2025 Toyota Grand Highlander

Shortly after powering on the GHHM vehicle, driving a short distance, coming to a stop and depressing the accelerator the vehicle does not accelerate as though no power is getting to the drive train. This does not often happen but has always happened when the EV battery level is 3 bars or less and the vehicle is in its Normal mode (as opposed to Sport or ECO). This acceleration failure event lasts for a few seconds. No warning indicators are displayed prior to, during or after this happens. The dealer checked the vehicle on 30AUG2025, was not able to reproduce, but applied a firmware update TSB-0040-25, which has not solved the problem. Took it back to dealer on 14OCT2025, but the dealer was again not able to reproduce the problem. It poses a safety risk when attempting to cross intersections or entering round-abouts and the vehicle can only move at a coasting speed instead of the expected normal acceleration.

I have experienced intermittent transmission issues. Specifically, the car often fails to shift gracefully from first gear, resulting in rough or hard shifts that are jarring and unsafe, particularly during acceleration or in stop-and-go traffic. On multiple occasions, the vehicle has refused to shift correctly, requiring me to pull over, turn the car completely off, and restart it to restore proper shifting functionality. This issue is not only inconvenient but also poses a significant safety risk, especially when merging into traffic or navigating busy roads. For a vehicle marketed as a reliable and family-friendly SUV, these transmission problems are unacceptable. The transmission issues have significantly undermined my confidence in the vehicle’s safety and reliability, particularly as I rely on it for family transportation. The need to pull over and restart the car to address shifting problems is not only inconvenient but also dangerous in certain driving conditions. Furthermore, the reports of similar issues among other owners indicate that these problems may persist without proper intervention from Toyota.

The vehicle was in PARK and the IGN was in the ON/RUN position and the air conditioning was on. There was no one in the driver's seat but there was an occupant sitting buckled in the front passenger seat. The passenger heard a sound (possibly the ICE turning on) and he felt the vehicle move forward about five inches. He became worried about his safety and pressed the IGN button in order to turn the vehicle off. It could have pushed itself into other cars in the parking lot or pedestrians. A report was made to the local police department on the same day. This occurred in a retail parking lot. Video footage cannot be obtained as a police officer or insurance company must request it. I have not seen a check engine light nor any message prompts and it has not been inspected by a dealership.

I am submitting this complaint regarding a serious safety hazard and design flaw with the 2025 Toyota Grand Highlander Hybrid. While driving on a two-lane highway, our vehicle suddenly lost power and warning lights appeared on the dashboard. We were forced to exit the highway immediately (we were less than 0.5 miles to an exit). Shortly after pulling onto the off-ramp, the vehicle entered limp mode, significantly limiting its ability to function - all assist systems deactivated amd the car has a significant decrease in power. We were able to drive approximately half a mile to a nearby gas station, where we called for a tow. This situation left us vulnerable on a busy roadway, placing both us and other drivers at risk. The Toyota dealership diagnosed the issue as damage to the hybrid inverter radiator, allegedly caused by a rock or piece of debris entering through the front grille. We were told this was not covered under warranty, and to make matters worse, the necessary part is currently on backorder for three weeks to three months—leaving the vehicle undriveable. A significant concern is the design of the front grille, which has large, open gaps that allow ordinary road debris to enter the engine compartment. This leaves critical components like the hybrid inverter radiator exposed and vulnerable, even under standard driving conditions. After researching, I discovered numerous similar reports from other Toyota hybrid owners—including those with Grand Highlanders, Highlander Hybrids, RAV4 Hybrids, and Prius models—who have experienced the exact same issue. In nearly every case, drivers were told it was due to external damage and denied warranty coverage. This presents a clear and growing safety issue: 1. Sudden power loss on a highway or arterial road increases the risk of collision. 2. A critical hybrid system component is inadequately