2007 Toyota Highlander

While driving down the 405fwy downhill, all my lights went off and showed VSC system on my dashboard. This part of the fwy is not extremely steep but somewhat is. When applying my brakes it was hard to get my vehicle to stop especially because I’m on a freeway and when trying to slow down because I’m going downhill. I had my family in the car. I can’t imagine if my my brakes actually gave what would happen. I researched this and Toyota only called this a “warranty extension” for your Brake Actuator. I can’t believe this hasn’t been classified as an official recall. Especially since it pertains to the brakes. An essential quality mechanism to prevent death. They obviously know they were in the wrong here since the warranted this as a “warranty extension”. All these vehicles should be recalled for human safety. Shame on them.

we were station in the Military base in Belle chasse LA. I'm having a SAFETY issue with the vehicle brake system and ABS.I contacted Toyota and nothing was done this vehicle has like 76000 miles and this a mayor concerned, and safety issue I believe this is a factory problem from day one. I have read thousands of same complaints on line with same problem. I also read that Toyota had the same issue with Prius and my understanding is that it was a recall on those. My car is low in millage for the year and I have been the only owner. This is a safety issue and I need help I'm very concern for our safety and others . Thank you, and your attention to this matter is appreciated.

The 2007 Toyota Highlander Hybrid and certain Prius and Lexus models were equipped with an ABS actuator that could potentially fail and cause serious injuries and or death. A safety notice and enhanced warranty covered the parts and labor 10 years later; however, after the 10 years was up, the owner would be responsible for the all the costs. I noticed the vehicle making erratic noises from the engine bay and discovered it was the brake actuator but no warning lights or significant braking issues were of concern around 1/5/22. On 1/30/22 I was driving the vehicle when suddenly multiple lights came on which include the VSC, ABS, Brake, warning light, and exclamation warning light came on. The vehicle started acting erratic with unusual power loss and poor braking responsiveness. This also occurred on my 2005 Toyota Prius which I got into an accident in where the vehicle was totaled. This part should last the life of the vehicle, and if replaced in the past due to safety concerns under the enhanced warranty, all vehicles with the same old part number should be recalled and replaced at no charge to the owner.

Was driving on highway and Check Hybrid System, Check ABS System and Check VSC system flashed on dash, lost all power. Had to manage my way and pull over on the side as I could not accelerate anymore. Sent vehicle to 3 shops/dealerships, NOBODY can figure out what is wrong and all saying it cannot be fixed. HELP PLEASE! Car starts up on battery but when engine tries to fire up it sputters and dies and gives the Check Hybrid, Check VSC System messages. Codes scanned showed all 6 coils were bad, replaced them all and still saying all 6 are bad. New coils, new plugs, nobody knows what is the issue. I'm already into this for thousands of dollars, I really, really cannot afford any more money into this! Someone please help me. Thank you so much.

WE HAVE A 2007 TOYOTA HIGHLANDER HYBRID LIMITED WITH APPROXIMATELY 150K MILES. IN OCTOBER 2017 WE BEGAN TO EXPERIENCE BREAKING PULSING AND SQUEAKING ISSUES. UPON INSPECTION AT PRECISION TOYOTA OF TUCSON, AZ, IT WAS DETERMINED TO BE THE BREAK ACTUATOR. THE BREAK ACTUATOR FAILURE IS A VERY COMMON PROBLEM FOR TOYOTA VEHICLES BEGINNING AS EARLY AS 2004 AND THIS CAN BE EASILY SEARCHED ONLINE. THIS BREAK FAILURE CAN RESULT IN COMPLETE BREAK FAILURE WHILE DRIVING (AND REPORTS OF THIS OCCURRING ARE EASILY SEARCHED ONLINE). IN 2017, THE BREAK ACTUATOR REPLACEMENT WAS FULLY COVERED BY THE WARRANTY ENHANCEMENT PROGRAM, BUT IT WAS VERBALLY ESTIMATED AT $2200 TO REPAIR AT THAT TIME. AS THE OWNERS OF THIS VEHICLE FOR SINCE 2009, IT WAS ODD THAT WE WERE NEVER NOTIFIED OF THIS RECALL/EXTENDED WARRANTY- BUT JUST 'FORTUNATE' ENOUGH TO HAVE OURS FAIL IN A TIMELY MANNER TO BE FULLY COVERED BY THE EXTENDED WARRANTY. IN NOVEMBER 2020, OUR 2007 TOYOTA HYBRID HIGHLANDER BEGAN DEMONSTRATING THE SAME BREAK ACTUATOR FAILURE 'SYMPTOMS' AS IN OCTOBER 2017 (PULSING BREAKS, REDUCED RESPONSE TO INCREASED BREAK PRESSURE, SQUEAKING NOISE WHEN BREAK DEPRESSED WHILE PARKED OR DRIVING). THIS REPAIR/REPLACEMENT IS NO LONGER COVERED UNDER THE WARRANTY ENHANCEMENT PROGRAM, EVEN THOUGH THE 2008- 2010 MODELS OF OUR VEHICLE HAD AN EXTENSION UNTIL 12/31/2020. THE ESTIMATE FOR THIS SECOND REPAIR IN 3 YEARS IS ~$2500-$2800... FOR A WIDELY-KNOWN AND DANGEROUS BREAK ENGINEERING ERROR THAT TOYOTA IS WELL AWARE OF AND HAS BEEN FOR YEARS.

