IllustrationTHE HEADLIGHT JUST GO OFF WHILE DRIVING. ONCE YOU TURN THE LIGHT SWITCH OFF AND THEN ON THEY COME BACK ON FOR A SHORT TIME. THE DEALER IS WANTING $1,400 TO MAKE THE REPAIRS. THIS IS EXTREMELY DANGEROUS WHILE DRIVING AT NIGHT. THERE SHOULD BE A RECALL ON THESE VEHICLES.
2009 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1880–25K
4325–50K
4050–75K
4675–100K
52100–150K
33150K+
402 reports with mileage · 100 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
64 crash reports4 fire reports21 injury reports
What owners actually said
502 reportsHEADLIGHTS FAIL WHILE DRIVING. AT FIRST ONLY THE DRIVER SIDE WOULD GO OUT, THEN THE PASSENGER SIDE WOULD GOT OUT AND MOST RECENTLY BOTH LIGHTS HAVE FAILED WHILE DRIVING AT NIGHT.
TRAVELING 101 NORTH TOWARD VENTURA, ON THE TOP OF THE DOWN HILL GRADE JUST SOUTH OF THE CAMIRILLO SPRINGS EXIT. ALL LIGHTS ON PANEL CAME ON. ESTIMATE 65 MPH, APPLIED BRAKE TO SLOW WITH TRAFFIC FLOW. NO BRAKES,NO WARNING.SEMI TRACKER TRAILERS ALSO SLOWING. TOOK EXIT BOTTOM OF HILL WITH FLASHES ON, WENT THRU STOP SIGN AS MY SPEED…
Read full complaint
TRAVELING 101 NORTH TOWARD VENTURA, ON THE TOP OF THE DOWN HILL GRADE JUST SOUTH OF THE CAMIRILLO SPRINGS EXIT. ALL LIGHTS ON PANEL CAME ON. ESTIMATE 65 MPH, APPLIED BRAKE TO SLOW WITH TRAFFIC FLOW. NO BRAKES,NO WARNING.SEMI TRACKER TRAILERS ALSO SLOWING. TOOK EXIT BOTTOM OF HILL WITH FLASHES ON, WENT THRU STOP SIGN AS MY SPEED AT APPROX 45-48MPH. WENT THRU SECOND STOP SIGN MADE SHARP LEFT PULLED EMERGENCY BRAKE ON... THIS IS A GARAGE CAR SERVICED BY DEALER ONLY, 3RD TIME FOR ELECTRICAL PROBLEM! NEVER WHILE DRIVING.... THIS WAS NEAR FATAL! THIS WAS AN ELECTRICAL PROBLEM OF THE MANUFACTURE, NEVER REPAIRED CORRECTLY! HAVE 3 COPIES OF REPAIRS FOR THE ELECTRICAL STARTING 6 MONTHS AFTER PURCHASE CAR...HELP.
MY HEADLIGHTS INTERMITTENTLY SHUT OFF FOR NO REASON WHILE DRIVING DOWN THE STREET. SOME TIMES IT'S ONLY ONE, OTHER TIMES IT'S BOTH. IF I TURN THE HEADLIGHTS OFF AND THEN BACK ON THEY WORK AGAIN FOR A SHORT TIME. THIS IS VERY SCARY TO HAVE HAPPEN WHEN DRIVING DOWN THE INTERSTATE AT NIGHT. IT HAPPENS ALMOST EVERY TIME I DRIVE. …
Read full complaint
MY HEADLIGHTS INTERMITTENTLY SHUT OFF FOR NO REASON WHILE DRIVING DOWN THE STREET. SOME TIMES IT'S ONLY ONE, OTHER TIMES IT'S BOTH. IF I TURN THE HEADLIGHTS OFF AND THEN BACK ON THEY WORK AGAIN FOR A SHORT TIME. THIS IS VERY SCARY TO HAVE HAPPEN WHEN DRIVING DOWN THE INTERSTATE AT NIGHT. IT HAPPENS ALMOST EVERY TIME I DRIVE. *TR
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT HAD DIFFICULTY OPENING THE TRUNK OF THE VEHICLE. ONCE OPENED, THE PANEL ABOVE THE LICENSE PLATE DETACHED FROM THE VEHICLE. THE PANEL WAS HANGING WITH ALL THE WIRES STILL ATTACHED TO THE VEHICLE. THE CONTACT COULD NO LONGER ACCESS THE TRUNK. THE VEHICLE WAS TAKEN TO AN INDEPEN…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT HAD DIFFICULTY OPENING THE TRUNK OF THE VEHICLE. ONCE OPENED, THE PANEL ABOVE THE LICENSE PLATE DETACHED FROM THE VEHICLE. THE PANEL WAS HANGING WITH ALL THE WIRES STILL ATTACHED TO THE VEHICLE. THE CONTACT COULD NO LONGER ACCESS THE TRUNK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WERE IT WAS DIAGNOSED THAT THE PANEL NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 136,545.
