Illustration2005 HIGHLANDER V6 AWD. HAS A SURGING EFFECT SINCE DAY ONE. ALSO SURGES SLIGHTLY WHEN APPLYING BRAKES. IN TRAFFIC STOP AND GO SITUATION, VEHICLE DOES NOT RESPOND FOR A FEW SECONDS AND THEN LUNGES FORWARD. VERY DANGEROUS WHEN TRYING TO CHANGE LANES. DEALER SAID NOTHING WRONG WITH VEHICLE. TOYOTA SAID AT TIME TO CONTACT DEALER.
2005 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
3325–50K
4450–75K
2575–100K
24100–150K
10150K+
171 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports4 fire reports16 injury reports
Power Train complaints
51 reportsI'VE OWNED A 2005 TOYOTA HIGHLANDER SINCE NEW, ONCE IN A WHILE THIS CONDITION WOULD OCCUR, NOW IT IS ALL THE TIME. IT JUST TURNED OVER 80K MILES. I HAVE NOT BEEN NOTIFIED OF ANY RECALLS, NOT EVEN TOYOTA NO. 60F. WHEN YOU ARE COMING TO A STOP,AT NORMAL SPEEDS,NORMAL BRAKING PEDAL PRESSURE, JUST BEFORE THE VEHICLE STOPS, IT LAUNC…
Read full complaint
I'VE OWNED A 2005 TOYOTA HIGHLANDER SINCE NEW, ONCE IN A WHILE THIS CONDITION WOULD OCCUR, NOW IT IS ALL THE TIME. IT JUST TURNED OVER 80K MILES. I HAVE NOT BEEN NOTIFIED OF ANY RECALLS, NOT EVEN TOYOTA NO. 60F. WHEN YOU ARE COMING TO A STOP,AT NORMAL SPEEDS,NORMAL BRAKING PEDAL PRESSURE, JUST BEFORE THE VEHICLE STOPS, IT LAUNCHES FORWARD WITH YOUR FOOT PRESSURE ON THE BRAKE PEDAL. WHEN YOU APPLY MORE PRESSURE AS IF THERE WAS AN EMERGENCY, IT IS WORSE. MY WIFE AND I HAVE LEARNED TO COMPENSATE BY COASTING THEN STOPPING. I EMAILED TOYOTA.COM ABOUT THIS TWICE, NO ANSWERS. *TR
2005 HIGHLANDER LTD. HAS A SURGING EFFECT SINCE DAY ONE. ALSO SURGES SLIGHTLY WHEN APPLYING BRAKES. DEALER SAID NOTHING WRONG WITH VEHICLE. TOYOTA SAID AT TIME TO CONTACT DEALER. TOYOTA HAS KEPT IT'S HEAD IN THE SAND TOO LONG. *TR
I OWN A 2005 TOYOTA HIGHLANDER. I WENT TO A FRIEND'S HOUSE AND PARKED VEHICLE IN FRONT OF THE HOUSE IN THE DRIVEWAY BY PLACING THE GEAR SHIFT IN THE PARK POSITION. I LEFT THE VEHICLE IDLING WHILE I WENT INTO MY FRIEND'S HOUSE TO GET A GROCERY LIST. I WENT IN AND OUT OF THE HOUSE ON 2 DIFFERENT OCCASIONS OVER A PERIOD OF ABOUT 1…
Read full complaint
