← New search

2006 Toyota Highlander

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Toyota Highlander do not stand out strongly from the model-year median of 186.5.

About this comparison →

When problems were reported

Mileage at the reported incident

199 reports with mileage · 78 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Vehicle Speed Control. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

29 crash reports4 fire reports19 injury reports

What owners actually said

277 reports
259,294 miles · Jan 7, 2019
Electrical SystemService Brakes

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING AT AN UNKNOWN SPEED, ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO TOYOTA OF CLEVELAND (3560 VILLAGE N BLVD, MCDONALD, TN 37353) WHERE IT WAS DIAGNOSED THAT THE ABS ACTUATOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPA…

Read full complaint

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING AT AN UNKNOWN SPEED, ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO TOYOTA OF CLEVELAND (3560 VILLAGE N BLVD, MCDONALD, TN 37353) WHERE IT WAS DIAGNOSED THAT THE ABS ACTUATOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 259,294.

NHTSA ODI #11164826

Mileage unknown · Oct 9, 2018
Service BrakesVehicle Speed ControlCrashInjury

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE MAKING A TURN AT 5 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED AT AN UNKNOWN SPEED. AS A RESULT, THE VEHICLE STRUCK A PEDESTRIAN. A POLICE REPORT WAS FILED. THE PEDESTRIAN SUFFERED INJURIES AND MEDICAL ATTENTION WAS REQUIRED. THE DEALER AND MANUFACTU…

Read full complaint

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE MAKING A TURN AT 5 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED AT AN UNKNOWN SPEED. AS A RESULT, THE VEHICLE STRUCK A PEDESTRIAN. A POLICE REPORT WAS FILED. THE PEDESTRIAN SUFFERED INJURIES AND MEDICAL ATTENTION WAS REQUIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. *JS

NHTSA ODI #11139259

208,000 miles · Jun 6, 2018
Vehicle Speed Control

THE VEHICLE ACCELERATES SEEMINGLY ON IT'S OWN. WHILE DRIVING IT PICKS UP SPEED THEN SLOWS DOWN SOME.

NHTSA ODI #11100158

10,000 miles · Apr 23, 2018
Electrical System

THE PASSENGER WINDOWS CONTINUALLY STICK IN THE DOWN POSITION. I HAVE TAKEN MY HIGHLANDER TO TOYOTA SEVERAL TIMES AND PAID HUNDREDS OF DOLLARS IN REPAIRS. ALSO, THE FOB QUIT WORKING ON THE DRIVER DOOR. I THINK THERE MIGHT BE AN ELECTRICAL ISSUE IN THE DOORS.

NHTSA ODI #11089665

Mileage unknown · Apr 18, 2018
Service Brakes

TWO MONTHS AGO, MY CAR SYSTEM NOTED ABS SYSTEM PROBLEM: ABS LIGHT, BRAKE LIGHT, AND OTHER LIGHTS ON. I TOOK MY CAR TO TOYOTA PLACE IN GARDEN GROVE, CA DEALER, THEY TOLD ME ABS SYSTEM FAILED, IT WOULD BE REPLACED AS POSSIBLE, THE COST IS FROM $2500 TO 3500. THEY ALSO SAID THE CAR I CAN DRIVE BUT THE ABS DIDN'T WORK. THE PROBL…

Read full complaint

TWO MONTHS AGO, MY CAR SYSTEM NOTED ABS SYSTEM PROBLEM: ABS LIGHT, BRAKE LIGHT, AND OTHER LIGHTS ON. I TOOK MY CAR TO TOYOTA PLACE IN GARDEN GROVE, CA DEALER, THEY TOLD ME ABS SYSTEM FAILED, IT WOULD BE REPLACED AS POSSIBLE, THE COST IS FROM $2500 TO 3500. THEY ALSO SAID THE CAR I CAN DRIVE BUT THE ABS DIDN'T WORK. THE PROBLEM IS THE COST IS TOO HIGH AND I CAN'T AFFORD FOR IT. ON LAST MONDAY 04/16/2018, AROUND 7:30AM ON THE WAY DRIVING TO THE WORK PLACE, I STEPPED ON BRAKE PEDAL, THE BRAKE SYSTEM DID NOTHING, MY CAR RAN OUT OF CONTROL. LUCKILY, I WAS FIRST IN THE LINE, THEN I DROVE THE CAR WITH NO STEP ON GAS PEDAL, HIT EMERGENCY LIGHTS ON, AND USED THE LEG BRAKE TO STOP THE CAR. AFTER THAT, MY CAR WAS TOWED TO THE TOYOTA DEALER, THEY SAID ABS ACTUATOR STOPPED WORKING AND HAD TO BE REPLACED. THEY CHARGED ME $2,642.32; THE PART COST IS $1,834.94, BRAKE FLUID IS $7.04, THE LABOR IS $650 (FROM THE ARRIVING TIME 9:36AM TO THE CALLING TIME TO NOTE MY CAR TO BE DONE AROUND 3:40PM) AND SALES TAX IS $143.30. YOU SHOULD KNOW MY CAR IS PERMANENTLY CHANGED OIL AND MAINTENANCE AT THE SAME DEALER FROM 2011, THE YEAR I BOUGHT THE CAR AS A PRE-OWNER CAR. IN THIS PERIOD TIME, MY CAR IS ALWAYS INSPECTED BY THE DEALER WITH NOTHING BIG PROBLEM AND SPECIFICALLY WITH NO WARNING ABOUT ABS SYSTEM. IN ADDITION, IN OWNER'S MANUAL AND SCHEDULED MAINTENANCE GUIDE THE MANUFACTORY KEEPS SILENT RECOMMENDATION ABOUT ABS SYSTEM REPLACEMENT. TODAY, I AM FILING A COMPLAIN ABOUT THE ABS SYSTEM PROBLEM OF TOYOTA HIGHLANDER 2006 BECAUSE IT IS VERY, VERY DANGEROUS FOR ITS CUSTOMERS WHEN DRIVING ON IT. I ALSO READ MORE THE SAME PROBLEM FROM ITS CUSTOMERS ON ONLINE. THEY MAY OR MAY NOT OPEN A FILE, BUT IT IS VITAL OF THE CONSUMER AND ALSO THE BUDGET OF EACH FAMILY. I HOPE YOU HAVE TO HELP TO SAVE THE LIFE OF PEOPLE ON THE ROAD AND SAVE THEIR MONEY ALSO. THANK YOU VERY MUCH FOR YOUR TIME.

NHTSA ODI #11088924

Mileage unknown · Mar 1, 2018
Vehicle Speed Control

2006 TOYOTA HIGHLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE SUDDEN ACCELERATION ACCIDENT. *SMD THE CONSUMER STATED THE VEHICLE ACCELERATED AND JUMPED A CURB AND HIT A BUILDING WHILE THE BRAKES WERE BEING DEPRESSED. *JS

NHTSA ODI #10845498

Mileage unknown · Feb 5, 2018
Electronic Stability Control (esc)Engine

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND LOST POWER. THE CONTACT STATED THAT ALL OF THE WARNING INDICATORS ILLUMINATED ON AND OFF. THE CONTACT CALLED STEVENS CREEK TOYOTA SAN JOSE AT (408) 984-1234 (LOCATED AT 4202 STEVENS CREEK BLVD, SAN JOS…

Read full complaint

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND LOST POWER. THE CONTACT STATED THAT ALL OF THE WARNING INDICATORS ILLUMINATED ON AND OFF. THE CONTACT CALLED STEVENS CREEK TOYOTA SAN JOSE AT (408) 984-1234 (LOCATED AT 4202 STEVENS CREEK BLVD, SAN JOSE, CA 95129) WHERE IT WAS CONFIRMED THAT NO RECALLS WERE ASSOCIATED WITH THE VIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ODI #11067113

140,000 miles · Nov 4, 2017
Unknown Or OtherVisibility/wiper

THE DRIVERS SIDE SUN VISOR FALLS DOWN WHETHER IN MOTION OR STOPPED, IT CAUSES A BLOCKED VISION WHICH CAN CAUSE COLLISIONS.

NHTSA ODI #11043185

179,800 miles · Aug 19, 2017
Power Train

THE VEHICLE WILL OCCASIONALLY SURGE IN SPEED MOMENTARILY, MOSTLY NOTICED WHEN OPERATING BELOW 50 MPH. IT IS MORE PREVALENT AT LOWER SPEEDS. WE ARE THE ORIGINAL OWNER.THIS HAS BEEN AN ONGOING SITUATION SINCE THE VEHICLE WAS NEW. HYBRID MODEL. IT HAS BEEN INSPECTED BY THE DEALER WITH NO ISSUES FOUND.

NHTSA ODI #11016298

Mileage unknown · Jun 14, 2017
Service Brakes

PLEASE DISREGARD COMPLAIN NUMBER 10994017. THE AGENT DIDN'T PUT CORRECT DESCRIPTION. THE VEHICLE'S BRAKE WARNING LIGHT WAS SUDDENLY ON ON 6/4/2017. THE BRAKE FLUID WAS LOW. THE VEHICLE HAD BRAKE WORK DONE IN LATE APRIL WITH TOYOTA OF NASHUA AND REPLACED THE BRAKE FLUID. THE NEXT MORNING THE BRAKE WAS NOT EFFECTIVE (MAKING NOISE …

Read full complaint

PLEASE DISREGARD COMPLAIN NUMBER 10994017. THE AGENT DIDN'T PUT CORRECT DESCRIPTION. THE VEHICLE'S BRAKE WARNING LIGHT WAS SUDDENLY ON ON 6/4/2017. THE BRAKE FLUID WAS LOW. THE VEHICLE HAD BRAKE WORK DONE IN LATE APRIL WITH TOYOTA OF NASHUA AND REPLACED THE BRAKE FLUID. THE NEXT MORNING THE BRAKE WAS NOT EFFECTIVE (MAKING NOISE WHEN PRESSING BRAKE PADDLE AND DID NOT EFFECTIVELY STOP). BROUGHT TO THE TOYOTA DEALER AND WAS TOLD THE SEAL BROKE, CAUSED BRAKE FLUID GET TO MASTER CYLINDER, THUS FAILURE, AND THE BRAKE FLUID ALSO LEAKED TO THE BRAKE BOOSTER AND BOTH PARTS NEEDS TO BE REPLACED. WE FOUND TOYOTA HAD A RECALL ON OCT 21 2010, WHICH DESCRIBED THE EXACTLY THE SAME CAUSE AS HAPPENED TO THIS CAR. FILE A CASE WITH TOYOTA CORP AND THE RESPONSE WAS ANY PART CAN FAIL AT ANY TIME. THE VEHICLE PASSED 1 YEAR WARRANTY OF RECALL WORK. SO TOYOTA IS NOT RESPONSIBLE FOR THE REPAIR. NOTE, IN THE ORIGINAL RECALL, WHICH WAS 2010 FOR HIGHLANDER MANUFACTURED IN 2004-2006, WHICH IS AS LONG AS 6 YEARS LATER, TOYOTA MADE THIS RECALL AND STATED THAT THEY REIMBURSED THE REPAIR COST OF MASTER CYLINDER AND BRAKE BOOSTER IF DAMAGED. THERE WAS NO MILEAGE RESTRICTION. WITH TOYOTA'S RESPONSE, WHY EVEN BOTHER RECALL? THIS RAISED SERIOUS SAFETY ISSUE. IT'S VERY LIKELY TO CRASH WITH SUCH DAMAGE DUE TO THE SEAL LEAK. IF THIS CONTINUED TO BE A SAFETY ISSUE, TOYOTA SHOULD PUT THIS CHECK INTO THEIR REGULAR MAINTENANCE CHECK AND REPLACEMENT. THERE ARE QUITE A FEW REPORTED PROBLEMS WITH THIS ISSUE: HTTP://WWW.CARPROBLEMZOO.COM/TOYOTA/HIGHLANDER/BRAKE-MASTER-CYLINDER-PROBLEMS.PHP. TOYOTA'S RESPONSE SHOWS INDIFFERENCE TO THE CONSUMERS AND SAFETY OF THEIR LIVES. I HOPE THIS BRINGS TOYOTA MORE ATTENTION TO BE RESPONSIBLE TO THE DEFECT AS APPARENTLY THIS IS NOT THE SINGLE OCCURRENCE. WITH SUCH CONDITION OF THE BRAKE, IT IS HIGHLY LIKELY TO CAUSE CRASH. I HOPE SOMEONE CAN DO FURTHER INVESTIGATION.

NHTSA ODI #10995154

Official recalls

7

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

14V743000 · Seats:front Assembly:seat Heater/cooler

Nov 19, 2014

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence & remedy

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V223000 · Equipment:other:labels

Jun 15, 2009

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Consequence & remedy

Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

PE06055 · Sudden Loss Of Power Steering Assist

Opened Nov 21, 2006 · Closed Mar 28, 2007

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Additional source detail variants (2)

Steering:electric Power Assist System

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Steering

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.