2018 Toyota Highlander

The transmission went on my 2018 Toyota Highlander. The other day as I was driving on highway, lost power as I was driving in neutral. I went from 70mph to 10 or less mph, would not accelerate. All of a sudden all warning lights. Check AWD, check engine light came on, many messages at once. There were no warning lights displayed prior to this. I was able to get off an exit. Could not move the car anymore was not in a safe area, called police for assistance. The car was towed to an independent service center who confirmed it was a transmission issue.

Currently at 113k miles. VIN # is not on the recall or extended warranty list for transmission issues, shift lag has been noticed way before 100k miles. vehicle is making squealing noise on drive, and when gas petal is press. Since no recall, but per research, I may have a faulty transmission that is left out of the Customer support program zjc, t-SB-0160-18.

The UA80 8-speed automatic transmission failed catastrophically without any prior warning symptoms while driving on the highway. During normal acceleration to pass another vehicle, the engine revved to 5,000 RPM as the transmission slipped, then dropped to 3,000 RPM coasting. After exiting the highway approximately one mile later and coming to a stop at a red light, the transmission would no longer engage in any forward gear. The engine revs freely when placed in drive and the accelerator is pressed. Reverse still functions. The vehicle had to be towed from the roadside. This created a serious safety hazard. The driver was stranded on the side of a busy road and lost all forward propulsion without warning while operating at highway speed. The failure occurred suddenly with zero prior symptoms. The vehicle was operating normally around town earlier the same day. The driver had no advance warning of any kind, no warning lights, no unusual noises, no shifting irregularities, before the catastrophic highway failure. This is consistent with reports from other UA80 owners who describe sudden, total transmission failure at similar mileage. The loss of forward propulsion at highway speed posed an immediate safety risk to the driver and surrounding traffic. The driver had to navigate to the shoulder and then reverse off the roadway to reach a safe location to wait for a tow truck. I contacted Toyota Customer Experience at 800-331-4331 and was assigned a case number. Goodwill assistance was denied twice. I was told the system would not allow the representative to proceed. I was disconnected twice during attempts to escalate to a supervisor. My case was then closed without resolution. Over 430 NHTSA complaints have been filed regarding UA80 transmission failures across multiple Toyota and Lexus models from 2017-2024. The pattern of failure is well documented. I am requesting NHTSA investigate this transmission platform and the adequacy of Toyota's limited CSP ZJC coverage.

I am reporting a documented safety defect in my 2018 Toyota Highlander (VIN: [XXX] ). On March 31, 2026, a certified technician at Groove Toyota (Work Order #XXX) performed a diagnostic inspection to investigate a severe 'airplane whine' noise. The technician verified the noise and used a stethoscope to pinpoint the source as 'very loud coming from final drive,' officially recommending a full transmission replacement at an estimated cost of $8,475. This failure is a direct mechanical match for a known factory assembly error (insufficiently bent locking tab) acknowledged by Toyota in Technical Service Bulletin T-SB-0160-18 and Customer Support Program ZJC. Despite the technician's formal diagnosis that the vehicle is mechanically unsound and requires immediate replacement for safe operation, Toyota Corporate denied my request for assistance (Case #XXX) on April 8, 2026. Toyota cited my vehicle's VIN does not fall into the customer support program, although it's essentially the same transmission, effectively refusing to remedy a documented manufacturing defect. This vehicle has excellent service records, and Toyota’s refusal to honor the spirit of the ZJC program leaves me with a documented safety risk that the manufacturer refuses to address. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2018 toyota highlander awd. Whining noise when gas is pressed. Whining stops when gas pedal not engaged. Started at 116000 mileage. Regular service done at dealer. Slippage/ delay in gear shifting (automatic). No light on dash to show there may be an issue. Bought a toyota, because they are supposed to be great cars that run long time. Not real happy to hear that they know they have quality and training issues that can seriously hurt people, and they are not doing anything about it. And “their”consumers have to eat the cost for their mistake. I hope nhtsa files another motion to cover move of the vehicle having the powertrain issue

The contact owns a 2018 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle made grinding sounds while accelerating. Additionally, the vehicle jerked while shifting into gear. The vehicle was taken to the dealer, who determined that the transmission fluid was dirty and that the transmission assembly and torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 107,700.