ABOUT A MONTH AGO, MY WIFE CALLED ME FROM FAR AWAY TELLING ME THAT SHE SUDDENLY HAD BRAKE-RELATED WARMING LIGHTS. I QUICKLY READ UP ON THE ABS SYSTEM FAILURES IN THIS CAR, AND SINCE SHE DID NOT YET HAVE SYMPTOMS, I TOLD HER TO DRIVE BACK CAREFULLY. I THEN REVIEWED MY FILES ON THE CAR AND SAW THAT THEY HAD SENT ME AN EXTENDED WARRANTY NOTICE ABOUT THIS PROBLEM, AND SUGGESTED THAT WE BRING THE CAR IN IF WE HAVE THESE WARNING LIGHTS. BUT WE NEVER HAD THE WARNING LIGHTS PREVIOUSLY, SO I MISSED THE BOAT ON THE EXTENDED WARRANTY. WE DID, HOWEVER, ALMOST FROM THE TIME THE CAR WAS JUST A FEW YEARS OLD, HAVE A LOUD CLUNKING NOISE FROM UNDER THE HOOD ON STARTUP OR SHUTDOWN. ACCORDING TO VARIOUS HIGHLANDER FORUMS, THIS IS A CLASSIC SYMPTOM OF ABS ACTUATOR FAILURE AND IF TOYOTA HAD JUST MENTIONED THIS IN THE THEIR EXTENDED WARRANTY NOTICE, I WOULD HAVE BROUGHT THE CAR IN IMMEDIATELY. I HAD THE SAME SOUND FROM MY 2007 PRIUS; I MENTIONED THE NOISE TO THE TOYOTA SERVICE PEOPLE AND THEY TOLD ME IT WAS THE COOLANT THERMOS BOTTLE AND WAS OF NO CONCERN. TO FIX MY HIGHLANDER, TOYOTA WANTED AROUND THREE THOUSAND DOLLARS; I TOLD THEM THAT WAS NOT REASONABLE SINCE REPLACING IT IS SIMPLE: 2 BOLTS, 1 ELECTRICAL CONNECTOR, 6 BRAKE LINES, AND A BRAKE BLEED. THEY WANTED ABOUT $2000 JUST FOR THE PART. THE TOYOTA SERVICE MANAGER TOLD ME I COULD STILL DRIVE THE CAR SINCE IT IS NOT A SAFETY CONCERN: IF IT FAILS THE ABS SYSTEM WILL STOP WORKING BUT NOT THE BRAKES. BASED ON THE EXPERIENCES OF OTHER HH OWNERS THAT I AM READING ABOUT AT THE NHTSA WEB SITE, HOWEVER, I FIND THIS HARD TO BELIEVE. ALSO, THE BRAKES ARE NOW GRABBING STRANGELY AND PULSATING WHEN THEY DON'T NEED TO BE. THERE SHOULD BE A RECALL SINCE 1.) THE PART SHOULD LAST THE LIFE OF THE CAR, 2. IT IS A SAFETY CONCERN, AND 3. TOYOTA DID NOT GIVE ACCURATE INFORMATION IN THEIR NOTICE TO ALLOW ME TO SPOT THE PROBLEM IN TIME.