THE CAR WAS INVOLVED IN A MOVING COLLISION THAT TOTALED THE DRIVERS FRONT END AND CAUSED THE DRIVER TO BE INJURED BECAUSE THE AIR BAGS FAILED TO DEPLOY. I SUSPECT THAT THE CARS STEERING FAILED WHILE GOING AROUND A SHARP CURVE. THE CAR HAS LOST STEERING ONE TIME BEFORE AND WAS TAKEN TO THE DEALER WHO COULD NOT DUPLICATE THE PROBL…
Read full complaint
THE CAR WAS INVOLVED IN A MOVING COLLISION THAT TOTALED THE DRIVERS FRONT END AND CAUSED THE DRIVER TO BE INJURED BECAUSE THE AIR BAGS FAILED TO DEPLOY. I SUSPECT THAT THE CARS STEERING FAILED WHILE GOING AROUND A SHARP CURVE. THE CAR HAS LOST STEERING ONE TIME BEFORE AND WAS TAKEN TO THE DEALER WHO COULD NOT DUPLICATE THE PROBLEM. *TR*DT*JB
I HAVE CONTACTED TOYOTA CONCERNING THE FAILURE OF A COMBINATION METER IN MY DAUGHTER'S 2007 PRIUS. THIS HAPPENED ON STARTUP. THIS ITEM IS RELATED TO THE DISPLAY SCREEN. AS MENTIONED IN THEIR WARRANTY POLICY BULLETIN NO: POL 12-05 DATED 10/12/12 A FAILURE CAN RESULT IN THE SCREEN GOING DARK. IF THIS HAPPENS IN THE NIGHT THIS …
Read full complaint
I HAVE CONTACTED TOYOTA CONCERNING THE FAILURE OF A COMBINATION METER IN MY DAUGHTER'S 2007 PRIUS. THIS HAPPENED ON STARTUP. THIS ITEM IS RELATED TO THE DISPLAY SCREEN. AS MENTIONED IN THEIR WARRANTY POLICY BULLETIN NO: POL 12-05 DATED 10/12/12 A FAILURE CAN RESULT IN THE SCREEN GOING DARK. IF THIS HAPPENS IN THE NIGHT THIS CAN RESULT IN A SERIOUS SAFETY ISSUE BOTH BECAUSE OF THE UNEXPECTED AND IMMEDIATE DISTRACTION AND THE LOSS OF CRITICAL VISUAL INFORMATION. THEIR WARRANTY BULLETIN DOES NOT SEEM TO ADDRESS THE SERIOUSNESS OF THE MATTER. IT IS MY OPINION THAT THIS ITEM SHOULD BE AN IMMEDIATE RECALL. MY 2009 PRIUS IS ONE OF THOSE MENTIONED IN THEIR BULLETIN. THOUGH I HAVE NOT EXPERIENCED ANY FAILURE, I BECAME AWARE OF THIS ISSUE WITH THE RECENT EVENT THAT MY DAUGHTER EXPERIENCED. NEITHER I NOR MY DAUGHTER HAS RECEIVED ANY NOTIFICATION FROM TOYOTA. I AM A FAN OF THE PRIUS AS IS MY DAUGHTER, BUT THIS ISSUE IS TOO SERIOUS TO SIMPLY IGNORE. IT IS MY HOPE THAT THIS WILL BE ADDRESSED WITH TOYOTA.
