← New search

2009 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2009 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

402 reports with mileage · 100 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

64 crash reports4 fire reports21 injury reports

Fuel System, Gasoline complaints

14 reports
Clear category filter
50,000 miles · Jan 25, 2013
Fuel System, Gasoline

I PULLED UP TO THE GAS PUMP AND COULD NOT PUT GAS IN MY CAR. IT HAD A LITTLE GAS IN IT, BUT THE PUMP CUT OFF BEFORE I COULD GET STARTED. THE CAR HAS HAD A PROBLEM WITH THE BLADDER SINCE ITS INCEPTION. I CAN NEVER FILL UP THE TANK. THE DEALER WANTS ME TO PAY AN ELABORATE AMOUNT TO GET IT FIXED. I WENT OUT ON THE INTERNE…

Read full complaint

I PULLED UP TO THE GAS PUMP AND COULD NOT PUT GAS IN MY CAR. IT HAD A LITTLE GAS IN IT, BUT THE PUMP CUT OFF BEFORE I COULD GET STARTED. THE CAR HAS HAD A PROBLEM WITH THE BLADDER SINCE ITS INCEPTION. I CAN NEVER FILL UP THE TANK. THE DEALER WANTS ME TO PAY AN ELABORATE AMOUNT TO GET IT FIXED. I WENT OUT ON THE INTERNET AND OTHER PEOPLE ARE HAVING THE SAME PROBLEM WITH NOT BEING ABLE TO FILL UP THEIR TANK. *TR

NHTSA ODI #10494704

43,000 miles · May 11, 2011
Electrical SystemFuel System, GasolinePower Train

TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED THAT THE FUEL GAUGE WOULD PROVIDE INACCURATE READINGS OF FUEL LEVELS. WHILE DRIVING 20 MPH, THE VEHICLE COMPLETELY SHUT DOWN WITHOUT WARNING DUE TO A BLADDER FUEL TANK PROBLEM. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE BLADDER FUEL TANK UNDER WARRANTY. THE M…

Read full complaint

TL* THE CONTACT OWNS A 2009 TOYOTA PRIUS. THE CONTACT STATED THAT THE FUEL GAUGE WOULD PROVIDE INACCURATE READINGS OF FUEL LEVELS. WHILE DRIVING 20 MPH, THE VEHICLE COMPLETELY SHUT DOWN WITHOUT WARNING DUE TO A BLADDER FUEL TANK PROBLEM. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE BLADDER FUEL TANK UNDER WARRANTY. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 43,000. THE CONSUMER STATED TOYOTA PAID FOR THE REPAIR. HOWEVER, THE GAS GAUGE CONTINUES TO BE INACCURATE AND THE CONSUMER IS UNABLE TO PUT NO MORE THAN SIX GALLONS OF GAS IN THE VEHICLE. ALSO, AT TIMES, THE VEHICLE WOULD NOT SHIFT INTO GEAR. UPDATED 06/30/11

NHTSA ODI #10400055

153 miles · Dec 10, 2010
Fuel System, GasolineFuel System, Other

2009 TOYOTA PRIUS, CAR HAS HAD A BAD FUEL GAUGE , DROVE OFF THE LOT NEW AND HAVE HAD FUEL TANK REPLACED ONCE. FUEL GAUGE FAILED AGAIN THIS IS THE SECOND TIME. DEALER UNABLE TO REPAIR, TOLD ME IT WAS A DESIGN FLAW AND IT COULD NOT BE REPAIRED, I AM RUNNING OUT OF GAS AND I CAN NOT USE THIS NEW CAR ON A LONG TRIP. I DO NOT KNOW AN…

Read full complaint

2009 TOYOTA PRIUS, CAR HAS HAD A BAD FUEL GAUGE , DROVE OFF THE LOT NEW AND HAVE HAD FUEL TANK REPLACED ONCE. FUEL GAUGE FAILED AGAIN THIS IS THE SECOND TIME. DEALER UNABLE TO REPAIR, TOLD ME IT WAS A DESIGN FLAW AND IT COULD NOT BE REPAIRED, I AM RUNNING OUT OF GAS AND I CAN NOT USE THIS NEW CAR ON A LONG TRIP. I DO NOT KNOW AND I AM GUESSING ON HOW MUCH FUEL I HAVE. THIS IS UNSAFE AND UNCALLED FOR. RUNNING OUT OF GLASS ON FREEWAY AND IT IS DANGEROUS. *TR

NHTSA ODI #10369953

18,500 miles · Jul 1, 2010
Fuel System, GasolinePower Train

WHILE DRIVING A 2009 TOYOTA PRIUS AT 50-55 MPH ON A SINGLE LANE HIGHWAY OUTSIDE OF PRESCOTT AZ, THE DRIVE SYSTEM SUDDENLY SHUT DOWN AND NO RESPONSE WAS FELT WHEN DEPRESSING THE ACCELERATOR PEDAL. LOTS OF INDICATORS CAME ON AND MY WIFE WAS ABLE TO STEER THE CAR TO THE SIDE OF THE ROAD WHERE THERE WAS JUST SUFFICIENT ROOM FOR FOLL…

Read full complaint

WHILE DRIVING A 2009 TOYOTA PRIUS AT 50-55 MPH ON A SINGLE LANE HIGHWAY OUTSIDE OF PRESCOTT AZ, THE DRIVE SYSTEM SUDDENLY SHUT DOWN AND NO RESPONSE WAS FELT WHEN DEPRESSING THE ACCELERATOR PEDAL. LOTS OF INDICATORS CAME ON AND MY WIFE WAS ABLE TO STEER THE CAR TO THE SIDE OF THE ROAD WHERE THERE WAS JUST SUFFICIENT ROOM FOR FOLLOWING TRAFFIC TO GO PAST. AFTER SPENDING A FEW MINUTES GOING THROUGH THE OWNER'S MANUAL AND FINDING NO EASY ANSWER TO EXPLAIN THIS CONDITION, WE TRIED AND WERE ABLE TO RE-START THE CAR. IT MUST BE NOTED THAT THE FUEL GAUGE WHEN RECENTLY CHECKED HAD INDICATED SLIGHTLY LESS THAN 1/4 FULL AND THAT WE WERE PROCEEDING UP HILL WHEN THE EVENT HAPPENED. NO ADD FUEL INDICATOR LIGHT NOR LOW FUEL ALARM HAD OCCURRED PRIOR TO THIS EVENT. WHEN THE CAR WAS RESTARTED IT WAS ON A MORE LEVEL BUT NOT FLAT SURFACE. WE PROCEEDED ON OUR TRAVEL WITH THE FLASHERS ON AND AT A SPEED NO HIGHER THAN 30-35 MPH. SOON THEREAFTER WE DID OBSERVE BOTH AN ADD FUEL INDICATOR LIGHT AND THEN A FLASHING LIGHT ON THE FUEL GAUGE ITSELF. WE STOPPED AT THE NEAREST GAS STATION AND ADDED FUEL. THE NEXT DAY WE TOOK THE CAR IN TO THE TOYOTA DEALER TO HAVE THEM LOOK AT THE FUEL GAUGE AND ELECTRONICALLY RECORDED HISTORY. THE REPORT SHOWED THAT THE CAR RESPONDED TO AN EMPTY FUEL TANK BY SHUTTING IF THE ENGINE AND THEN THE BATTERY DRIVE WHEN ITS CHARGE WENT TOO LOW (TO PROTECT THE BATTERY). WE WERE TOLD THE THIS CAR HAS A BLADDER TYPE FUEL STORAGE DEVICE AND THAT IT CAN ACT FUNNY WHEN IT GETS LOW. THE CAR WAS CHECKED OUT FINE AND RETURNED TO US WITH THE WORDS NO WISDOM TO NOT LET THE CAR GET TOO LOW ON FUEL. MY CONCERN IS THAT THE ENGINE AND DRIVE SYSTEMS SHUT DOWN UNDER HIGH SPEED DRIVING CONDITIONS WITHOUT ANY LOW FUEL WARNING INDICATORS BEING ACTIVATED. *TR

NHTSA ODI #10341031

36,000 miles · Mar 11, 2010
Fuel System, GasolineVehicle Speed ControlCrash

I JUST BOUGHT A 2009 PRIUS & THERE ARE SO MANY ISSUES WITH UNEXPECTED ACCELERATION & VEHICLE NOT GOING INTO PARK OR REVERSE JUST STOPS IN NEUTRAL, I WAS AT A HEB SORE TRYING TO PARK, ALL OF A SUDDEN MY CAR SPED UP AN HIT A POLE IN FRONT OF ME, I WAS TRYING TO PARK, WITH MY FOOT ON BREAK, SO AS TO SLOW DOWN, YESTERDAY I HAD MY WI…

Read full complaint

I JUST BOUGHT A 2009 PRIUS & THERE ARE SO MANY ISSUES WITH UNEXPECTED ACCELERATION & VEHICLE NOT GOING INTO PARK OR REVERSE JUST STOPS IN NEUTRAL, I WAS AT A HEB SORE TRYING TO PARK, ALL OF A SUDDEN MY CAR SPED UP AN HIT A POLE IN FRONT OF ME, I WAS TRYING TO PARK, WITH MY FOOT ON BREAK, SO AS TO SLOW DOWN, YESTERDAY I HAD MY WIFE DRIVE THE PRIUS & THE CAR SUDDENLY STOPPED WOULD NOT GO INTO REVERSE OR DRIVE, THAT WAS VERY DANGEROUS THEN THEY PULL INTO A TARGET PARKING LOT I HAD TO DRIVE OUT THERE TO MEET THEM, IT TOOK ALMOST 1HR & 3MINS TO GET THE CAR IN REVERSE, OFF COURSE I CALLED MY TOYOTA SALES GUY THIS BEING THE THIRD TIME I HAVE REPORTED THIS INCIDENT & THE KEEP DOWN PLAYING IT SAYING THERE IS NOTHING WRONG, NOT REALLY LOOKING INTO IT. *TR

NHTSA ODI #10318937

1,500 miles · Mar 4, 2010
Fuel System, Gasoline

COLLAPSE OF FUEL BLADDER CAUSE THE PRIUS TO RUN OUT OF FUEL WITH 2 GALLONS OF GAS IN THE VEHICLE WHILE ON FREEWAY. CAUSED TOWING TO DEALERSHIP. WHEN FUEL WAS ADDED TO CAR ONLY 8.9 GALLONS COULD BE ADDED TO A REPORTED 10.9 GALLON TANK CAPACITY. *TR

NHTSA ODI #10316839

9,000 miles · Jan 19, 2010
Fuel System, Gasoline

FUEL BLADDER SEEMS TO HAVE COLLAPSED. WHEN I AM SHOWING 1/4 TANK LEFT I CAN ONLY PUT 6 GALLONS IN THE TANK. *TR

NHTSA ODI #10300352

22,000 miles · Oct 27, 2009
Electrical SystemFuel System, Gasoline

I HAVE WRITTEN TOYOTA ON SEVERAL OCCASIONS AND THEY HAVE FAILED TO RESPOND. I OWN A 2009 PRIUS. FIRST,NAVIGATION SYSTEM IS VERY POOR AND SENDS YOU TO WRONG ADDRESSES. ON AUG 17,2009,THE FUEL GAUGE WAS AT ONE BAR AND A RED TRIANGLE CAME ON DASH AND CAR STARTED PULLING AND DRAGGING. I PULLED OFF OF THE ROAD ON THE SHOULDER AND TR…

Read full complaint

I HAVE WRITTEN TOYOTA ON SEVERAL OCCASIONS AND THEY HAVE FAILED TO RESPOND. I OWN A 2009 PRIUS. FIRST,NAVIGATION SYSTEM IS VERY POOR AND SENDS YOU TO WRONG ADDRESSES. ON AUG 17,2009,THE FUEL GAUGE WAS AT ONE BAR AND A RED TRIANGLE CAME ON DASH AND CAR STARTED PULLING AND DRAGGING. I PULLED OFF OF THE ROAD ON THE SHOULDER AND TRIED TO RESTART CAR. IT STARTED AGAIN AND THEN IT PULLED AND DRAGGED AND I GOT BACK ON THE SHOULDER. IT WOULD NOT MOVE.I TRIED TO PLACE THE VEHICLE IN NEUTRAL BUT IT WOULD ONLY STAY IN PARK. THIS CREATED A DANGEROUS PROBLEM ESPECIALLY NOT BEING ABLE TO MOVE THE CAR AND THEN THE TOW TRUCK HAD TO MAKE ARRANGEMENTS BECAUSE CAR WOULD NOT LEAVE PARK. AS I WAITED FOR 2 HOURS FOR THE TOW TRUCK,THE HAZARD WARNING LIGHTS I TURNED ON AND THEN THEY ONLY WOULD BLINK ON THE RIGHT SIDE OF THE VEHICLE. THIS IS VERY DANGEROUS SINCE IT WAS MY LEFT SIDE THAT WAS EXPOSED TO TRAFFIC. I WAS LATER TOLD THAT THE CAR RAN OUT OF GAS. THIS DOES NOT EXPLAIN THE NONFUNCTIONAL HAZARD LIGHT SYSTEM,THE VEHICLE BEING FROZEN IN PARK AND THE PULLING AND DRAGGING ON THE HIGHWAY. WAS THE GAS GAUGE MALFUNCTIONING? I HAVE WRITTEN TOYOTA MANY TIMES AND COMPLETED SURVEYS EXPLAINING THESE CONCERNS AND THEY FAIL TO ACKNOWLEDGE OR RESPOND. I THINK A SAFETY ISSUE IS RAISED. *TR

NHTSA ODI #10290015

Mileage unknown · Aug 27, 2009
Fuel System, Gasoline

I OWN A TOYOTA PRIUS. ON JUNE 22, THE FUEL GAUGE STARTED TO ACT UP. I TOOK IT TO THE DEALERSHIP AFTER HAVING MY CAR FOR ALMOST 2 WEEKS THEY CLAIMED IT WAS FIXED. THEY REPLACED ALMOST EVERYTHING TO DO WITH THE FUEL. I THEN TOOK IT BACK LESS THAN A MONTH LATER WITH THE SAME PROBLEM. THEY TOLD ME THERE WAS NOTHING THEY COULD DO AND…

Read full complaint

I OWN A TOYOTA PRIUS. ON JUNE 22, THE FUEL GAUGE STARTED TO ACT UP. I TOOK IT TO THE DEALERSHIP AFTER HAVING MY CAR FOR ALMOST 2 WEEKS THEY CLAIMED IT WAS FIXED. THEY REPLACED ALMOST EVERYTHING TO DO WITH THE FUEL. I THEN TOOK IT BACK LESS THAN A MONTH LATER WITH THE SAME PROBLEM. THEY TOLD ME THERE WAS NOTHING THEY COULD DO AND JUST TO NEVER LET MY TANK GO BELOW 1/4. TO ME, THIS IS A DANGER. I NEVER KNOW HOW MUCH GAS IS IN MY GAS TANK OR WHEN I MAY RUN OUT OF GAS. I THEN TOOK IT TO ANOTHER DEALERSHIP AND THEY EXPLAINED TO ME THIS IS A PROBLEM WITH THE PRIUS, YET TOYOTA DOES NOTHING TO FIX THIS. EVERY FEW DAYS I HAVE TO STOP AND GET GAS BECAUSE MY GAS GAUGE DOES NOT WORK PROPERLY. I AM DRIVING AROUND AN ACCIDENT WAITING TO HAPPEN. *TR

NHTSA ODI #10281973

320 miles · Aug 19, 2009
Fuel System, Gasoline

TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. DURING THE WINTER MONTHS, THE VEHICLE BECAME DIFFICULT TO ADD FUEL. THE DEALER HAS PROVIDED THE CONTACT WITH SEVERAL OPTIONS TO AVOID THIS PROBLEM WHICH INCLUDED TURNING THE NOZZLE SIDEWAYS AND TAKING THE NOZZLE OUT FROM TIME TO TIME WHILE ADDING FUEL. THE CONTACT FOUND THAT THESE TECHNI…

Read full complaint

TL*THE CONTACT OWNS A 2009 TOYOTA PRIUS. DURING THE WINTER MONTHS, THE VEHICLE BECAME DIFFICULT TO ADD FUEL. THE DEALER HAS PROVIDED THE CONTACT WITH SEVERAL OPTIONS TO AVOID THIS PROBLEM WHICH INCLUDED TURNING THE NOZZLE SIDEWAYS AND TAKING THE NOZZLE OUT FROM TIME TO TIME WHILE ADDING FUEL. THE CONTACT FOUND THAT THESE TECHNIQUES ARE DIFFICULT TO PERFORM. SHE ALSO STATED THAT THE SAFETY RISK IS HIGHER SINCE THE LIMITED AMOUNT OF GAS COULD CAUSE THE ENGINE TO SHUT OFF WITHOUT WARNING. THE CURRENT MILEAGE WAS 9000 AND THE FAILURE MILEAGE WAS 320. UPDATED 09/08/09 *BF UPDATED 09/29/09.*JB

NHTSA ODI #10281097

Official recalls

6

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Seats

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606