NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
39 reportsClear category filterMileage unknown · Aug 27, 2023
Unknown Or Other
At about 3500 miles the car has started lagging really bad. I have almost been hit in stop and go traffic and have almost hit the car in front of me because I never know if when I put my foot on the gas if I’m going to go or not. When pulling out into on coming traffic I have to make sure the cars are really far away because aga…
Read full complaint
At about 3500 miles the car has started lagging really bad. I have almost been hit in stop and go traffic and have almost hit the car in front of me because I never know if when I put my foot on the gas if I’m going to go or not. When pulling out into on coming traffic I have to make sure the cars are really far away because again I never know if the car is going to actually get up and go. It lags, shakes like of it has no power. Once you get going it ok but to actually get going it’s awful. I’m really nervous the almost getting hit or hitting someone is actually going to happen because you have to floor it to get it to actually go and randomly sometimes it actually does get power that when it does take off it’s to much. There is no smooth to this car. Dealership says nothing wrong.
NHTSA ODI #11541007
Mileage unknown · Aug 26, 2023
Unknown Or Other
I purchased a 2023 Toyota Highlander 2.5 turbo in June of 2023. This car was bought for my wife so I had not noticed a operation issue until I had a opportunity to drive it, at about 1,500 miles on the odometer. Upon accelerating from a stop, the car slightly hesitates then surges followed by slight bucking. My wife acknowledged…
Read full complaint
I purchased a 2023 Toyota Highlander 2.5 turbo in June of 2023. This car was bought for my wife so I had not noticed a operation issue until I had a opportunity to drive it, at about 1,500 miles on the odometer. Upon accelerating from a stop, the car slightly hesitates then surges followed by slight bucking. My wife acknowledged the issue when I mentioned it. I have to state that the problem does not exist from every acceleration from a stop. I took the car to the dealer where I bought the car to investigate the issue. They said the mechanic did not experience the issue. I've read of many like minded comments from owners on toyotanation.com. I do believe this issue if not resolved may eventually lead to a accident.
NHTSA ODI #11540863
Mileage unknown · Aug 25, 2023
Fuel/propulsion SystemPower TrainUnknown Or Other
There is a significant hesitation / stuttering when the gas pedal is pressed (i.e. the vehicle doesn't move properly when the gas pedal is pressed). This is especially dangerous when pulling out into traffic, making turns, etc. This appears to be a known problem with this model and Toyota is working on a TSB (supposedly). Doing …
Read full complaint
There is a significant hesitation / stuttering when the gas pedal is pressed (i.e. the vehicle doesn't move properly when the gas pedal is pressed). This is especially dangerous when pulling out into traffic, making turns, etc. This appears to be a known problem with this model and Toyota is working on a TSB (supposedly). Doing a Google search for this problem shows that a number of consumers are having a similar issue. A few people have documented the issue here: https://www.toyotanation.com/threads/2023-highlander-2-4-turbo-surging-and-bucking-under-acceleration.1751952/ This is an ongoing problem. It hasn't resulted in an accident yet, but the lag / stutter in accelerating is putting consumers at risk. I just picked one random date below, but it has been ongoing since the vehicle was purchased new and appears to be happening to numerous other people as well as is evidenced by an internet search.
NHTSA ODI #11540745
Mileage unknown · Aug 25, 2023
Unknown Or Other
My 2023 highlander limited hesitates and lags when pulling out into the roads and highways! I almost have gotten hit several times. It has so called been inspected three times and they all tell me it doesn’t show on our computer so it’s fine ! No messages or warnings ever come up. This is so very dangerous and I could be killed…
Read full complaint
My 2023 highlander limited hesitates and lags when pulling out into the roads and highways! I almost have gotten hit several times. It has so called been inspected three times and they all tell me it doesn’t show on our computer so it’s fine ! No messages or warnings ever come up. This is so very dangerous and I could be killed along with others
NHTSA ODI #11540678
Mileage unknown · Jul 24, 2023
EnginePower TrainUnknown Or Other
The vehicle hesitates when accelerating from a stop. Dealership Technician says he noticed the hesitation when accelerating, but since there are no DTC’s and No Data found saying that there is a malfunction
NHTSA ODI #11534090
Mileage unknown · Jul 13, 2023
Unknown Or Other
While driving from Detroit to Chicago I was in a single lane traffic due to construction. I started getting message "Engine coolant temperature high, pull over when safe to do and contact dealer". The coolant temperature needle will jump to high then go back to normal. I stopped 5 different times before I could get the car to th…
Read full complaint
While driving from Detroit to Chicago I was in a single lane traffic due to construction. I started getting message "Engine coolant temperature high, pull over when safe to do and contact dealer". The coolant temperature needle will jump to high then go back to normal. I stopped 5 different times before I could get the car to the dealer. Only once during this ordeal the gage temperature stayed at high for couple of minutes. The Toyota dealer ran all the tests and couldn't find anything wrong other than the coolant level was a little below full. The outside temperature was 90 degrees Fahrenheit, Air conditioning was on high and speed was between 40 and 60 MPH. This Hybrid car had just gone past the 5000 miles mark when this started happening.
