2019 Toyota Highlander

Hundreds of thousands of 2017–2022 gas-powered Toyota Highlanders (equipped with UA80E/UA80F 8-speed transmissions) are experiencing high-pitched whining noises, hard or erratic shifting, and sudden hesitation. This is caused by a factory defect where a retaining nut and locking tab in the counter drive gear sub-assembly were improperly installed, causing premature internal wear and gear movement

My Toyota Highlander 2019 began to produce a whining noise that orginates in the transmission at about 89000 miles. An independent mechanic examined the vehicle and deteremined that the noise is well documented. After conducting research, I found that the issue is caused by improper assembly and the only repair is a complete replacement of the transmission. I also discovered that there is a recall on the 2017-2019 Toyota Highlander due to the 8 speed transmission which is also used in my vehicle. The idea that the 2019-2022 Toyota Highlanders are NOT included in this recall is completely unreasonable. These vehicles utilize the same 8-speed transmission and the whining noise tends to surface after 60, 000 miles - about four to five years based on useage. The whining noise began without warning or symptoms. The vehicle drove without issues and we intended on driving this vehicle into retirement considering the reputation Toyota had on building reliable vehicles. I will never purchase or recommend the purchase of a Toyota vehicle! The idea that repeated transmission failures, without an univeral recall for all years affected, shows that the comsumer is not respected. I would enjoy understanding the logic and data that enabled Toyota to limit the recall to just three production year when the 8-speed transmission spanned six years of production (2017-2022). I am now forced to look into replacing the transmission with potentionally another faulty, improperly assembled 8-speed transmission.

I am reporting a potential premature transmission failure in my 2019 Toyota Highlander AWD. At approximately 89,000 miles, the vehicle developed a noticeable and persistent whining noise coming from the transmission/drivetrain area. The noise continued despite transmission service and has progressed to the point where the vehicle requires a transmission replacement. I have had the vehicle evaluated by three separate repair facilities, including transmission specialists. All three independently determined that the transmission has failed and requires replacement. Repair estimates range from approximately $7,200 to $12,000. A complete transmission failure at approximately 89,000 miles is unexpected and raises concerns about a possible design or manufacturing defect. A transmission failure while driving could cause loss of power, inability to accelerate, reduced control of the vehicle, or create a dangerous situation while merging, entering traffic, or traveling at highway speeds. The vehicle has been maintained and used normally. I am submitting this complaint because I believe this issue may affect other Toyota Highlander owners and should be investigated for a potential safety-related defect.

My 2019 Toyota Highlander XLE V6 developed a serious transmission-related safety problem that ultimately resulted in a sudden loss of propulsion while driving. For some time before the failure, I had noticed an unusual startup noise during cold starts and mentioned this concern during routine service visits at an authorized Toyota dealership. I was advised that the condition was normal. Prior to the major failure, the vehicle otherwise remained drivable. On December 2, 2025, the vehicle underwent scheduled maintenance at an authorized Toyota dealership, including a transmission fluid service. Within the following days, during cold weather conditions (approximately 35°F), the vehicle began exhibiting transmission shudder, RPM flare, harsh torque converter engagement, and illuminated both the Check Engine and Traction Control warning lights. I immediately returned the vehicle to the servicing dealership and reported that these symptoms had appeared following the maintenance visit. After inspection, I was informed that the torque converter clutch actuator had failed and that the transmission would require replacement or rebuilding. The vehicle was released to me, and I was not advised that it was unsafe to drive or that it should not be operated. On the morning of December 11, 2025, while driving home from work in approximately 31°F temperatures, the vehicle suddenly lost propulsion. The engine RPM increased, but the vehicle would not move under its own power. I narrowly avoided being rear-ended by a truck traveling behind me. I believe this created a significant risk of a serious collision. The vehicle was towed and remained out of service for approximately two months because replacement transmissions were difficult to obtain. The transmission was ultimately replaced with a used transmission assembly at a total repair cost of approximately $7,220. After the transmission replacement, the unusual startup noise that I had previously reported completely disappeared,

Transmission is giving a whining noice when accelerating. Took it to Toyota dealer, they said the transmission needs to be changed and it will cost me $11,000 . There are many complaints online about these UA80 Transmissions and the root cause is listed to an assembly problem during production but Toyota will not accept this and will not help to replace it

The contact owns a 2019 Toyota Highlander. The contact stated while driving 70 MPH, on the highway. the contact notice an abnormal noise coming from the transmission. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure and they informed him this will not b escalated and offered no further assistance. The approximate failure mileage was 133, 000.