WHILE DRIVING THE HEADLIGHTS WILL TURN OFF. MOST OF THE TIME IT IS THE RIGHT HEADLIGHT AND AT OTHER TIMES THE RIGHT OR BOTH OF THEM WILL GO OUT. IF I TURN THE LIGHT SWITCH ON THE STEERING COLUMN OFF AND THEN BACK ON IT WILL TURN THEM ON FOR A FEW SECONDS. WHEN TAKEN TO THE DEALERSHIP THEY SAID THERE IS NO RECALL BUT THERE ARE PL…
Read full complaint
WHILE DRIVING THE HEADLIGHTS WILL TURN OFF. MOST OF THE TIME IT IS THE RIGHT HEADLIGHT AND AT OTHER TIMES THE RIGHT OR BOTH OF THEM WILL GO OUT. IF I TURN THE LIGHT SWITCH ON THE STEERING COLUMN OFF AND THEN BACK ON IT WILL TURN THEM ON FOR A FEW SECONDS. WHEN TAKEN TO THE DEALERSHIP THEY SAID THERE IS NO RECALL BUT THERE ARE PLENTY OF COMPLAINTS. I WAS PULLED OVER BY A POLICE OFFICER AND THEY LET ME OFF WITH A WARNING TO FIX IT. IT TURNS OFF EVEN WHILE SITTING IN MY DRIVEWAY AS WELL AS WHILE DRIVING. THERE IS NO RHYME OR REASON AS TO WHEN. *TR
TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED THAT THE HATCH WAS MELTED TO THE HATCH LEVER LATCH. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF FAILURE. THE FAILURE MILEAGE WAS 70,000.
2009 TOYOTA PRIUS PASSENGER HEADLIGHT GOES OFF SPONTANEOUSLY WHILE DRIVING OR STATIONARY. WHEN YOU TURN OFF THE HEADLIGHT SWITCH, THEN TURN THEM ON, THE HEADLIGHT TURNS BACK ON FOR A WHILE. THEN AFTER A WHILE THE HEADLIGHT TURNS OFF AGAIN. THIS DEFECT WAS A NHTSA RECALL AND EXTENDED WARRANTY PROBLEM BUT THE DEALER SAID THE WA…
Read full complaint
2009 TOYOTA PRIUS PASSENGER HEADLIGHT GOES OFF SPONTANEOUSLY WHILE DRIVING OR STATIONARY. WHEN YOU TURN OFF THE HEADLIGHT SWITCH, THEN TURN THEM ON, THE HEADLIGHT TURNS BACK ON FOR A WHILE. THEN AFTER A WHILE THE HEADLIGHT TURNS OFF AGAIN. THIS DEFECT WAS A NHTSA RECALL AND EXTENDED WARRANTY PROBLEM BUT THE DEALER SAID THE WARRANTY AND RECALL HAS EXPIRED. THEY WANT TO CHARGE ME OVER $500 TO FIX THIS DEFECT. NHTSA NEEDS TO EXTEND THE RECALL AND WARRANTY BECAUSE THERE HAVE BEEN ACCIDENT DEATHS AND INJURY RELATED TO THIS DEFECT. YOU CAN SEE THE DEFECT DOCUMENTED ON SEVERAL YOUTUBE VIDEOS: TOYOTA PRIUS HEADLIGHT FAILURE. PLEASE ISSUE AN ORDER FOR DEALERS TO RECALL AND EXTEND THE WARRANTY TO FIX THIS HEADLIGHT DEFECT AT NO COST TO OWNERS !! *TR
Official recalls
613V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606