NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
84 reportsClear category filterMileage unknown · Dec 26, 2024
Electrical SystemVehicle Speed ControlWheels
The light up display for the odometer, fuel gauge, and speedometer does not always light up. When it is not lit, the cruise control and any warning and informative alarms/lights also do not work. This is a well-known issue among owners of these cars, related to the capacitors on the circuit board for the display being defective,…
Read full complaint
The light up display for the odometer, fuel gauge, and speedometer does not always light up. When it is not lit, the cruise control and any warning and informative alarms/lights also do not work. This is a well-known issue among owners of these cars, related to the capacitors on the circuit board for the display being defective, and there is extensive documentation of it online. It may also have had a technical service bulletin released for the issue, but I'm not entirely sure. The light goes out intermittently and is not always consistently out. I did mention it to the service personnel when I took it in to get recalls repaired recently, and they didn't seem surprised or unaware of the issue. I did not ask them to diagnose or fix it, as I know I can get it done for a better deal elsewhere.
NHTSA ODI #11632471
77,000 miles · Jul 17, 2024
SteeringVehicle Speed ControlCrashInjury
The contact owns a 2006 Toyota Prius. The contact stated that while driving approximately 35 MPH, the steering wheel erroneously steered to the left direction on its own. The contact used force to maneuver the vehicle however the steering wheel independently veered again to the left, right, left, and then back to the right. The …
Read full complaint
The contact owns a 2006 Toyota Prius. The contact stated that while driving approximately 35 MPH, the steering wheel erroneously steered to the left direction on its own. The contact used force to maneuver the vehicle however the steering wheel independently veered again to the left, right, left, and then back to the right. The vehicle crashed into a curb, and violently accelerated across 2 lanes of oncoming traffic where a van crashed into the vehicle head-on. The air bags deployed upon impact. The contact sustained 11 fractured bones (L1 through L5 lower lumbar, pelvic, pelvis, 11th rib, and sacrum) and received medical attention via trauma center where she remained for over 2 weeks. The other driver of the van sustained unknown injuries but did not receive any known medical attention. A police report was not on file for the incident. A dealer was not contacted. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 77,000.
NHTSA ODI #11602992
88,000 miles · Dec 19, 2017
Electrical SystemVehicle Speed Control
COMBINATION METER STOPPED WORKING IN COLD WEATHER. KNOW PROBLEM FOR TOYOTA AND A VERY DANGEROUS ONE. THEY DID ONE REPAIR AND WARRANTY EXTENSION BUT VEHICLES NOW HITTING HIGHER MILIAGE ARE HAVING ISSUES AND IT IS DOCUMENTED BY TOYOTA IN A WARRANTY BULLENTIN NO. POL12-05 FROM TOYOTA
NHTSA ODI #11055524
65 miles · Nov 21, 2017
Service BrakesVehicle Speed ControlCrashInjury
MY CAR (06 TOYOTA PRIUS) HAD HIT A POTHOLE WHILE ON MY WAY TO CHURCH ON 11/16/17. THERE WAS A LOT OF TRAFFIC AND THOUGH I WAS FAR BEHIND THE PERSON IN FRONT OF ME, MY BRAKE DID NOT STOP AND MY CAR WENT UNDER THE CAR IN FRONT OF ME. THE VEHICLE WAS GOING MAYBE 5-10 MPH AS WE INCHED UP TO THE LIGHT. LOTS OF TRAFFIC, I WAS DOUBLE …
Read full complaint
MY CAR (06 TOYOTA PRIUS) HAD HIT A POTHOLE WHILE ON MY WAY TO CHURCH ON 11/16/17. THERE WAS A LOT OF TRAFFIC AND THOUGH I WAS FAR BEHIND THE PERSON IN FRONT OF ME, MY BRAKE DID NOT STOP AND MY CAR WENT UNDER THE CAR IN FRONT OF ME. THE VEHICLE WAS GOING MAYBE 5-10 MPH AS WE INCHED UP TO THE LIGHT. LOTS OF TRAFFIC, I WAS DOUBLE AND TRIPLE CHECKING TO SEE MY FOOT ON THE BRAKE AND IT WAS BUT CAR WOULD NOT STOP, IN FACT IT FELT LIKE IT REVVED UP.IT WAS TERRIFYING AS I SAW MY CAR PLOW INTO ANOTHER WHEN THERE WAS NOTHING I COULD DO. I KNOW THE 2010 MODELS WERE RECALLED FOR THIS BUT IT HAPPENED TO ME ON MY 2006 PRIUS. NO RECALL BUT A WARRANT ENHANCEMENT NOTIFICATION WAS SENT TO MY RELATIVE WHO HAD A 2007 BUT I NEVER RECEIVED IT. IT IS ALL ABOUT THE BRAKES AND THE NOT STOPPING PROPERLY. TOYOTA ALSO DID A WEIRD BUY BACK THING AND WANTED MY CAR. I THINK IT IS BECAUSE THEY WANTED TO HIDE THE PROBLEM INSTEAD OF HAVING A RECALL. I HAVE NEVER HAD A COMPANY TRY TO BUY BACK MY CAR. TOYOTA IS AT FAULT AND I WANT TO MAKE SURE NO ONE ELSE IS KILLED OR HURT BY THIS. IT ALSO SHOWS UP IN THE TECHNICAL SERVICE BULLETIN BUT AGAIN, NOT A RECALL BUT IT NEEDS TO BE RECALLED! MY CAR HAD ABOUT 65K ON IT.
NHTSA ODI #11047769
Mileage unknown · Oct 3, 2017
Electrical SystemFuel/propulsion SystemVehicle Speed Control
WHEN VEHICLE IS STARTED NO DASH LIGHTS FOR FUEL GAGE, SPEEDOMETER, ODOMETER INOPERABLE DUE TO FAULTY COMBINATION METER. NO RECALL JUST EXTENDED WARRANTY THAT TOYOTA WILL NOT REPLACE.
NHTSA ODI #11031475
140,000 miles · Aug 26, 2017
Electrical SystemExterior LightingVehicle Speed Control
I BELIEVE ITS A GLITCH IN THE CAR'S COMPUTER. AT UNPREDICTABLE AND INTERMITTENT INTERVALS THE ELECTRONIC HEADS UP DISPLAY DOES NOT OPERATE. THIS LEAVES ME WITH NO SPEEDOMOETER, NO FUEL LEVEL INDICATOR, NO BRIGHT OR DIM INDICATOR FOR THE HEADLIGHTS, AND THE CRUISE CONTROL DOES NOT WORK. DURING THE INCIDENTS THE CAR ALSO MIGHT …
Read full complaint
I BELIEVE ITS A GLITCH IN THE CAR'S COMPUTER. AT UNPREDICTABLE AND INTERMITTENT INTERVALS THE ELECTRONIC HEADS UP DISPLAY DOES NOT OPERATE. THIS LEAVES ME WITH NO SPEEDOMOETER, NO FUEL LEVEL INDICATOR, NO BRIGHT OR DIM INDICATOR FOR THE HEADLIGHTS, AND THE CRUISE CONTROL DOES NOT WORK. DURING THE INCIDENTS THE CAR ALSO MIGHT NOT RESPOND TO THE POWER OFF BUTTON, SO IT KEEPS RUNNING. THIS PROBLEM MIGHT LAST FOR A DAY OR TWO AND THEN IT STARTS TO WORK AGAIN.
NHTSA ODI #11019826
85,000 miles · Mar 16, 2017
EngineVehicle Speed Control
THE COMPUTERIZED THROTTLE CONTROL ON THE PRIUS CAN GET YOU INTO TROUBLE. A PRIUS WILL NOT REVERSE UP A STEEP DRIVEWAY. NO MATTER HOW FAR YOU DEPRESS THE ACCELERATOR, THE ENGINE WILL NOT GO ABOVE ABOUT 1000 RPM, AND THE CAR WILL NOT MOVE. NOW, IF BASED ON SOUND OF THE ENGINE, YOU PLACE THE TRANSMISSION IN FORWARD WITHOUT FIRST…
Read full complaint
THE COMPUTERIZED THROTTLE CONTROL ON THE PRIUS CAN GET YOU INTO TROUBLE. A PRIUS WILL NOT REVERSE UP A STEEP DRIVEWAY. NO MATTER HOW FAR YOU DEPRESS THE ACCELERATOR, THE ENGINE WILL NOT GO ABOVE ABOUT 1000 RPM, AND THE CAR WILL NOT MOVE. NOW, IF BASED ON SOUND OF THE ENGINE, YOU PLACE THE TRANSMISSION IN FORWARD WITHOUT FIRST REMOVING FOOT FROM ACCELERATOR, THE CAR WILL ROCKET FORWARD (AND LIKELY CRASH). IT IS QUITE EASY TO DO THIS, AS THE ENGINE IS STUCK AT IDLE, THEN FURIOUSLY REVVING WITH NO CHANGE OF DRIVER INPUT. FATHER-IN-LAW, AND VARIOUS PEDESTRIANS, WERE MIRACULOUSLY UNINJURED, BUT A VERY NEAR THING INDEED.
NHTSA ODI #10966412
Mileage unknown · May 5, 2016
Service BrakesSteeringVehicle Speed ControlCrashInjury
I WAS IN A 2006 TOYOTA PRIUS CAR ACCIDENT ON THE FREEWAY WHEN THE STEERING WHEEL STARTED JERKING (TO THE POINT OF NO CONTROL), THE BRAKES STOPPED WORKING AND THE CAR KEPT ACCELERATING. CAR LOST CONTROL.*DT*JB CAR WAS TOTALED, TWO WITNESSES AND A POLICE REPORT. I WAS SENT THE EMERGENCY ROOM. NO RESPONSIBILITY WAS ASSUMED BY TO…
Read full complaint
I WAS IN A 2006 TOYOTA PRIUS CAR ACCIDENT ON THE FREEWAY WHEN THE STEERING WHEEL STARTED JERKING (TO THE POINT OF NO CONTROL), THE BRAKES STOPPED WORKING AND THE CAR KEPT ACCELERATING. CAR LOST CONTROL.*DT*JB CAR WAS TOTALED, TWO WITNESSES AND A POLICE REPORT. I WAS SENT THE EMERGENCY ROOM. NO RESPONSIBILITY WAS ASSUMED BY TOYOTA, WHICH COMPLETED THEIR "INSPECTION" ON MARCH 9TH, 2012. THEN EIGHT MONTHS LATER ON NOVEMBER 14, 2012 THEY COME OUT WITH TWO RECALLS: A STEERING RECALL & AN ENGINE AND ENGINE COOLING, HYBRID PROPULSION SYSTEM RECALL, PROBABLY AS PART OF WHAT THEY SAW HAPPENED TO ME. I WAS NEVER NOTIFIED AFTER ABOUT THESE RECALLS THAT MY CAR POTENTIALLY COULD'VE BEEN DEFECTIVE FROM AND PART OF.
NHTSA ODI #10863308
128,780 miles · Dec 12, 2015
Service BrakesVehicle Speed ControlCrash
WHILE DRIVING 20 M/H VEHICLE SUDDENLY ECCELERATED AND I HIT THE GUARD RAIL WHEN EXPERIENCING UNINTENDED ACCELERATITION
NHTSA ODI #10809851
103,000 miles · Sep 21, 2015
Fuel/propulsion SystemService BrakesVehicle Speed ControlCrashInjury
MY WIFE [XXX] HAD A SERIOUS ACCIDENT IN THE PARKING LOT OF THE VICTORIAN ON MAIN ST IN SANTA MONICA ON WEDNESDAY SEPTEMBER 2. FROM STANDSTILL, HER 2006 PRIUS SUDDENLY ACCELERATED TO A VERY HIGH RATE ON ITS OWN AND THE CAR'S BRAKES WERE COMPLETELY NON-RESPONSIVE. IN THIS RELATIVELY CONFINED PARKING AREA, AFTER A FRIGHTENING PERIO…
Read full complaint
MY WIFE [XXX] HAD A SERIOUS ACCIDENT IN THE PARKING LOT OF THE VICTORIAN ON MAIN ST IN SANTA MONICA ON WEDNESDAY SEPTEMBER 2. FROM STANDSTILL, HER 2006 PRIUS SUDDENLY ACCELERATED TO A VERY HIGH RATE ON ITS OWN AND THE CAR'S BRAKES WERE COMPLETELY NON-RESPONSIVE. IN THIS RELATIVELY CONFINED PARKING AREA, AFTER A FRIGHTENING PERIOD OF TRYING TO REGAIN CONTROL OF THE VEHICLE, SHE MADE A SPLIT-SECOND DECISION TO CRASH INTO A TREE AT A RELATIVELY HIGH SPEED IN ORDER TO AVOID STEERING THE CAR ONTO MAIN ST. AND CAUSING A MUCH MORE SERIOUS ACCIDENT THAT WOULD HAVE IMPACTED MANY PEOPLE, AUTOMOBILES AND PUBLIC AND PRIVATE PROPERTY AND POSSIBLY RESULTED IN MULTIPLE DEATHS AND MULTIPLE SERIOUS INJURIES. SHE SUSTAINED A BROKEN FOOT. HER PASSENGER SUSTAINED BRUISING. BOTH WERE TAKEN BY AMBULANCE TO ST. JOHN'S HOSPITAL. BOTH AIRBAGS DEPLOYED. THE 2 OCCUPANTS WERE WEARING SEAT BELTS. AS A RESULT, AND ONLY BECAUSE OF [XXX] QUICK THINKING AND POTENTIALLY SACRIFICIAL ACTION, [XXX], HER PASSENGER AND MANY OTHER NON-SUSPECTING PEOPLE ARE ALIVE TODAY. IT IS APPARENTLY WELL-ESTABLISHED THAT THE PRIUS CAN ACCELERATE IN THIS MANNER. IN THIS CASE, THE CIRCUMSTANCES WOULD APPEAR TO BE STRAIGHT FORWARD: A CAR PARKED IN A PARKING LOT AND STARTED SUDDENLY ACCELERATES ON IT'S OWN AND REFUSES TO ALLOW THE DRIVER CONTROL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10766471
Official recalls
6Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
May 31, 2006
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.
Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE09019 · Headlight Failure
Opened Apr 17, 2009 · Closed Aug 27, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration