NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
16 reportsClear category filterMileage unknown · Nov 2, 2023
EngineFuel/propulsion SystemLane Departure
Engine intermittently has no power on take off and causes an unsafe condition to turning into traffic where car will just not go until after flooring it and a 3-5 second delay!! Engine also looses power and bucks or misses while accelerating through gears. This has caused multiple near miss incidents when turning into or across …
Read full complaint
Engine intermittently has no power on take off and causes an unsafe condition to turning into traffic where car will just not go until after flooring it and a 3-5 second delay!! Engine also looses power and bucks or misses while accelerating through gears. This has caused multiple near miss incidents when turning into or across traffic. Also have issues with the steering assist that it yanks the wheel intermittantly. This cause me to loose control on the wet interstate in a turn when it yanked the wheel to the right while banking left at 65mph. I panicked and pulled the wheel back which cause a skid. The system has been turned off since. Toyota is not doing anything to repair anything and keep giving me the car back saying its fine.
NHTSA ODI #11553206
Mileage unknown · Sep 21, 2023
EngineFuel/propulsion System
I've had the car for 6 months. After a few months we noticed a "bucking" during acceleration and a "hesitation" when pressing the accelerator. Under medium to hard acceleration the car will exhibit these traits almost consistantly and now after 3500 miles it has become so noticeable that it is dangerous! The hesitation is "o…
Read full complaint
I've had the car for 6 months. After a few months we noticed a "bucking" during acceleration and a "hesitation" when pressing the accelerator. Under medium to hard acceleration the car will exhibit these traits almost consistantly and now after 3500 miles it has become so noticeable that it is dangerous! The hesitation is "off the line" from a dead stop. There is at least a couple second delay sometimes when leaving a stop. And then as the car climbs in RPM's you can feel the engine struggling almost like a car with bad spark plug wires. It tends to "spit and buck" as it is accelerating. We have tried different fuels, fuel cleaners, different octanes, and nothing seems to curb the problem. We took the car to our local dealer and they confirm the problem but have stated that there is nothing they can do as it appears to be a software issue with the car. I have requested from Toyota using their "Brand engagement center" to provide an engineer to evaluate the car and so far have not heard back from them in almost a week.
NHTSA ODI #11545936
Mileage unknown · Sep 6, 2023
EngineFuel/propulsion SystemPower Train
Upon acceleration, car hesitates then surges. Started after approximately 2000 miles. Occurs most frequently from a dead start. However, continues upon acceleration up to 50 mph. Took to Toyota Dealer, but they were unable to diagnose. Others report similar problems on Toyota Nation Form. Concerned about pulling out into traffic…
Read full complaint
Upon acceleration, car hesitates then surges. Started after approximately 2000 miles. Occurs most frequently from a dead start. However, continues upon acceleration up to 50 mph. Took to Toyota Dealer, but they were unable to diagnose. Others report similar problems on Toyota Nation Form. Concerned about pulling out into traffic safely
NHTSA ODI #11542958
Mileage unknown · Aug 25, 2023
Fuel/propulsion SystemPower TrainUnknown Or Other
There is a significant hesitation / stuttering when the gas pedal is pressed (i.e. the vehicle doesn't move properly when the gas pedal is pressed). This is especially dangerous when pulling out into traffic, making turns, etc. This appears to be a known problem with this model and Toyota is working on a TSB (supposedly). Doing …
Read full complaint
There is a significant hesitation / stuttering when the gas pedal is pressed (i.e. the vehicle doesn't move properly when the gas pedal is pressed). This is especially dangerous when pulling out into traffic, making turns, etc. This appears to be a known problem with this model and Toyota is working on a TSB (supposedly). Doing a Google search for this problem shows that a number of consumers are having a similar issue. A few people have documented the issue here: https://www.toyotanation.com/threads/2023-highlander-2-4-turbo-surging-and-bucking-under-acceleration.1751952/ This is an ongoing problem. It hasn't resulted in an accident yet, but the lag / stutter in accelerating is putting consumers at risk. I just picked one random date below, but it has been ongoing since the vehicle was purchased new and appears to be happening to numerous other people as well as is evidenced by an internet search.
NHTSA ODI #11540745
Mileage unknown · Jul 30, 2023
EngineFuel/propulsion SystemPower Train
2023 Toyota Highlander XLE with 2.4 Turbo hesitates for an unacceptable period of time when accelerating from a stop. This could pose a huge safety risk when merging into traffic from a stop sign. The lag / hesitation is present on all eco / normal / sport drive modes. The issue has been occurring since the vehicle was purcha…
Read full complaint
2023 Toyota Highlander XLE with 2.4 Turbo hesitates for an unacceptable period of time when accelerating from a stop. This could pose a huge safety risk when merging into traffic from a stop sign. The lag / hesitation is present on all eco / normal / sport drive modes. The issue has been occurring since the vehicle was purchased at 70 miles and currently has about 5200 miles. Toyota needs to look into this issue and address it as soon as possible.
NHTSA ODI #11535351
Mileage unknown · Jul 27, 2023
Electrical SystemEngineFuel/propulsion System
Vehicle unpredictably hesitates during light to moderate acceleration in all driving modes (Sport, Normal, and Eco). This is especially dangerous when crossing in front of oncoming traffic from a stop or slow speed. Had a certified mechanic drive the car and verify the problem, but the car's systems don't report that there is a …
Read full complaint
Vehicle unpredictably hesitates during light to moderate acceleration in all driving modes (Sport, Normal, and Eco). This is especially dangerous when crossing in front of oncoming traffic from a stop or slow speed. Had a certified mechanic drive the car and verify the problem, but the car's systems don't report that there is a problem, so he had no answers.
NHTSA ODI #11534843
Official recalls
9Mar 5, 2026
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Highlander and Highlander Hybrid vehicles. The second-row seat backs may fail to lock into position during seat back adjustment.
Consequence & remedy
Consequence: A seat back that fails to lock may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will replace the return springs in the seat back recliner assemblies, free of charge. Owner letters were mailed September 9, 2026. This is a phased recall. Owners may contact Toyota’s customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB06 and 26TA06.
Oct 30, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Jan 29, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Jul 23, 2024
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
Jun 18, 2024
Southeast Toyota Distributors, LLC (SET) is recalling certain 2021-2024 Highlander vehicles. The 20-inch accessory tires with an insufficient load rating for the vehicle's Gross Axle Weight Rating (GAWR) were installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Tires with an insufficient load rating can be overloaded and fail, increasing the risk of a crash.
Remedy: SET will inspect and replace the tires and information placard, as necessary free of charge. Owner notification letters were mailed August 16, 2024. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET24A.
Jun 6, 2024
Gulf States Toyota, Inc. (GST) is recalling certain 2022-2024 model year Highlander L and Highlander LE vehicles equipped with the Blackout Package that includes 20" black alloy wheels and tires. The installed tires have an insufficient load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Tires with an insufficient load rating may be overloaded and fail, increasing the risk of a crash.
Remedy: GST will inspect and replace the tires as necessary, and install a new tire information label as necessary, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R1.
Oct 26, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2023 Highlander & Highlander Hybrid vehicles. During normal vehicle operation, minor impact to the front lower bumper cover may result in the cover coming loose or detaching.
Consequence & remedy
Consequence: A detached front bumper cover can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair or replace the upper and lower front bumper covers as necessary, free of charge. Owner letters were mailed April 22, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB12/23TA12.
Jul 12, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration