2021 Toyota Highlander

After just passing 100K miles, there is now a whirling noise upon acceleration. After taking to an auto repair shop, they narrowed it down to the transmission and said it was a known problem (referenced T-SB-0008-21) and suggested I take it to the dealership. I took to the dealership where a service manager offered to ride with me to confirm and he confirmed the issue was in fact the known problem noted from the technical service bulletin. The Toyota dealership assistant service manager stated that the noise (which he said was coming from a final drive gear bearing) would continue to get progressively worse and that despite being a known issue, there was no remediation available aside from replacing the transmission completely. He said that he saw no reason that I could not continue to drive the car without complications and without the transmission going completely out for at least a couple more years, but that the noise would get progressively louder until you could no longer tolerate the noise level and would need a new transmission at that point (despite it just beginning last week (or my just noticing it), you can hear it over the the radio when at a low to moderate volume). If this is a "known issue," (ie: a defect that is only in some of the cars per the T-SB-0008-21 notice) this does not seem like a reasonable answer to 'just wait until you can't stand the noise level with acceleration and then completely replace your transmission as there is nothing we can do for you' but it was suggested that I could take it to a body shop that would rebuild transmissions and they may could replace that part.

I own a 2021 Toyota Highlander with approximately 127k miles. The vehicle has developed a noticeable whining/whirring noise during acceleration. The noise appears to originate from the drivetrain/transmission area and has become increasingly noticeable over time. The condition occurs every-time during acceleration and is present under normal driving conditions. I am concerned that this may indicate a transmission or drivetrain-related issue that could affect vehicle reliability and safety. I have found reports from other 2021 Toyota Highlander owners describing similar symptoms involving whining noises during acceleration. The vehicle has been inspected by a Toyota dealership. And is certified through Toyota. The vehicles was bought new from the Toyota dealership and has had all service done through Toyota. I am submitting this complaint so NHTSA can evaluate whether this condition is part of a broader pattern affecting similar vehicles as a defect in the original transmission built in the SUV.

I own a 2021 Toyota Highlander with approximately 93,000 miles. The vehicle developed transmission symptoms including whining noise. A Toyota dealer diagnosed internal transmission failure and recommended complete transmission replacement at a cost of approximately $9786.31. Toyota declined repair assistance. I am concerned because a transmission failure at this mileage is unexpected and appears similar to other owner complaints involving the 2021 Toyota Highlander transmission.

The transmission in my 2021 Toyota Highlander began producing a whining noise during acceleration between approximately 15-50 mph at around 80,000 miles. The noise stops when the accelerator is released and has progressively become louder. The vehicle was inspected by a Toyota dealership. I was informed that the condition is a known issue affecting some Toyota vehicles, but no repair was offered because the vehicle is outside the 5-year/60,000-mile powertrain warranty. There are currently no warning lights or diagnostic trouble codes. I am concerned that the transmission may fail while driving, resulting in loss of power or propulsion and creating a safety risk for myself and other motorists. The vehicle remains available for inspection.

The front lower bumper detached while driving on the PA turnpike. The vehicle was traveling in the left lane approximately 75 MPH and was bumping on the road until we were able to pull over all the way to the right lane for approximately 1-2 miles. This hanging bumper dragging on the floor causing some damage to upper bumper as well. This was extremely unsafe for everyone in our vehicle and put the safety of all other driver around us at risk of accidents. No warning lights were present before bumper detached. Toyota dealership looked at it and refused to do anything about it, saying that they see damage to upper bumper and that is not part of recall. I told them the damage to upper bumper was caused by lower bumper falling off and being dragged at speeds of 75MPH until we could safely pull over. They stated that the recal only offered a repair kit to lower bumper. I will include a picture of bumper after lower bumper detached and upper bumper still firmly attached. I had no option and had the bumper repaired by a auto body repair shop. This should have been fixed by toyota and i would like to be reimbursed by toyota. There should be punishment to toyota corp for endagering the public and not keeping their word to correct recalls when they are known about. On June 8, 2026 i received a text message from toyota informing me that there was a recall on my vehicle for front bumper detaching. I responded that is exactly what happened to my vehicle. Needless to say they did not respond to that.

On XXX, I was driving my 2021 Toyota Highlander at approximately 55 mph when a deer entered the roadway and I had to brake suddenly to avoid a collision. My [XXX] daughter was properly seated in the second-row seat and was properly restrained by her seatbelt. During the braking event, the second-row seat unexpectedly folded forward while she was seated in it. As a result, my daughter experienced rib pain and soreness that lasted several days. After the incident, the seat was returned to the upright position and appeared to latch normally. The vehicle is subject to a recall involving the second-row seat. I contacted Toyota Customer Care on XXX, and Toyota provided a rental vehicle on XXX, while the recall issue is being addressed. I am reporting this incident because the recalled seat failed during an emergency braking event and resulted in injury to a child passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Right after the manufacture warranty of 60K miles, the car began to make a humming noise. I took the car into the dealership with 65K miles on 13 Jun 2026, and the Toyota dealership stated that the humming is caused by the transmission and we will need to replace the entire transmission. The cost would be $9,447.29. This issue is known by Toyota and Toyota put out Toyota Service Bulletin (T-SB-008-21) but failed to issue recall for this defective transmission.