NHTSA ODI #11531965
Mileage unknown · May 19, 2023
Unknown Or Other
I bought toyota 2023 highlander in january. But I found water damage on roof of interior. so I went to dealership service center ( Midland toyota ). and they told to me . sun roof glass angle had wrong angle. and fixed it. ater 3 monthes same problem was appeared in this morning. so I went to Jim hudson toyota to fix it. but Jim…
Read full complaint
I bought toyota 2023 highlander in january. But I found water damage on roof of interior. so I went to dealership service center ( Midland toyota ). and they told to me . sun roof glass angle had wrong angle. and fixed it. ater 3 monthes same problem was appeared in this morning. so I went to Jim hudson toyota to fix it. but Jim hudson toyota PIC told to me. reason is that I parked my car angled location. I asked to him again Is that reason? he told to me. yes !!! you should go. I don't believe this. I think that toyota must explain that toyota car can't be parked on angled location
NHTSA ODI #11522920
Mileage unknown · Apr 18, 2023
Unknown Or Other
This car when I’m driving it has a loud wind noise I went to dealer couple time but they told me that they can’t hear any noise but I have evidence and video about the noise when I’m driving 45 mph. It is still loud noise.
NHTSA ODI #11517605
Mileage unknown · Feb 14, 2023
Service BrakesUnknown Or Other
The vehicle brakes stop working suddenly requiring lift the pedal and slam the brakes to make it work correctly. I almost have a bad accident for this problem. I did my research and learned this is a problem that Toyota need to fix. The situation was very scary.
NHTSA ODI #11507296
Official recalls
9Mar 5, 2026
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Highlander and Highlander Hybrid vehicles. The second-row seat backs may fail to lock into position during seat back adjustment.
Consequence & remedy
Consequence: A seat back that fails to lock may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will replace the return springs in the seat back recliner assemblies, free of charge. Owner letters were mailed September 9, 2026. This is a phased recall. Owners may contact Toyota’s customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB06 and 26TA06.
Oct 30, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Jan 29, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Jul 23, 2024
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
Jun 18, 2024
Southeast Toyota Distributors, LLC (SET) is recalling certain 2021-2024 Highlander vehicles. The 20-inch accessory tires with an insufficient load rating for the vehicle's Gross Axle Weight Rating (GAWR) were installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Tires with an insufficient load rating can be overloaded and fail, increasing the risk of a crash.
Remedy: SET will inspect and replace the tires and information placard, as necessary free of charge. Owner notification letters were mailed August 16, 2024. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET24A.
Jun 6, 2024
Gulf States Toyota, Inc. (GST) is recalling certain 2022-2024 model year Highlander L and Highlander LE vehicles equipped with the Blackout Package that includes 20" black alloy wheels and tires. The installed tires have an insufficient load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Tires with an insufficient load rating may be overloaded and fail, increasing the risk of a crash.
Remedy: GST will inspect and replace the tires as necessary, and install a new tire information label as necessary, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R1.
Oct 26, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2023 Highlander & Highlander Hybrid vehicles. During normal vehicle operation, minor impact to the front lower bumper cover may result in the cover coming loose or detaching.
Consequence & remedy
Consequence: A detached front bumper cover can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair or replace the upper and lower front bumper covers as necessary, free of charge. Owner letters were mailed April 22, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB12/23TA12.
Jul 12, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration