2025 Toyota Grand Highlander

The vehicle suddenly gave several warnings of “check engine visit your dealer”, “Hybrid system malfunction”, “AWD system malfunction 2WD activated” and “System malfunction visit your dealer.” The vehicle was bought new 4 weeks prior. Took it to the dealership and the technician said there was coolant all over the engine compartment and there was a leak somewhere. After inspection he told us that a small rock hit the radiator and caused damage. Told to replace the radiator and flush the system and it was not covered under warranty. After research was done, it was found there was a forum with hundreds of not thousands of people with the same issue. This has been an issue with the new OEM front grill not protecting the radiator and leaving it susceptible to be damaged easily. Toyota Corporate was called and said they were aware of the issue for some time. Even the Technician told us this is a common issue with this vehicle. Also if you place something inside the grill to protect the radiator, it will void the warranty.

The vehicle was in PARK and the IGN was in the ON/RUN position and the air conditioning was on. There was no one in the driver's seat but there was an occupant sitting buckled in the front passenger seat. The passenger heard a sound (possibly the ICE turning on) and he felt the vehicle move forward about five inches. He became worried about his safety and pressed the IGN button in order to turn the vehicle off. It could have pushed itself into other cars in the parking lot or pedestrians. A report was made to the local police department on the same day. This occurred in a retail parking lot. Video footage cannot be obtained as a police officer or insurance company must request it. I have not seen a check engine light nor any message prompts and it has not been inspected by a dealership.

Missing the wire connector for the puddle lamp installation? although not a safety issue, would like to bring this to attention; wire connectors (and wires) missing on both driver and passenger doors? Not sure if this was a factory oversight, or an error in original wiring diagram of Toyota? If so, there could be other wires missing in the vehicle as well. Hopefully Toyota will look into this and propose a fix for their customers. Thank you

Hood on 2025 Toyota Grand Highlander vibrates/flutters due to poorly designed aluminum construction. Very distracting and causes drivers to take eyes off the road. Toyota has issued T-SB-0111-24 for the 2024 Grand Highlander for this specific issue but my dealership told me that it doesn't apply to the 2025 but the hood part number is the same for both years. The constant vibration could eventually "work harden" the thin metal and ultimatlly allow the hood to break off the vehicle. Check out the old Jimmy Stewart movie when the constant vibration made the tail break off the airplane.

I am submitting this complaint regarding a serious safety hazard and design flaw with the 2025 Toyota Grand Highlander Hybrid. While driving on a two-lane highway, our vehicle suddenly lost power and warning lights appeared on the dashboard. We were forced to exit the highway immediately (we were less than 0.5 miles to an exit). Shortly after pulling onto the off-ramp, the vehicle entered limp mode, significantly limiting its ability to function - all assist systems deactivated amd the car has a significant decrease in power. We were able to drive approximately half a mile to a nearby gas station, where we called for a tow. This situation left us vulnerable on a busy roadway, placing both us and other drivers at risk. The Toyota dealership diagnosed the issue as damage to the hybrid inverter radiator, allegedly caused by a rock or piece of debris entering through the front grille. We were told this was not covered under warranty, and to make matters worse, the necessary part is currently on backorder for three weeks to three months—leaving the vehicle undriveable. A significant concern is the design of the front grille, which has large, open gaps that allow ordinary road debris to enter the engine compartment. This leaves critical components like the hybrid inverter radiator exposed and vulnerable, even under standard driving conditions. After researching, I discovered numerous similar reports from other Toyota hybrid owners—including those with Grand Highlanders, Highlander Hybrids, RAV4 Hybrids, and Prius models—who have experienced the exact same issue. In nearly every case, drivers were told it was due to external damage and denied warranty coverage. This presents a clear and growing safety issue: 1. Sudden power loss on a highway or arterial road increases the risk of collision. 2. A critical hybrid system component is inadequately

When going over rough or uneven roads, the car produces a strong low-frequency resonance, like a bass-heavy "boom". This causes a very uncomfortable feeling of pressure changing in my ears, gives me a headache and ear pain whenever I drive in local roads, which is the majority of driving in my area. This causes me to need to pull over and stop the car frequently to readjust my hearing. I've found many reports from others of the same issue but Toyota have not acknowledged it or found a solution.

The contact owns a 2025 Toyota Grand Highlander. The contact stated while reversing, the back over prevention system failed to function as intended. The contact stated that the image was visible; however, there was no tone alert. Additionally, there was a message indicating that the Adaptive Cruise Control was unavailable and to see the dealer. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the automatic braking system had independently activated. The contact stated that the failure had occurred several times. The contact stated that the instrument cluster was replaced two weeks prior to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.