I OWN A 2005 TOYOTA HIGHLANDER. I WENT TO A FRIEND'S HOUSE AND PARKED VEHICLE IN FRONT OF THE HOUSE IN THE DRIVEWAY BY PLACING THE GEAR SHIFT IN THE PARK POSITION. I LEFT THE VEHICLE IDLING WHILE I WENT INTO MY FRIEND'S HOUSE TO GET A GROCERY LIST. I WENT IN AND OUT OF THE HOUSE ON 2 DIFFERENT OCCASIONS OVER A PERIOD OF ABOUT 10- 15 MINUTES TO RETRIEVE ITEMS FOR MY FRIEND THAT WERE OUTSIDE. ON BOTH OCCASIONS MY VEHICLE WAS IN THE DRIVEWAY IDLING. WHILE I WAS BACK INSIDE RETRIEVING THE GROCERY LIST MY FRIEND AND I OBSERVED MY VEHICLE MOVING THROUGH HER BACK YARD AND PROCEEDED INTO THE WOODS BEHIND HER HOUSE WHERE IT CAME TO A STOP AFTER HITTING A TREE. THIS VEHICLE SOMEHOW TOOK ITSELF OUT OF THE PARK POSITION AND INTO DRIVE!!!! I REPORTED THIS TO MY TOYOTA DEALER AND THE INSURANCE COMPANY. THE TOYOTA DEALER AND THE REGIONAL TOYOTA MANAGER SAID THERE WAS NO WAY THIS COULD HAVE HAPPENED AND THAT IT WAS NOT THE SAME ISSUE BEING INVESTIGATED (GAS PEDAL ISSUE). I WENT AHEAD AND HAD THE CAR REPAIRED AND THE INSURANCE COMPANY PAID FOR IT (EXCEPT FOR MY $500.00 DEDUCTIBLE) WITH NO INVESTIGATION OR QUESTIONS. I PICKED THE CAR UP TODAY AND NOW I AM HEARING ON THE NEWS THAT MANY OF THE SO CALLED GAS PEDAL INCIDENTS HAVE NOT BEEN EXPLAINED AND THAT IT IS POSSIBLE THAT MANY OF THE PREVIOUSLY REPORTED INCIDENTS CAN ONLY BE EXPLAINED BY A FAULTY COMPUTER. RIGHT AFTER THE ACCIDENT I ASKED THE TOYOTA DEALER/REGIONAL MANAGER SPECIFICALLY IF MY INCIDENT COULD HAVE BEEN CAUSED BY A COMPUTER MALFUNCTION. THE ANSWER WAS NO! *TR
MY 2005 TOYOTA HIGHLANDER, V6 MODEL, ALWAYS ON APPLYING THE BRAKES THE FIRST TIME AFTER STARTING IN THE MORNING IS LIKE THE ABS SYSTEM IS ENGAGED, IT TAKES LONGER TO STOP THAN IT WILL ON THE SUCCEEDING BRAKING APPLICATIONS. THIS IS VERY DANGEROUS, ESPECIALLY TO SOMEONE WHO MAY NOT BE PREPARED FOR THIS OR IS NOT THE USUAL DRIVER…
Read full complaint
MY 2005 TOYOTA HIGHLANDER, V6 MODEL, ALWAYS ON APPLYING THE BRAKES THE FIRST TIME AFTER STARTING IN THE MORNING IS LIKE THE ABS SYSTEM IS ENGAGED, IT TAKES LONGER TO STOP THAN IT WILL ON THE SUCCEEDING BRAKING APPLICATIONS. THIS IS VERY DANGEROUS, ESPECIALLY TO SOMEONE WHO MAY NOT BE PREPARED FOR THIS OR IS NOT THE USUAL DRIVER. AT FIRST I THOUGHT THIS WAS JUST HYDRAULICS BUT NOW I THINK IT IS TIED TO THE ABS SYSTEM, AFTER READING OF THE PROBLEM WITH ACCELERATION. *TR
MY 2005 TOYOTA HIGHLANDER HAS CHRONIC TRANSMISSION PROBLEMS. WHEN ACCELERATING, THE ENGINE REVS BUT THE TRANSMISSION HESITATES NOTICEABLY BEFORE GOING INTO GEAR. SOMETIMES THE HESITATION LASTS SO LONG THAT IT INTERFERES WITH MY ABILITY TO MERGE ONTO THE FREEWAY AND THOSE ARE VERY SCARY SITUATIONS. SOMETIMES THE TRANSMISSION CANN…
Read full complaint
MY 2005 TOYOTA HIGHLANDER HAS CHRONIC TRANSMISSION PROBLEMS. WHEN ACCELERATING, THE ENGINE REVS BUT THE TRANSMISSION HESITATES NOTICEABLY BEFORE GOING INTO GEAR. SOMETIMES THE HESITATION LASTS SO LONG THAT IT INTERFERES WITH MY ABILITY TO MERGE ONTO THE FREEWAY AND THOSE ARE VERY SCARY SITUATIONS. SOMETIMES THE TRANSMISSION CANNOT DECIDE WHAT GEAR TO BE IN AND WHEN IT DOES ENGAGE THE WHOLE CAR BUCKS OR SHUDDERS. EVERYONE WHO DRIVES MY CAR EXPERIENCES THE SAME PROBLEM. EVEN THE PASSENGERS NOTICE. THE TOYOTA DEALER CLAIMS THAT THERE IS NO PROBLEM WITH THE VEHICLE AND THAT THE PROBLEM IS MY DRIVING AND THAT I HAVE NOT ADJUSTED TO THE CAR'S "DRIVE BY WIRE" SYSTEM. ONE MECHANIC DID ADMIT THAT THERE WERE ISSUES WITH THE TRANSMISSION'S COMPUTER FOR THIS MODEL YEAR. OTHER THAN THAT, TOYOTA INSISTS THAT THERE IS NO PROBLEM AND THAT I HAVE TO LEARN HOW TO DRIVE THE CAR. *TR
MY 2005 TOYOTA HIGHLANDER V6 4WD, WHICH I PURCHASED NEW, HAS BEEN EXPERIENCING A HESITATION/SHIFTING PROBLEM FOR NEARLY AS LONG AS I HAVE OWNED THE VEHICLE. WHILE THE PROBLEM DOES NOT ALWAYS OCCUR, IT IS QUITE PRONOUNCED WHEN IT DOES AND HAS RESULTED IN VERY DANGEROUS SITUATIONS. THE PROBLEM HAS BEEN BROUGHT TO THE DIRECT ATTENT…
Read full complaint
MY 2005 TOYOTA HIGHLANDER V6 4WD, WHICH I PURCHASED NEW, HAS BEEN EXPERIENCING A HESITATION/SHIFTING PROBLEM FOR NEARLY AS LONG AS I HAVE OWNED THE VEHICLE. WHILE THE PROBLEM DOES NOT ALWAYS OCCUR, IT IS QUITE PRONOUNCED WHEN IT DOES AND HAS RESULTED IN VERY DANGEROUS SITUATIONS. THE PROBLEM HAS BEEN BROUGHT TO THE DIRECT ATTENTION OF TOYOTA MOTOR SALES IN CALIFORNIA, AND THEIR RESPONSE HAS BEEN DISTURBINGLY POOR. THE TOYOTA DEALER THAT HAS BEEN SERVICING MY VEHICLE HAS BEEN VERY HELPFUL, BUT APPARENTLY CANNOT TAKE ACTION TO CORRECT THE PROBLEM WITHOUT CORPORATE AUTHORIZATION. HERE IS A SUMMARY OF THE PROBLEM: THE VEHICLE CANNOT ALWAYS DECIDE WHEN TO ACCELERATE FROM A STOP - THERE HAVE BEEN MANY INSTANCES OF INITIAL HESITATION/LACK OF ADEQUATE POWER UPON APPLYING THE GAS PEDAL. FOR EXAMPLE, I HAVE EXPERIENCED A DELAY OF A SECOND OR TWO WHEN APPLYING THE GAS PEDAL TO PROCEED. THIS HAS RESULTED IN SOME VERY CLOSE CALLS WITH ONCOMING TRAFFIC. ALSO, THERE ARE OCCURRENCES WHERE THE VEHICLE CANNOT SEEM TO DECIDE BETWEEN GEARS (IT WILL SOMETIMES JUMP UP/DOWN BETWEEN THE LOWER GEARS, SUCH AS 1ST TO 2ND GEAR AND/OR 2ND TO 3RD GEAR). FURTHERMORE, I HAVE NOTICED A GENERAL LACK OF ADEQUATE ACCELERATION/GAS PEDAL RESPONSE, ESPECIALLY DURING CITY DRIVING (IE. LOWER SPEEDS). MY LOCAL TOYOTA DEALER HAS RECORDS OF THE PROBLEM SINCE APPROXIMATELY 16,000 MILES (THE VEHICLE NOW HAS ABOUT 44,000 MILES). I BELIEVE THE ISSUE IS THE ECM, WHICH WAS REPROGRAMMED BUT THE PROBLEM RETURNED. BASED ON MY RESEARCH, I BELIEVE THE ECM MAY BE DEFECTIVE AND THAT REPLACING THE UNIT MAY SOLVE THE PROBLEM. TOYOTA WILL NOT REPLACE THE ECM. ABOUT A MONTH AGO, THE TOYOTA DEALER WAS ABLE TO VERIFY THE HESITATION PROBLEM DURING A SERVICE VISIT. HOWEVER, THEY COULD NOT DUPLICATE IT LATER WITH THE SCAN TOOL ATTACHED - THEY HAD THE VEHICLE FOR TWO DAYS TRYING TO GET A SNAP SHOT BECAUSE THE TOYOTA FIELD SERVICE TECHNICIAN TOLD THEM "NO REPAIRS ARE TO BE MADE UNTIL THE PROBLEM OCCURS MORE OFTEN." TW*
AUTOMATIC TRANSMISSION IS FORCING FLUID OUT THROUGH VENT CAUSING LOSS OF FLUID AND POSSIBLE DAMAGE TO TRANSMISSION. DEALER SAID IT IS CAUSED BY BEARING GOING BAD IN THE TRANSMISSION. VEHICLE HAS ALMOST 90,000 MILES. DEALERSHIP SAID PROBLEM IS COVERED UNDER EXTENDED WARRANTY SINCE IT WAS A CERTIFIED USED VEHICLE. *TR
2005 TOYOTA HIGHLANDER WITH ONLY 72000 MILES (12,000 MILES OUT OF WARRANTY), SEALS ON TRANSFER CASE OF TRANSMISSION LEAKS ONTO EXHAUST PIPE CAUSING SMOKING AND SMELL OF BURNT FLUIDS. *TR
I HAVE A 2005 HIGHLANDER THAT DEVELOPED A TRANSMISSION FLUID LEAK AT 62,000 MILES. TOYOTA CURRENTLY HAS A SERVICE BULLETIN OUT STATING THAT THE TRANSMISSION SEAL ON CERTAIN AWD HIGHLANDERS AND SIENNAS ARE PRONE TO PREMATURE FAILURE. THIS CAN RESULT IN LEAK OF TRANSMISSION OR FRONT DIFFERENTIAL FLUID. THE REPAIR IS NOT BEING C…
Read full complaint
I HAVE A 2005 HIGHLANDER THAT DEVELOPED A TRANSMISSION FLUID LEAK AT 62,000 MILES. TOYOTA CURRENTLY HAS A SERVICE BULLETIN OUT STATING THAT THE TRANSMISSION SEAL ON CERTAIN AWD HIGHLANDERS AND SIENNAS ARE PRONE TO PREMATURE FAILURE. THIS CAN RESULT IN LEAK OF TRANSMISSION OR FRONT DIFFERENTIAL FLUID. THE REPAIR IS NOT BEING COVERED UNDER THE WARRANTY FOR ME SINCE THE CAR IS BEYOND THE 60000 MILE POWERTRAIN WARRANTY. THE LOSS OF TRANSMISSION OR GEAR OIL CAN LEAD TO SUDDEN FREEZING OF DIVE-AXLE, WHICH SHOULD BE CONSIDERED A SERIOUS SAFETY ISSUE. *TR
Official recalls
616V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
11V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.