2021 Toyota Highlander

2021 Vehicle has 105,000 miles, purchased certified used in 2023 from dealership. Whining noise with acceleration began so we brought to dealership to get the recalls fixed and asked about the whine on acceleration. Vehicle inspected at the Toyota dealership and service advisor stated that the transmission needed a full replacement and would have catastrophic failure if we keep driving. Advised that a new transmission is needed and cost of replacement is $10,000. The warranty no longer applies as the vehicle has over 100,000 miles. However we purchased with 66000. Technical service bulletin (T-SB-0008-21) notes that transmission issue recognized by Toyota since 2021. Hundreds of posts and complaints by Toyota Highlander owners with 2021 models can be found online. The dealership tried their third party warranty and the claim was denied. There should be more support from Toyota in supporting customers in replacing the transmission as it is clear this is a known issue. A recall is needed and a remedy in place. There is no reason a transmission should fail this early. Toyota needs to provide more support for this safety issue and replace the faulty transmission.

Vehicle has 84,000 miles, purchased new in 2021. Started to experience whining noise with acceleration and irregular shifting of gears. Knew it was a transmission problem. Vehicle inspected at the Toyota dealership and service advisor stated that metal shavings are seen in the transmission oil. Advised that a new transmission is needed but may take several months before it is available. Cost of replacement >$9000. The extended warranty that I purchased previously no longer applies as the vehicle has more than 72,000 miles. Technical service bulletin (T-SB-0008-21) notes that transmission issue recognized by Toyota since 2021. There should be more support from Toyota in supporting customers in replacing the transmission. There appears to be many other owners who have experienced similar issues. Due to well recognized safety issue related to transmission failures, a recall should/need to be pursued. Please help.

On February 16, 2025 the vehicle was parked. The temperatures that day were in single digits. After approximately 1 1/2 hours the 12V system was drained. The driver panel was blank and the vehicle did not respond to any attempt to start. This vehicle had a similar incident the prior year, also in extreme cold conditions. During that incident the vehicle was towed to the dealership. They recharge the 12V system and did not find any problems once the faults were cleared. For the February incident, an attempt was made to jump start the vehicle. After the jump start the driver panel was active, but the vehicle reported a hybrid system malfunction and would not start the engine. The vehicle was then towed to the dealership. Attached is the report from service team. Problem #1. Under cold weather conditions this vehicle will drain the 12V system leaving the driver stranded in dangerous weather. Problem #2. The jump start procedure leaves the ECU exposed to severe damage. This leaves the vehicle inoperable.

My transmission has a whining noise and is just over warranty. It is likely to fail soon. Toyota knows the transmission has had issues and has only recalled a select number of them but the issues are all over the board. The issues is consistent across all makes that use the UA80 trans mission (Sennia, Highlander, Camry, etc). In fact, these transmissions (new and remanufactured) all out of stock across the country because the issue is so bad. Research verifies this issue. Please see actual customer experiences below. There are way more out there when you research. [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission failure at 94k miles. Driving on I90 the truck started making very loud whining noise. TSB0008-21 was issued by Toyota Feb-21 and I bought my truck Apr-21. Toyota did NOT disclose this to me.Vehicle failure happened exactly like the TSB. Toyota takes no responsibility-extended warranty is 100% unethical as I am still waiting 4 weeks later for repair. Toyota has no new transmissions available either. Please look into issuing a recall- thousands of people are impacted- please investigate. Toyota is choosing profit over people and safety.

39,000 miles- Transmission starting to make a loud whining noise while driving. Dealership stated failed carrier bearing, unsafe to drive as this could cause the transmission to lock up at any moment. Toyota has a TSB out for this and has provided a loaner. My car does not fall within the TSB VIN range however still has same failure.