NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
248 reportsClear category filter81,670 miles · May 9, 2012
Electrical System
WHEN I STARTED MY PRIUS AND THE DASH LIGHTS DID NOT COME ON (FUEL GAUGE, MILEAGE, SPEEDOMETER ETC). I PUT THE CAR IN REVERSE AND THE BACKUP CAMERA PICTURE DID NOT APPEAR ON THE SCREEN. THE SCREEN WAS ON BUT CONTINUED TO SHOW THE CONSUMPTION SCREEN. I THEN PUT THE CAR IN PARK AND HIT THE POWER BUTTON AND THE CAR WOULD NOT TURN P…
Read full complaint
WHEN I STARTED MY PRIUS AND THE DASH LIGHTS DID NOT COME ON (FUEL GAUGE, MILEAGE, SPEEDOMETER ETC). I PUT THE CAR IN REVERSE AND THE BACKUP CAMERA PICTURE DID NOT APPEAR ON THE SCREEN. THE SCREEN WAS ON BUT CONTINUED TO SHOW THE CONSUMPTION SCREEN. I THEN PUT THE CAR IN PARK AND HIT THE POWER BUTTON AND THE CAR WOULD NOT TURN POWER OFF. I PUT THE CAR IN DRIVE THEN PARK AND REVERSE THEN PARK SEVERAL TIMES HITTING THE POWER BUTTON AFTER EACH TRY AND THE CAR EVENTUALLY POWERED OFF. I STARTED THE CAR AGAIN AND HEADED TO THE GOLF COURSE AND CALLED TOYOTA AND MADE AN APPOINTMENT FOR THE SAME DAY. THE NEXT TIME I GOT IN THE CAR (ABOUT 4 HOURS LATER) THE DASH LIGHTS CAME ON AND I DROVE HOME AND THE CAR POWERED OFF NORMALLY. I CANCELLED THE APPOINTMENT AT TOYOTA FOR NOW AND WILL SEE WHAT HAPPENS. THE SERVICE PERSON AT THE DEALERSHIP SAID THAT SHE HAD NOT HEARD OF THIS PROBLEM. *TR
NHTSA ODI #10457932
46,000 miles · Apr 29, 2012
Electrical SystemExterior Lighting
HEADLAMPS TURN OFF ON THEIR OWN INTERMITTENTLY. THE LEFT LIGHT WILL GO OFF MORE THAN THE RIGHT. I USUALLY CORRECT THE SITUATION BY TURNING OFF THE LIGHTS THEN BACK ON. THIS PROBLEM HAS INCREASED IN FREQUENCY. I READ IN AN ONLINE FORUM (PRIUSCHAT) THAT THIS IS A COMMON PROBLEM. *TR
NHTSA ODI #10456817
45,000 miles · Mar 24, 2012
Electrical SystemExterior Lighting
1. THE RIGHT-FRONT HEADLIGHT OFTEN GOES OUT AFTER THE CAR HAS BEEN DRIVEN FOR A WHILE. (FORTUNATELY, BOTH HEADLIGHTS DON'T HAVEN'T OUT YET!) THIS REALLY SHOULD BE CONSIDERED A SAFETY ISSUE - WHY ISN'T THERE A RECALL? 2. THE BACK-UP CAMERA OFTEN STOPS WORKING FOR A FEW DAYS AT A TIME. THIS IS A PROBLEM, GIVEN THE VERY POOR VIS…
Read full complaint
1. THE RIGHT-FRONT HEADLIGHT OFTEN GOES OUT AFTER THE CAR HAS BEEN DRIVEN FOR A WHILE. (FORTUNATELY, BOTH HEADLIGHTS DON'T HAVEN'T OUT YET!) THIS REALLY SHOULD BE CONSIDERED A SAFETY ISSUE - WHY ISN'T THERE A RECALL? 2. THE BACK-UP CAMERA OFTEN STOPS WORKING FOR A FEW DAYS AT A TIME. THIS IS A PROBLEM, GIVEN THE VERY POOR VISIBILITY THE MIRRORS HAVE BEHIND THIS CAR. *TR
NHTSA ODI #10452883
70,000 miles · Mar 10, 2012
Electrical SystemExterior Lighting
THE HEADLIGHTS KEEP GOING OUT. THIS HAPPENS AT ANY SPEED AND IN ANY CLIMATE. FLICKERING THEM OFF AND ON ALLEVIATES THE PROBLEM. BEEN HAPPENING FOR CLOSE TO 2 YEARS NOW. *TR
NHTSA ODI #10451052
Mileage unknown · Mar 6, 2012
Electrical SystemExterior Lighting
HID HEADLIGHT RANDOM FAILURE WHILE DRIVING PRIUS. UNRELIABLE TO DRIVE VEHICLE DURING THE NIGHT. *TR
NHTSA ODI #10450503
1,000 miles · Jan 3, 2012
Electrical SystemExterior LightingFuel System, Gasoline
THE MILEAGE IS BETWEEN 30 AND 35 MPG, WHICH IS A LONG WAYS FROM THE STICKER CLAIM. THE HEADLIGHT GOES ON AND OFF INTERMITTENTLY, EVEN THOUGH REPLACED SEVERAL TIMES. SECOND HEADLIGHT IS ALSO FAILING. THE BLOWER WORKS ONLY INTERMITTENTLY, USUALLY AFTER HITTING A LARGE BUMP IN THE ROAD. *TR
NHTSA ODI #10442173
135,980 miles · Dec 28, 2011
Electrical SystemExterior Lighting
APPROXIMATELY ONE WEEK AFTER HAVING MY BATTERY REPLACED BY A TOYOTA DEALERSHIP IN TEMECULA, CA THE DIGITAL DISPLAY ON MY DASHBOARD STOPPED WORKING AND NO LONGER DISPLAYED MY SPEED, GAS TANK GAUGE, TRIP MILEAGE OR TOTAL MILEAGE. AFTER ANOTHER WEEK OR SO PASSED, THE DISPLAY, OR CLUSTER DISPLAY, AS IT IS LISTED ON A TOYOTA REPAIR …
Read full complaint
APPROXIMATELY ONE WEEK AFTER HAVING MY BATTERY REPLACED BY A TOYOTA DEALERSHIP IN TEMECULA, CA THE DIGITAL DISPLAY ON MY DASHBOARD STOPPED WORKING AND NO LONGER DISPLAYED MY SPEED, GAS TANK GAUGE, TRIP MILEAGE OR TOTAL MILEAGE. AFTER ANOTHER WEEK OR SO PASSED, THE DISPLAY, OR CLUSTER DISPLAY, AS IT IS LISTED ON A TOYOTA REPAIR ESTIMATE FROM NOVEMBER 3, 2011, WOULD WORK INTERMITTENTLY BY AGAIN DISPLAYING MY SPEED, GAS TANK GAUGE, ETC. THE DISPLAY WOULD SOMETIMES WORK FOR A FEW HOURS AND THEN STOP WORKING, AND NOT WORK AGAIN FOR SEVERAL DAYS OR A WEEK OR MORE. CURRENTLY, IT THE DISPLAY CONTINUES TO WORK INTERMITTENTLY ONLY, CAUSING ME TO DRIVE FOR DAYS OR A WEEK OR MORE WITH NO VISUAL DISPLAY OF HOW FAST I AM DRIVING OR HOW MUCH GAS I HAVE REMAINING IN MY TANK. THIS FAILURE OF THE CLUSTER DISPLAY IS A HAZARD TO ME AND ESPECIALLY TO MY YOUNG TEENAGE DAUGHTER BECAUSE WE DO NOT KNOW FOR SURE HOW FAST WE ARE DRIVING OR HOW MUCH GAS WE HAVE REMAINING AT ANY GIVEN TIME WHEN THE DISPLAY STOPS WORKING. I HAD MY VEHICLE INSPECTED BY THE TOYOTA DEALERSHIP IN TEMECULA, CA AND THEY RECOMMENDED REPLACING THE COMBO METER SINCE THEY BELIEVE THERE IS AN OPEN CIRCUIT IN THE COMBO METER, BUT THEY COULD NOT GUARANTEE THAT THEIR RECOMMENDATION WOULD RESOLVE THE PROBLEM. THEY THEN ADVISED ME THAT A SERVICE BULLETIN WAS ISSUED FOR PROBLEMS WITH THE CLUSTER DISPLAY, BUT NO RECALL HAS BEEN ORDERED AND THEY COULD NOT COVER THE COST OF FIXING THE PROBLEM UNDER WARRANTY. I THEN CALLED TOYOTA CORPORATE OFFICES AT 800-331-4331AND SPOKE TO THE SERVICE DIRECTOR, WHO OFFERED ME A 40% DISCOUNT ON THE COST OF REPLACING THE COMBO METER ON A REIMBURSEMENT BASIS AND SAID IF A RECALL WAS ORDERED I WOULD GET A FULL REFUND. I BELIEVE THE PROBLEM ON MY TOYOTA PRIUS OF AN INTERMITTENTLY FUNCTIONING CLUSTER DISPLAY PRESENTS A SIGNIFICANT HAZARD FOR THE REASONS STATED ABOVE AND WARRANTS A RECALL.
NHTSA ODI #10441868
Mileage unknown · Dec 28, 2011
Electrical System
2007 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO A SERIOUS ELECTRICAL FAILURE *TGW THE CONSUMER HAD TO CALL AAA FOR EMERGENCY ROAD SIDE ASSISTANCE. WHEN THE CONSUMER WENT TO THE DEALER TO THE RETRIEVE THE VEHICLE, HE WAS HANDED A REPAIR CHARGE OF OVER $ 5,300. THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS INCORRECTLY JUMP S…
Read full complaint
2007 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO A SERIOUS ELECTRICAL FAILURE *TGW THE CONSUMER HAD TO CALL AAA FOR EMERGENCY ROAD SIDE ASSISTANCE. WHEN THE CONSUMER WENT TO THE DEALER TO THE RETRIEVE THE VEHICLE, HE WAS HANDED A REPAIR CHARGE OF OVER $ 5,300. THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS INCORRECTLY JUMP STARTING THE VEHICLE. ACCORDING TO THE DEALER, THE INCORRECT PROCEDURE IN ATTEMPTING TO JUMP START THE VEHICLE LEAD TO A MAIN FUSE FAILURE AND COMPLETE FAILURE OF THE INVERTER-CONVERTER.
NHTSA ODI #10441849
57,900 miles · Dec 12, 2011
Electrical SystemExterior LightingVisibility
NO ONE INJURED. MINOR PROBLEM, BUT TOYOTA REFUSES SUGGESTIONS "FOR LEGAL REASONS", SO I HAVE TO REPORT IT TO YOU, AND HOPE THAT YOU WILL RELAY TO TOYOTA. GOOD CAR, GOOD DASH LIGHTING SYSTEM, NICE RHEOSTAT TO DIM THE INSTRUMENT PANEL LIGHTS AT NIGHT, TO ASSIST IN NIGHT ROAD VISIBILITY. THE PROBLEM IS THAT AS YOU DIM THE INSTRUM…
Read full complaint
NO ONE INJURED. MINOR PROBLEM, BUT TOYOTA REFUSES SUGGESTIONS "FOR LEGAL REASONS", SO I HAVE TO REPORT IT TO YOU, AND HOPE THAT YOU WILL RELAY TO TOYOTA. GOOD CAR, GOOD DASH LIGHTING SYSTEM, NICE RHEOSTAT TO DIM THE INSTRUMENT PANEL LIGHTS AT NIGHT, TO ASSIST IN NIGHT ROAD VISIBILITY. THE PROBLEM IS THAT AS YOU DIM THE INSTRUMENT PANEL LIGHTS, THE LIGHTED SYMBOL FOR THE EMERGENCY FLASHER LIGHT SWITCH GOES COMPLETELY DARK BEFORE THE INSTRUMENT PANEL LIGHTS DO. SO, ON A DARK NIGHT, YOU DIM THE LIGHTS TO MAKE THE INSTRUMENT PANEL LIGHTS JUST BRIGHT ENOUGH TO READ, WITHOUT EXCESS REFLECTION OR DISTRACTION, AND THE EMERGENCY FLASHER SWITCH BECOMES INVISIBLE BECAUSE ITS LIGHT WENT COMPLETELY OUT BEFORE THE OTHER INSTRUMENT PANEL LIGHTS DID. THIS INCREASES DISTRACTION AND REDUCES REACTION TIME WHEN YOU NEED TO FIND AND TURN ON THE EMERGENCY FLASHER LIGHT SWITCH. I DOUBT THIS PROBLEM IS LIMITED TO JUST MY CAR. THE SIMPLE SOLUTION (EVERYTHING SEEMS SIMPLE TO THE GUY NOT DOING THE WORK) WOULD BE TO DESIGN AND WIRE THE DASH PANEL LIGHTS SO THAT THE EMERGENCY FLASHER SWITCH LIGHT STAYS A LITTLE BRIGHTER THAN ALL THE OTHER LIGHTS, AS THEY ALL DIM. THAT WAY, THE SWITCH YOU MIGHT MOST NEED IN A HURRY WILL BE VISIBLE, EVEN IF YOU HAVE DIMMED YOUR INSTRUMENT PANEL LIGHTS. QUICKER TURN-ON OF THE EMERGENCY FLASHER ALERTS FOLLOWING DRIVERS SOONER, INCREASING THEIR SAFETY, AND MINE. THANKS FOR WORKING TO KEEP US ALL SAFER ON THE ROAD, AND TO IMPROVE THE VEHICLES WE DRIVE. *TR
NHTSA ODI #10439668
67,000 miles · Nov 16, 2011
Electrical System
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACTED STATED THAT ON TWO SEPARATE OCCASIONS, THE LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 67,000 …
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACTED STATED THAT ON TWO SEPARATE OCCASIONS, THE LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE WAS 69,500.
NHTSA ODI #10436089
Official recalls
4Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE09019 · Headlight Failure
Opened Apr 17, 2009 · Closed Aug 27, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration