2007 Toyota Fj Cruiser

TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHEN THE VEHICLE STOPPED THE ANTI LOCK AND TRACTION CONTROL LIGHTS BEGAN ILLUMINATING ON THE DASHBOARD. WHILE EXAMINING THE VEHICLE HE NOTICED THAT THE FRONT DRIVERS SIDE WHEEL SPEED SENSOR WAS BROKEN. HE ATTEMPTED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER BUT THE VEHICLE WOULD NOT ACCELERATE BECAUSE THE WHEELS WERE LOCKED. WHILE TOWING THE VEHICLE A LOUD POPPING NOISE WAS HEARD AND ALL OF THE WHEELS EXCEPT THE FRONT DRIVERS SIDE WHEELS BEGAN TO TURN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE SPEED SENSOR WIRE WAS REPLACED. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 02/02/11 *CN

SUMMARY: THE PRIMARY SAFETY SYSTEM (BRAKES) IN MY 2007 TOYOTA FJ CRUISER FAILED TWICE. THE LOCAL TOYOTA DEALERSHIP UTILIZING TOYOTA NATIONAL RESOURCES WERE UNABLE TO ISOLATE THE PROBLEM. THE SOLUTION WAS TO COMPLETELY REPLACE BRAKE SYSTEM AND CHARGE IT TO ME. THE LACK OF AVAILABILITY OF PARTS NATIONALLY (BACKORDER) RESULTED IN A COMPLETELY UNREASONABLE REPAIR TIMEFRAME. THE VEHICLE WAS OUT OF SERVICE FOR 49 DAYS AND COST $2503.99 TO REPAIR. OCTOBER 1, 2010 DRIVING IN TRAFFIC DEPRESS BRAKE. THE PEDAL GOES COMPLETELY TO FLOOR BOARD. NO INDICATION OF PROBLEMS VIA INTERIOR WARNING LIGHTS. OCTOBER 6, 2010 PROBLEM DETERMINED TO BE BRAKE MASTER CYLINDER. PART ORDERED (47025-35111 CYLINDER SUB-ASSEMBLY) THROUGH INTERNET SITE OF LAKELAND TOYOTA IN FLORIDA. THE COST OF THE PART IS $981.37 AND THE PART IS ON BACKORDER. ESTIMATED DELIVER IS 10/26/10. OCTOBER 26, 2010 PART ARRIVES AND IS INSTALLED. MULTIPLE WARNING LIGHTS ARE INDICATED ON INTERIOR DISPLAY. NOVEMBER 1, 2010 TOYOTA DEALERSHIP DETERMINES THE NEW MASTER CYLINDER ASSEMBLIES COMPUTER IS DEFECTIVE. NOVEMBER 4, 2010 TOYOTA DEALERSHIP REPLACES NEW MASTER CYLINDER COMPUTER WITH MY OLD COMPUTER. THE RESULT IS THE WARNING LIGHTS TURNING OFF AND INDICATES THE PROBLEM HAS BEEN FIXED. THE MECHANIC TAKE THE VEHICLE ON A TEST DRIVE ACTIVATES THE ANTILOCK BRAKES WHICH RESULTS IN AN UNEXPECTED LOSS OF VEHICLE CONTROL. THE SERVICE MANAGER REFUSES TO RETURN THE VEHICLE CLAIMING IT IS UNSAFE TO DRIVE. NO WARNING LIGHTS ARE INDICATED ON THE VEHICLE. NOVEMBER 10, 2010 TOYOTA DEALERSHIP DETERMINED THAT THE MASTER CYLINDER WITHIN THE NEW MASTER CYLINDER ASSEMBLIES IS FAULTY. BRAKE SOLENOID COMPONENTS ARE ALSO DETERMINED TO BE FAULTY AND A CONTRIBUTING FACTOR IN THE LOSS OF VEHICLE CONTROL. TOYOTA RECOMMENDS THAT COMPLETE BRAKE ASSEMBLY (47050-35072 $1823.87) BE REPLACED. THIS IS VIRTUALLY THE ENTIRE BRAKE SYSTEM OF THE VEHICLE. THIS ASSEMBLY IS ON BACKORDER AS WELL. NOVEMBER 18, 2010 VEHICLE REPAIRED AND RETURNED. *TR

1. I WAS DRIVING HOME FROM WORK AND WAS ON THE HIGHWAY. THE CARS IN FRONT OF ME CAME TO AN ABRUPT STOP, CAUSING ME TO SLAM MY BREAKS WHILE I WAS DOING 40-ISH. 2. THIS CAUSED THE CAR TO BAKE STUMBLE AS THE BREAKS SLOWED THE CAR, THEN CAME LOSE CAUSING THE CAR TO LUNGE FORWARD, THEN MOMENTARILY BRAKE, THEN LOSE BRAKING AGAIN. THIS CAUSED ME TO ALMOST SLAM IN TO THE CAR IN FRONT OF ME. 3. I HAVE NOT TAKEN CORRECTIVE ACTION AS THIS SHOULD ADDRESSED BY TOYOTA AS THERE ARE MANY MANY PEOPLE DESCRIBING THE SAME ISSUE. *TR

AFTER A "PANIC STOP" IN MY 2007 TOYOTA FJ CRUISER, THE BRAKE MASTER CYLINDER FAILED. WHEN AT A STOP LIGHT, THE BRAKES WILL SLOWLY FADE UNTIL THE PEDAL IS ON THE FLOOR AND THE TRUCK WILL ROLL FORWARD. THIS IS NOT COVERED UNDER WARRANTY AND I WILL HAVE TO PAY TO REPLACE IT. THIS IS HAS OCCURRED WITH OTHER PEOPLE AND IS DOCUMENTED ON FJCRUISERFORUMS.COM. *TR

THIS IS A TOYOTA ECM COMPUTER ELECTRICAL MALFUNCTION. I WAS WAITING IN MY 2007 TOYOTA FJ CRUISER AT A TRAFFIC STOP FOR THE LIGHT TO CHANGE FROM RED TO GREEN. AT THIS TIME, I FELT A HARD "BUMP" AS IF ANOTHER CAR HAD REAR-ENDED MY FJ. THERE WAS THIS REAL HARD "THUMP." THE FJ HAD SHIFTED GEARS ON ITS OWN WHILE AT A COMPLETE STOP. EITHER THE TRANSFER CASE DIFFERENTIAL AND/OR THE ELECTRICAL REAR DIFFERENTIAL LOCKED UP. BOTH MY HANDS WERE ON THE STEERING WHEEL AND MY RIGHT FOOT WAS ON THE BRAKE AT THE TIME. THERE IS NO DRIVER'S SIDE FLOOR MAT. THE FJ GOT A STRONG GRIP ON THE ROAD AND IT LURCHED FORWARD. THERE WAS A LOT OF EXTRA POWER AND A LOT MORE TRACTION THAN IN THE NORMAL "D" MODE FOR DRIVING ON DRY PAVEMENT. INSTINCTIVELY, I PRESSED DOWN HARDER ON THE BRAKE IN ORDER TO KEEP THE FJ FROM MOVING INTO THE INTERSECTION. TWO SECONDS LATER, THERE WAS ANOTHER "THUMP" AND THE FJ SHIFTED BACK INTO THE NORMAL ROAD GEAR "D." I BELIEVE WHAT HAPPENED IS THAT THE ECM COMPUTER SENT A MALFUNCTIONING SIGNAL AND LOCKED UP ONE OR BOTH OF THE DIFFERENTIALS. THIS HAPPENED WITH AN AUTOMATIC TRANSMISSION ON DRY PAVEMENT AND STOP WHEN THERE WAS NO DRIVER COMMAND TO SHIFT GEARS. THE SENSATION I FELT IS SIMILAR TO USING MY FJ FOR OFF-ROAD DRIVING AND SHIFTING INTO 4WD "LOW," BUT THIS WAS MUCH MORE SEVERE. MY CONCERN IS THAT THE ECM COMPUTER MIGHT MALFUNCTION HIGHWAY SPEEDS OF 70 MPH. IT COULD SEND A SIMILAR COMMAND TO LOCK UP EITHER THE TRANSFER CASE DIFFERENTIAL OR ELECTRIC REAR DIFFERENTIAL. IF THIS HAPPENS, THE FJ BECOMES A 5,000 LB. FLYING MISSILE, BASICALLY OUT OF CONTROL. I WOULD NOT BE ABLE TO STEER THE FJ OR TO NAVIGATE TURNS PROPERLY. IT WOULD BECOME A DANGER NOT ONLY TO MYSELF, BUT TO ALL OTHER CARS IN THE IMMEDIATE VICINITY. THIS IS THE FIRST TIME IT HAPPENED. SOMETHING IS DANGEROUSLY WRONG WITH TOYOTA'S ECM COMPUTER SYSTEM IN THE FJ CRUISER. *TR

I HAVE DISCOVERED BULGING AND CRACKING ISSUES IN THE ENGINE BAY INNER FENDER APRONS AT THE LOCATION OF THE CRUMPLE SAFETY ZONES. TOYOTA DEALER AND CUSTOMER SERVICE PERSONNEL ARE AWARE OF THE ISSUE BUT WILL NOT ESCALATE MY COMPLAINT OR ALLOW ME TO SPEAK WITH A SUPERVISOR. FURTHER INVESTIGATION SHOWS THAT THERE IS A HIGH AMOUNT OF OWNERS EXPERIENCING SOME BULGING AND CRACKING ISSUES WITH 2007 AND SOME EARLY 2008 MODELS. THE BULGES AND CRACKS IN THE INNER FENDERS SEEM TO BE ATTRIBUTED TO A TOYOTA DESIGN FLAW THROUGH CERTAIN VIN NUMBERS. SOME SPECULATION WAS MADE THAT AFTERMARKET STEEL BUMPERS HAD PUT EXTRA WEIGHT AND STRESS ON THE FENDERS, CAUSING THEM TO CRACK, BUT HUNDREDS OF FJ'S EQUIPPED WITH AFTERMARKET BUMPERS SUFFERED NO DAMAGE. IT IS RUMORED THAT TOYOTA ADDRESSED THE PROBLEM IN MOST 2008 MODELS BY BOXING THE INNER FENDER AND ADDING A THIRD LAYER OF METAL AND A NEW BOLT INSIDE THE FENDER. THIS IS A HUGE SAFETY CONCERN AS IT NEGATES THE ABSORPTIVE PROPERTIES OF THE FRONTAL CRUMPLE ZONE, IN ADDITION TO THE OBVIOUS STRUCTURAL PROBLEMS. *TR

THIS IS A COMMON PROBLEM BEING REPORTED ON TOYOTA BASED FORUMS. WHEN YOU APPLY THE BRAKES AND ONLY ONE SIDE (LEFT OR RIGHT) OF THE VEHICLE IS OVER SOME ROUGH TERRAIN, THE BRAKES RELEASE EVEN WITH THE BRAKE CONTINUALLY BEING PRESSED. IT LEAVES THE VEHICLE ROLLING INSTEAD OF STOPPING UNTIL YOU HIT THE BRAKES AGAIN. SOME PEOPLE HAVE CLAIMED IT WILL ENGAGE AGAIN IF KEEPING IT DEPRESSED, BUT ONLY AFTER MORE THAN A SECOND HAS PAST. I CAN RECREATE THIS ACTION TIME AND TIME AGAIN WITH THE SAME FAILURE HAPPENING EVERY TIME. *TR

WHILE TRAVELING IN THE FAR RIGHT HAND LANE, IN A WORK ZONE AT DESIGNATED SPEEDS AS CONTROLLED BY ROAD WORKERS. THE VEHICLE IN FRONT OF ME APPLIED BRAKES CAUSING ME TO DUE THE SAME. MY BRAKES INITIALLY GRABBED MOMENTARILY AND THEN RELEASED UNEXPECTEDLY, WHILE I WAS STILL APPLYING THE BRAKES. I JAMMED ON THE BRAKES THE TIRES LOCKED UP AND NOSE DIVED VIOLENTLY.....BARELY AVOIDING AN ACCIDENT. OBVIOUS SIGNIFICANT BRAKE SYSTEM FAILURE. *TR

TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHEN COMING TO STOP THE CONTACT DROVE OVER A POT HOLE AND WHEN APPLYING THE BRAKES THE VEHICLE DID NOT STOP AND BEGAN TO LUNGE FORWARD. THE BRAKE PEDAL EXTENDED TO THE FLOOR AND THE CONTACT HAD TO RELEASE HER FOOT SO THAT THE PEDAL WILL RELEASE; OTHERWISE, SHE HAD TO PULL IT UP MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE AND THEY COULD NOT DUPLICATE THE PROBLEM. THE FAILURE OCCURRED FIVE ADDITIONAL TIMES AND WAS TAKEN TO THE DEALER FIVE TIMES AS WELL. THE CONTACT REPLACED THE BRAKE PAD AND ROTORS WHICH DID NOT RESOLVE THE FAILURE. THE FAILURE MILEAGE WAS 29000 AND THE CURRENT MILEAGE WAS 75000.

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT WAS DRIVING IN SNOWY WEATHER AND APPROACHING A TRAFFIC STOP. HE PROCEEDED TO MAKE A LEFT TURN WHEN ANOTHER VEHICLE CAME THROUGH THE INTERSECTION AND CRASHED INTO THE SIDE OF THE CONTACT'S VEHICLE. THE CONTACT'S VEHICLE WAS PUSHED SEVERAL FEET DOWN THE STREET AND INTO THE CURB. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO HIS NECK AND SPINE. THE VEHICLE WAS ABLE TO BE DRIVEN AFTER THE ACCIDENT. THE INSURANCE COMPANY STATED THE AIR BAGS DID NOT DEPLOY, BECAUSE THE SIDE STEP ON THE VEHICLE TOOK THE BRUNT OF THE COLLISION. UPDATED 01/31/11/ *BF UPDATED 03/24/11 STATUS UPDATE. UPDATED EVOQ 04/19/11