Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

35 crash reports4 fire reports16 injury reports

Exterior Lighting complaints

9 reports

Clear category filter

Mileage unknown · Sep 18, 2025

Electrical SystemExterior LightingUnknown Or Other

Read full complaint

All at once the windows, moon roof, blinkers, reverse lights, running lights and brake lights stopped working - also the automatic headlight function stopped working and we must turn on and off the headlights or risk draining the battery. It's interesting to note that the flashers work, but the blinkers do not. The wipers, radio, cruise control, etc. are all fine. It appears all fuses associated with these items are intact - I don't know how to check the viability of the relays, but have been told it could be a relay and or a ground wire. I've purchased a new multifunction blinker headlight replacement switch AND a master window replacement switch to see if this will resolve the issue - but the fact that it happened all at the same time concerns me that it could be electrical or wiring. All the wires under the dash are intact.

NHTSA ODI #11688025

266,000 miles · Jan 20, 2019

Exterior Lighting

REAR BREAK LIGHTS KEEP GOING OUT WITH FUSE BLOWING. NO REAR LIGHTS AT ALL WHEN THIS HAPPENS. I KEEP REPLACING THE 10A FUSE BUT CAN'T FIND CAUSE OF FAILURE. VEHICLE IS IN MOTION ON HIGHWAY. CAUSE OF LIGHTS SUDDENLY GOING OUT IS UNKNOWN.

NHTSA ODI #11171040

20 miles · Oct 19, 2015

Exterior Lighting

Read full complaint

WHEN DRIVING ON THE COUNTRY SIDE, WE USED THE HIGH BEAM LIGHTS AND NOTICED WHEN WE STOP SMOKE FROM THE HEAD LAMPS. IT WAS SO HOT THAT MELTED THE LENS COVERS. THIS REPRESENT A HAZARD AND LIABILITY. IT CAN CAUSE A SEVERE BURN SKIN DAMAGE TO A PERSON AND PROBABLY IF LEFT MORE TIME A FIRE. TOYOTA HAS A SERVICE TECHNICAL BULLETIN T-SB-0036-08 (NHTSA ID NUMBER: 10024893) THAT ADDRESS A "DISCOLORATION ON THE LENS". MY VIN NUMBER IS INCLUDED ON THE LIST. TOYOTA KNOWS THERE IS A PROBLEM WITH THE MATERIAL USED, IT ABSORBS TO MUCH HEAT. THIS IS A POTENTIAL FOR FIRE AND FOR A SEVERE BURN. TOYOTA SHOULD REPLACE THEM. PICTURES ATTACHED AS WELL AS SERVICE TECHNICAL BULLETIN T-SB-0036-08. EVEN THOUGH IT WAS NOT A FIRE, THE PRESENCE OF THE SMOKE INDICATE A POTENTIAL FOR FIRE IF WE HAD USE IT LONGER.

NHTSA ODI #10783330

100,097 miles · Mar 19, 2014

Exterior Lighting

Read full complaint

AS NOTED ON MULTIPLE WEBSITES FROM USERS HAVING THE SAME ISSUE AS I AM, THERE NEEDS TO BE A RECALL ON THIS ISSUE; THE REAR PASSENGER BRAKELIGHT IS FAULTY. IT DOES NOT ILLUMINATE WHEN PRESSED. THERE ARE HUNDREDS AND HUNDREDS OF OTHER HIGHLANDER OWNERS EXPERIENCING THIS EXACT SAME ISSUE. DEALER HAS BEEN NO HELP UNLESS I GIVE THEM EVERY PENNY I HAVE TO MY NAME OF COURSE. THIS IS AN ISSUE THAT I AM NOT EXPERIENCING ALONE. PUBLIC OUTCRY FOR ASSISTANCE NEEDED ON PULLING A RECALL ON THIS ISSUE. PLEASE AND THANK YOU. *TR

NHTSA ODI #10573531

43,000 miles · Sep 24, 2010

Exterior Lighting

Read full complaint

I AM APPROACHING 50,000 MILES ON THE CAR. I JUST RECENTLY NOTICED THAT THE HEADLIGHT LENS ON BOTH HEADLIGHTS HAS AN OPAQUE SPOT ABOUT ONE INCH IN DIAMETER DIRECTLY IN FRONT OF THE HIGHBEAM LIGHT BULB. TOYOTA HAS RECOGNIZED THIS PROBLEM SINCE APRIL 15, 2008 AS EVIDENCED BY TOYOTA TECHNICAL SERVICE BULLETIN #T-SB-0036-08 DATED APRIL 15, 2008. WHEN YOU GOOGLE THE BULLETIN IT WILL BECOME APPARENT THAT THIS PROBLEM EXISTS FOR SOME 2004 TO 2007 MODELS, A SPAN OF THREE YEARS. THE BULLETIN WILL ALSO SHOW THAT TOYOTA WILL REPLACE BOTH HEADLIGHTS IF COMPLAINED ABOUT DURING THE 36,000 / 3 YEAR WARRANTY PERIOD. I AM OUTSIDE OF THE WARRANTY PERIOD AND IN FEAR THAT IT WILL COST ME SEVERAL HUNDRED DOLLARS TO REPAIR A DESIGN DEFECT THAT TOYOTA HAS BEEN AWARE OF FOR SEVERAL YEARS. FROM WHAT I READ FROM OTHER POSTERS TOYOTA'S ATTITUDE APPEARS TO BE IT IS NOT OUR PROBLEM. *TR

NHTSA ODI #10357396

77,254 miles · Aug 3, 2010

Exterior Lighting

2005 TOYOTA HIGHLANDER WOULD NOT PASS 2010 MASSACHUSETTS STATE INSPECTION DUE TO FAULTY HEADLIGHT ASSEMBLY. THERE IS FOG IN THE LENS AND NIGHT TIME LIGHT IS IMPAIRED???? TOYOTA WILL NOT COVER THE $900 EXPENSE TO REPLACE BOTH HEADLIGHTS. THE EXTENDED WARRANTY DOES NOT COVER THIS EXPENSE AS WELL. *TR

NHTSA ODI #10347069

52,991 miles · Feb 21, 2010

Exterior LightingParking BrakeTires

Read full complaint

2005 TOYOTA HIGHLANDER HYBRID. DRIVING TO WORK IN A BLIZZARD ON 12/11/09 ALL DASH BOARD LIGHTS WENT ON. DEALERSHIP FOUND THAT THE SUNROOF HOUSING FAILED CAUSING $3,977.16 WORTH OF DAMAGE. BEING OUT OF WARRANTY THE DEALER AGREED TO PAY 2,000.00. TOYOTA CUSTOMER SERVICE ANOTHER 1,500 AND WE PAID 477.16. WE PICKED UP THE CAR ON 12/24/09. ON 2/2/10 WE RETURNED IT AFTER NOTICING A BURN SPOT ON EACH OF THE PLASTIC HEAD LIGHT COVERS. THE DEALER FOUND BOTH HIGHBEAM BULBS MELTED,AND SUGGESTED I HAD OVERUSED THEM CAUSING THE INTENSE HEAT THAT DID THE DAMAGE. I AM CONCERNED IT COULD BE A RESULT OF DELAYED WATER DAMAGE SHOWING UP. OUR CONCERNS WITH THIS CAR(WHICH WE PURCHASED NEW IN NOV. OF 2005)GOES BACK TO 9/7/06 WHEN THE CRUISE CONTROL DID NOT SLOW THE CAR GOING DOWN HILLS. ON 2/28/07 WE HAD BRAKE AND WIPER BLADE ISSUES. ON 4/20/07 THE BLADES LOCKED DURING A DOWNPOUR ON THE 5 FREEWAY. I HAD TO PULL OVER IN A PANIC. ON 7/12/07 THE CARGO CLIP HAD TO BE REPLACED. ON 9/10/07 THAT PARKING BRAKE DID NOT HOLD PROPERLY AND THERE WAS A RATTLE FROM THE RIGHT REAR. ON 11/6/07 WE COMPLAINED OF SQUEAKY BRAKES. DEALER TIGHTENED LOOSE NUTS AND BOLTS ON 4X4 ASSEMBLY. ON 4/1/08 THE BRAKES WERE REPLACED @ 29,080 MILES.ON 10/22/08 THE SOUND SYSTEM FAILED AND WAS REPLACED UNDER WARRANTY. NEXT WEEK WE ARE HAVING THE 5TH SET OF TIRES PUT ON THIS VEHICLE WHICH HAS ONLY 53,000 MILES ON IT. THE SET TO BE REPLACED HAS ONLY ABOUT 15,000 MILES ON THEM. THEY HAVE A 60,000 MILE WARRANTY. *TR

NHTSA ODI #10312516

Mileage unknown · Aug 28, 2007

Exterior LightingFire

MY DRIVER SIDE HIGH BEAM HEADLIGHT FLASHED BURNED MY LIGHT ENSEMBLE ON MY 2005 TOYOTA HIGHLANDER. SHOWED TECH AT TOYOTA AND CLAIMED DESPITE NEVER SEEN A FIRE CAUSED BY HEADLAMP THAT IT DID INDEED BURN PLASTIC HOUSING FROM FLASH BURN OUT NOT COVERED BY WARRANTY.*JB

NHTSA ODI #10201019

25,063 miles · Aug 10, 2007

Exterior Lighting

Read full complaint

DEFECTIVE HEADLIGHT LENSES IN JULY 2006, A 1-INCH DIAMETER OPAQUE "DISCOLORATION " APPEARED IN LEFT FRONT HEADLAMP LENS, DIRECTLY IN FRONT OF AREA CLOSEST TO HALOGEN BULB. BESIDES IMPAIRING LIGHT OUTPUT, I WAS FEARFUL THAT DEFECTIVE AREA WOULD EVENTUALLY BREAK OR CRACK, ALLOWING WATER TO CONTACT HALOGEN BULB - CAUSING IT TO EXPLODE WHEN HOT. (2005 TOYOTA HIGHLANDER WAS 18-MONTHS OLD AT THAT TIME, WITH 25,263 MILES.) TOYOTA REPLACED SAME UNDER WARRANTY. NOW SAME LENS DEFECT / DISCOLORATION IS OCCURRING TO RIGHT FRONT HEADLAMP PLASTIC LENS AT 45,000 MILES, AND AGAIN FEARFUL THAT LENS FAILURE WILL RESULT IN EXPLODING HALOGEN BULB. UNSURE IT TOYOTA WILL COVER THIS SECOND REPAIR. HEADLAMPS AND BULBS ARE ORIGINAL FACTORY EQUIPMENT. *JB

NHTSA ODI #10199097

Official recalls

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal