← New search

2005 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2005 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

871 reports with mileage · 180 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

102 crash reports4 fire reports46 injury reports

Electrical System complaints

178 reports
Clear category filter
19,300 miles · May 22, 2009
Electrical SystemEngine And Engine CoolingFire

FIRE AND TOTAL LOSS OF 2005 TOYOTA PRIUS, 19,300 MILES AFTER RETURNING FROM WORK, THE VEHICLE WAS PARKED AS USUAL WITH ENGINE POWER CUT IN THE OWNER'S DRIVEWAY. A FEW MINUTES LATER, SMOKE WAS NOTICED INSIDE THE CAR WITH FLAMES SHOWING FROM UNDERNEATH THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE ABOUT 10 MINUTES AFTER …

Read full complaint

FIRE AND TOTAL LOSS OF 2005 TOYOTA PRIUS, 19,300 MILES AFTER RETURNING FROM WORK, THE VEHICLE WAS PARKED AS USUAL WITH ENGINE POWER CUT IN THE OWNER'S DRIVEWAY. A FEW MINUTES LATER, SMOKE WAS NOTICED INSIDE THE CAR WITH FLAMES SHOWING FROM UNDERNEATH THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE ABOUT 10 MINUTES AFTER IT WAS FIRST NOTICED. THE MAIN DAMAGE IS IN THE REAR LEFT (DRIVER'S SIDE) OF THE VEHICLE, WITH THE CARGO COMPARTMENT COMPLETELY DESTROYED, TIRE COMPLETELY MELTED, ALL PLASTIC IN THE AREA MELTED, DOOR BLACKENED, THE REAR BENCH DESTROYED, THE CEILING CARPET DESTROYED AND BIG HEAT MARKS ON THE ROOF OF THE CAR. THE VEHICLE WAS NOT MODIFIED AS A "PLUG-IN HYBRID" WHICH HAVE BEEN REPORTED IN AT LEAST ONE INCIDENT OF FIRE. THE EXTERNAL TEMPERATURE WAS MODERATE, AROUND 70-75 DEGREES. *TR UPDATED 06/05/09*JB

NHTSA ODI #10269762

62 miles · Apr 1, 2009
Electrical SystemService Brakes, HydraulicCrashInjury

ON 2/27/09, MY 2005 TOYOTA PRIUS' BRAKES COMPLETELY FAILED. I WAS GOING DOWNHILL IN AN HIGHLY TRANSITED URBAN ROAD (RTE 123 IN VA, CLOSE TO TYSONS CORNER). THANKFULLY I WAS ONLY GOING ABOUT 40MPH WHEN THE LIGHT CHANGED TO RED. THE 2 VEHICLES IN FRONT OF ME STOPPED. I PRESSED THE BRAKE PEDAL AND MY CAR ACCELERATED INITIALLY, AND …

Read full complaint

ON 2/27/09, MY 2005 TOYOTA PRIUS' BRAKES COMPLETELY FAILED. I WAS GOING DOWNHILL IN AN HIGHLY TRANSITED URBAN ROAD (RTE 123 IN VA, CLOSE TO TYSONS CORNER). THANKFULLY I WAS ONLY GOING ABOUT 40MPH WHEN THE LIGHT CHANGED TO RED. THE 2 VEHICLES IN FRONT OF ME STOPPED. I PRESSED THE BRAKE PEDAL AND MY CAR ACCELERATED INITIALLY, AND THEN NOTHING. BRAKES ARE MEANT TO WORK. ALWAYS. I KEPT PUMPING THE PEDAL HOPING TO ENGAGE THE BREAKS, BUT THEY DID NOT ENGAGE. WHAT STOPPED ME WAS THE REAR OF A BMW X5. THANKFULLY I WAS THE ONLY INJURED PARTY, AND MY INJURIES ARE MOSTLY MUSCULAR. I COULD HAVE DIED OR I COULD HAVE KILLED SOMEONE. IN JANUARY, I HAD TAKING MY CAR TO THE DEALER BECAUSE ALL THE ALERT LIGHTS ON THE DASH WOULD SPORADICALLY GO OFF. THEY KEPT THE CAR FOR A WEEK AND CLAIMED THAT THE SECONDARY BATTERY NEEDED TO BE REPLACED. I GOT MY VEHICLE BACK AND ON 2/23/09 THE ISSUE RESTARTED. I WAS DUE TO TAKE MY CAR BACK TO THE DEALER THE DAY OF THE ACCIDENT. I CALLED A LAWYER TO SEE IF I HAD A CASE, AND WAS TOLD NO. I AM STILL RESEARCHING THE ISSUE BECAUSE SOMEONE SHOULD BE HELD ACCOUNTABLE AND FUTURE TRAGEDIES SHOULD BE AVOIDED. IF ANYONE HAS STARTED A CLASS ACTION SUIT, PLEASE DO LET ME KNOW AS I WOULD LIKE TO JOIN YOU. *TR

NHTSA ODI #10263905

94,000 miles · Dec 30, 2008
Electrical SystemExterior Lighting

ON THREE SEPARATE OCCASIONS MY HEADLAMPS HAVE GONE OUT. EACH TIME IT HAS BEEN THE RIGHT OR LEFT SIDE. THE FOURTH TIME. THE LIGHTS CAME ON USING THE HI-BEAM ONLY. NUMEROUS INCIDENTS HAVE TAKEN PLACE. THIS IS THE SECOND TIME MY WIFE HAS BEEN PULLED OVER FOR THIS. I HAVE REPLACED THESE MYSELF. HOWEVER, THIS LAST TIME IT IS NOT THE…

Read full complaint

ON THREE SEPARATE OCCASIONS MY HEADLAMPS HAVE GONE OUT. EACH TIME IT HAS BEEN THE RIGHT OR LEFT SIDE. THE FOURTH TIME. THE LIGHTS CAME ON USING THE HI-BEAM ONLY. NUMEROUS INCIDENTS HAVE TAKEN PLACE. THIS IS THE SECOND TIME MY WIFE HAS BEEN PULLED OVER FOR THIS. I HAVE REPLACED THESE MYSELF. HOWEVER, THIS LAST TIME IT IS NOT THE BULB. IT IS THE ELECTRICAL SYSTEM. ACCORDING TO THE FORUM. COSTS HAVE BEEN FROM $300 - 2K. SOME DEALERSHIPS ASSUME SOME RESPONSIBILITY AND OTHERS DON'T. THIS IS A SAFETY AND EXPENSE ISSUE. DRIVING HOME IS VERY DIFFICULT AT NIGHT AND USING THE HI-BEAM IS BLINDING TO ON COMING TRAFFIC AND AGAINST THE LAW IN MOST CIRCUMSTANCES. *TR

NHTSA ODI #10253301

120,000 miles · Dec 2, 2008
Electrical SystemExterior Lighting

LEFT HEADLIGHT KEEPS GOING OUT IN PRIUS. TURN OFF THEN BACK ON TO RESET BOTH HEADLIGHTS WENT OUT ONE NIGHT AND ALMOST CAUSED A WRECK IT RESET ONCE I TURNED IT OFF AND BACK ON. *TR

NHTSA ODI #10250535

13,000 miles · Oct 7, 2008
Electrical System

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. FOR THE PAST TWO YEARS, THE VEHICLE HAS EMITTED AN ODOR INSIDE THE PASSENGER COMPARTMENT, WHICH STICKS TO THE CONTACT'S CLOTHING AND HAIR. THE ODOR HAS BEEN RECOGNIZED BY TOYOTA AS AN ODOR THAT ORIGINATES FROM THE REAR BATTERY WHICH IS FOUND UNDER THE BACK SEAT. THE ODOR IS TRIGGERED B…

Read full complaint

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. FOR THE PAST TWO YEARS, THE VEHICLE HAS EMITTED AN ODOR INSIDE THE PASSENGER COMPARTMENT, WHICH STICKS TO THE CONTACT'S CLOTHING AND HAIR. THE ODOR HAS BEEN RECOGNIZED BY TOYOTA AS AN ODOR THAT ORIGINATES FROM THE REAR BATTERY WHICH IS FOUND UNDER THE BACK SEAT. THE ODOR IS TRIGGERED BY EXTREME HEAT AND WHILE PULLING HEAVY LOADS. THE CONTACT LIVES IN ARIZONA SO THE VEHICLE IS SUBJECTED TO EXTREME HEAT. TOYOTA STATED THAT THE ODOR WAS NON-TOXIC AND THAT THERE WAS NO CURRENT REMEDY FOR THE DEFECT. THE CONTACT BELIEVES THAT THE CHEMICAL MAY BE TOXIC AND FEELS UNCOMFORTABLE DRIVING THE VEHICLE. THE FAILURE MILEAGE WAS 13,000 AND CURRENT MILEAGE WAS 45,000.

NHTSA ODI #10244631

80,000 miles · Jul 24, 2008
Electrical System

I OWN A 2005 TOYOTA PRIUS. I PURCHASED IT IN MARCH 2005. LAST WEEK, MY MULTIFUNCTIONAL DISPLAY (MFD) CEASED TO OPERATE CORRECTLY. THE MFD INITIALIZED TO THE MPG SCREEN BUT HAD UNUSUAL COLORS. I ATTEMPTED TO CHANGE THE DISPLAY SCREEN BY SELECTING THE AUDIO, CLIMATE, DISPLAY, AND INFO BUTTONS BUT TO NO AVAIL. THE SCREEN WOULD…

Read full complaint

I OWN A 2005 TOYOTA PRIUS. I PURCHASED IT IN MARCH 2005. LAST WEEK, MY MULTIFUNCTIONAL DISPLAY (MFD) CEASED TO OPERATE CORRECTLY. THE MFD INITIALIZED TO THE MPG SCREEN BUT HAD UNUSUAL COLORS. I ATTEMPTED TO CHANGE THE DISPLAY SCREEN BY SELECTING THE AUDIO, CLIMATE, DISPLAY, AND INFO BUTTONS BUT TO NO AVAIL. THE SCREEN WOULD GO BLANK AND THEN SHOW THE ?PRIUS HYBRID? INITIALIZING SCREEN AND THEN RETURN TO THE MPG SCREEN. AS I WAS NEARING MY 80K SERVICE, I CONTACTED MY DEALER AND REPORTED THE PROBLEM. THEY DIAGNOSED THE MFD AS BEING UNSERVICEABLE THAT NEXT SATURDAY. THE SERVICE REPRESENTATIVE MADE THE COMMENT THAT IT WAS COMMON FOR THE MFD TO GO BAD. TO REPLACE THE MFD WITH A NEW ONE, IT IS $4,000.00 PLUS INSTALLATION. THAT IS 19% OF THE COST OF THE VEHICLE WHEN IT WAS BRAND NEW! I BEGAN RESEARCHING AND FOUND THAT TOYOTA HAD ISSUED A TECHNICAL SERVICE BULLETIN ON 10 JANUARY 2005 TITLE: MULTI-DISPLAY FUNCTIONS ARE INOPERATIVE; TSB# EL002-05 WHICH IDENTIFIED ISSUES WITH THE MFD. ALSO IN BROWSING THE WEB SPECIFICALLY WWW.PRIUSCHAT.COM AND HTTP://AUTOS.GROUPS.YAHOO.COM/GROUP/PRIUS-2G/ AND SAW THAT I WAS NOT THE ONLY ONE WITH THIS PROBLEM. ONE ELECTRONICALLY GIFTED PERSON DISASSEMBLED HIS MFD AND DIAGNOSED THE PROBLEM AS IMPROPER SOLDERING ON THE CIRCUIT CARD (SEE HTTP://TECHNO-FANDOM.ORG/~HOBBIT/CARS/MFD/COMPARE.HTML ). IT SEEMS THAT TOYOTA CORPORATION WAS AWARE OF THE PROBLEM AND WERE NOT DISCLOSING IT HOPING THAT THE FAULTY MFD?S WOULD NOT BE DISCOVERED UNTIL THE VEHICLES EXCEEDED THE 3 YEAR 36,000 WARRANTY. I KNOW I AM OUTSIDE THE MILEAGE WARRANTY, HOWEVER, I AM JUST PASSED THE 3 YEAR WINDOW. I PURCHASED AND USE MY CAR AS A COMMUTER VEHICLE DRIVING ALMOST 100 MILES PER DAY. AS A MAINTENANCE OFFICER IN THE US ARMY, I KNOW THERE ARE COMPONENTS THAT ARE MILEAGE DEPENDENT (ENGINES, TRANSMISSIONS, DIFFERENTIALS) BUT THIS IS NOT ONE OF THEM. ELECTRICAL COMPONENTS ARE BUILT TO LAST THE MAJORITY OF VEHICLES LIFE, NOT JUST UNTIL THE WARRANTY EXPIRES. *TR

NHTSA ODI #10235664

33,000 miles · Jun 7, 2008
Electrical System

FIVE NO STARTING CONCERNS AFTER TWO YEARS OF OWNERSHIP. *TR

NHTSA ODI #10230229

58,203 miles · Feb 28, 2008
Electrical System

2005 TOYOTA PRIUS RIGHT HID HEADLAMP FLICKERS AND SOMETIMES TURNS OFF WHILE DRIVING. DEALER WILL NOT COVER EXTENSIVE REPAIR COST. FROM INTERNET INFORMATION THIS SEEMS TO BE A VERY COMMON PROBLEM THAT COULD BE VERY DANGEROUS IF BOTH HEADLIGHTS QUIT SIMULTANEOUSLY. *TR

NHTSA ODI #10219579

55,000 miles · Nov 30, 2007
Electrical SystemTires

WE HAVE TWO 2005 TOYOTA PRIUSES WHICH HAVE EXHIBITED IDENTICAL STALLING AND SHIFTING PROBLEMS. THE HYBRID SYSTEM WILL STALL OR NOT OPERATE AND WILL NOT ALLOW US TO SHIFT THE VEHICLE INTO GEAR PERIODICALLY. ONE TOYOTA DEALER SAYS WE NEED TO REPLACE THE TRANSAXLE, AND ANOTHER WAS NOT SURE AND SAID THERE BEST "GUESS" WAS TO REFRESH…

Read full complaint

WE HAVE TWO 2005 TOYOTA PRIUSES WHICH HAVE EXHIBITED IDENTICAL STALLING AND SHIFTING PROBLEMS. THE HYBRID SYSTEM WILL STALL OR NOT OPERATE AND WILL NOT ALLOW US TO SHIFT THE VEHICLE INTO GEAR PERIODICALLY. ONE TOYOTA DEALER SAYS WE NEED TO REPLACE THE TRANSAXLE, AND ANOTHER WAS NOT SURE AND SAID THERE BEST "GUESS" WAS TO REFRESH THE ECU AND HYBRID CONTROL MODULE SOFTWARE , HOWEVER AFTER DOING EXTENSIVE RESEARCH ONLINE BELIEVE IT TO BE A COMBINATION OF A SOFTWARE GLITCH ATTRIBUTED TO A LEAK IN WATERPROOFING A GASKET NEAR AN ECU. THE PROBLEM WAS BROUGHT TO THE DEALERS ATTENTION ALMOST A YEAR AGO WHILE THE VEHICLES WERE STILL UNDER WARRANTY. ALL THEY DID WAS SIMPLY "FLASH" OR REFRESH THE MEMORY AND DID NOT ACTUALLY RESOLVE THE PROBLEM. THE PRIUS' HYBRID-RELATED COMPONENTS, INCLUDING THE HYBRID CONTROL MODULE ARE COVERED FOR 8 YEARS/100,000 MILES. WE ALSO MENTIONED TO THE DEALER THE UNUSUAL AND EXCESSIVE TIRE WEAR ON BOTH VEHICLES, SOME OF THE TIRES HAD NO TREAD AND WERE ALREADY BALD AFTER ONLY 12,000 MILES. I AM WONDERING IF THIS COULD BE RELATED TO THE STEERING OR TRACTION CONTROL ISSUES PREVALENT WITH THIS MODEL. *TR

NHTSA ODI #10210426

40,000 miles · Oct 30, 2007
Electrical SystemExterior Lighting

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE BEING SERVICED AT THE DEALER, THEY NOTICED THAT THE HEADLIGHTS WERE DISTORTED. THE PLATING ON THE INTERNAL PART OF THE HEADLIGHTS WERE OVERHEATING. THERE IS NO WAY TO RELEASE THIS HEAT AND THE CONTACT IS CONCERNED THAT A POSSIBLE FIRE MAY OCCUR. THE VEHICLE WAS TAKEN TO THE DEAL…

Read full complaint

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE BEING SERVICED AT THE DEALER, THEY NOTICED THAT THE HEADLIGHTS WERE DISTORTED. THE PLATING ON THE INTERNAL PART OF THE HEADLIGHTS WERE OVERHEATING. THERE IS NO WAY TO RELEASE THIS HEAT AND THE CONTACT IS CONCERNED THAT A POSSIBLE FIRE MAY OCCUR. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY DID NOT WANT TO BE RESPONSIBLE BECAUSE IT WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 41,000. UPDATED 01-14-08. *KB UPDATED 12/12/07. *JB

NHTSA ODI #10207429

Official recalls

6

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

06V188000 · Steering:electric Power Assist System

May 31, 2006

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Consequence & remedy

Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

06V096000 · Air Bags

Apr 3, 2006

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Consequence & remedy

Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

PE05029 · Engine Stalling

Opened May 31, 2005 · Closed Oct 12, 2005

Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Additional source detail variants (3)

Engine And Engine Cooling:engine

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Engine And Engine Cooling

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.