEN GOING OVER ROUGH PAVEMENT OR POTHOLE IN BOTH 2005 AND 2009 TOYOTA PRIUS. WE HAVE OWNED TWO PRIUS, A 2005 AND NOW A 2009, AND BOTH HAVE EXHIBITED THE BRAKING ANOMOLY THAT IS BEING DESCRIBED IN THE PRESS AS ONLY OCCURING WITH THE 2010 PRIUS. I EXPERIENCE THIS FAILURE FREQUENTLY. THE FAILURE OCCURS ONLY BRIEFLY…
Read full complaint
BRAKE FAILURE WHEN GOING OVER ROUGH PAVEMENT OR POTHOLE IN BOTH 2005 AND 2009 TOYOTA PRIUS. WE HAVE OWNED TWO PRIUS, A 2005 AND NOW A 2009, AND BOTH HAVE EXHIBITED THE BRAKING ANOMOLY THAT IS BEING DESCRIBED IN THE PRESS AS ONLY OCCURING WITH THE 2010 PRIUS. I EXPERIENCE THIS FAILURE FREQUENTLY. THE FAILURE OCCURS ONLY BRIEFLY -ABOUT ONE OR TWO SECONDS AND WE HAVE NEVER HAD AN ACCIDENT BECAUSE OF THIS. HOWEVER, IT IS DISCONCERTING AND IF THIS IS A MALFUNCTION, IT SHOULD BE TAKEN CARE OF FOR ALL PRIUS, NOT JUST 2010. *CN
1. BRAKES FAIL TO WORK PROPERLY 2. OCCURS AT LEAST ONCE OR TWICE WEEKLY; CONSEQUENCES -- EMOTIONAL DURESS AND CONCERN; NO ACCIDENTS YET, THANK GOD. 3. NOTHING HAS BEEN DONE TO CORRECT THIS YET. I WENT TO MY TOYOTA DEALER, TOYOTA CAVENDER IN SAN ANTONIO, TX 48 HRS AGO TO GET USUAL OIL CHANGE AND TO GET THE BRAKES CHECKED FOR…
Read full complaint
1. BRAKES FAIL TO WORK PROPERLY 2. OCCURS AT LEAST ONCE OR TWICE WEEKLY; CONSEQUENCES -- EMOTIONAL DURESS AND CONCERN; NO ACCIDENTS YET, THANK GOD. 3. NOTHING HAS BEEN DONE TO CORRECT THIS YET. I WENT TO MY TOYOTA DEALER, TOYOTA CAVENDER IN SAN ANTONIO, TX 48 HRS AGO TO GET USUAL OIL CHANGE AND TO GET THE BRAKES CHECKED FOR THIS PROBLEM. I WAS TOLD BY THE SERVICE DEPT. THAT THEY WERE CLOSING IN AN HOUR AND THE TOYOTA PRIUS TECHNICIAN WAS NOT THERE. I HAD TO CALL FOR AN APPOINTMENT WITH HIM -- EVEN THOUGH MY BRAKES HAD NEARLY FAILED TO STOP WHEN I PULLED INTO THE DEALERSHIP SERVICE AREA. *CN
I HAVE A 2009 PRIUS. I'VE BEEN COMPLAINING TO FRIENDS AND FAMILY, SINCE I GOT IT ABOUT SIX MONTHS AGO, ABOUT ITS INSTABILITY WHEN I GO OVER SMALL BUMPS AND RUTS IN THE ROAD. THE CAR SEEMS TO SURGE AHEAD, SWERVE A BIT, AND LOSE CONTACT WITH THE GROUND. THE OTHER MAJOR PROBLEM IS THE CAR'S HORRIBLE TRACTION ON WET HIGHWAYS. IF I'M…
Read full complaint
I HAVE A 2009 PRIUS. I'VE BEEN COMPLAINING TO FRIENDS AND FAMILY, SINCE I GOT IT ABOUT SIX MONTHS AGO, ABOUT ITS INSTABILITY WHEN I GO OVER SMALL BUMPS AND RUTS IN THE ROAD. THE CAR SEEMS TO SURGE AHEAD, SWERVE A BIT, AND LOSE CONTACT WITH THE GROUND. THE OTHER MAJOR PROBLEM IS THE CAR'S HORRIBLE TRACTION ON WET HIGHWAYS. IF I'M TRAVELING OVER 45 M.P.H., MY CAR BEGINS TO HYDROPLANE. THE EXPERIENCE IS UNNERVING. I'VE NEVER DRIVEN A CAR THAT FEELS SO UNSAFE AND THAT MAKES ME FEEL SUCH A LACK OF CONFIDENCE, AND I'VE BEEN DRIVING FOR 35 YEARS. PLUS, DURING THE LAST SNOWSTORM, WHEN I PUT MY PRIUS IN PARK ON A SLIGHT INCLINE ON THE ROAD IN FRONT OF MY HOME, THE CAR SLID ABOUT 20 FEET, IN PARK. I HAD TO PUT ON THE EMERGENCY BRAKE TO STOP. IT SLIDES ALL OVER THE ROAD, IN SNOW. I HATE THIS CAR AND WISH I'D NEVER BOUGHT IT. I BELIEVE THAT ITS MERITS WERE MISREPRESENTED. DESPITE THE CHOSEN DATE THAT YOU'VE REQUIRED ME TO ENTER, UNFORTUNATELY THESE PROBLEMS ARE ONGOING. *TR
TOYOTA PRIUS II BRAKE ISSUES. I HAVE A 2009 PRIUS THAT EXHIBIT SIMILAR BRAKING PROBLEMS AS THE RECALLED 2010 PRIUS. WHEN I'M COMING TO A STOP AND HIT A BUMPY PATCH, THE BRAKES WILL RELEASE MOMENTARILY. THE RELEASE IS FOR A SECOND RESULTING IN THE CAR TRAVELING 3 FEET BEFORE I HAVE TO APPLY ADDITIONAL PRESSURE TO THE BRAKES. …
Read full complaint
TOYOTA PRIUS II BRAKE ISSUES. I HAVE A 2009 PRIUS THAT EXHIBIT SIMILAR BRAKING PROBLEMS AS THE RECALLED 2010 PRIUS. WHEN I'M COMING TO A STOP AND HIT A BUMPY PATCH, THE BRAKES WILL RELEASE MOMENTARILY. THE RELEASE IS FOR A SECOND RESULTING IN THE CAR TRAVELING 3 FEET BEFORE I HAVE TO APPLY ADDITIONAL PRESSURE TO THE BRAKES. THIS COULD EASILY MEAN A FENDER BENDER IF I'M A BIT CLOSER TO THE VEHICLE IN FRONT OF ME. IT IS ESPECIALLY AN ISSUE WHEN STOPPING DOWN HILL WHICH IS NOT UNCOMMON HERE IN SEATTLE. I BOUGHT MY CAR (BRAND NEW) IN SPRING OF 2009. I'VE ALWAYS NOTICED THE PROBLEM BUT THOUGHT IT WAS JUST THE NATURE OF THE HYBRID DRIVE. MY CONCERN IS THAT THIS MAY WORSEN WITH THE AGE OF THE CAR. PLEASE ADVISE. I WOULD HATE TO SEE THIS ISSUE DISREGARDED. *TR
Official recalls
613V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606