Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1460–25K
6525–50K
5150–75K
4975–100K
76100–150K
55150K+
442 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports5 fire reports8 injury reports
What owners actually said
593 reports
115,000 miles · Jan 27, 2020
Structure
MY FJ CRUISER FRAME IS ROTTING FROM THE INSIDE OUT, THE GAS TANK MOUNTING STRAP HAS BROKEN AND DUE TO FRAME RUST, THE MOUNTING POINT HAS FAILED AND BROKEN OFF THE FRAME. THE REAR BODY MOUNTS ARE DETERIORATING AS IS THE REAR FRAME CROSS MEMBERS. DUE TO THE FRAME RUAT AND GAS STRAP MOUNTING POINT FAILING, THE DEALER CANNOT RE…
Read full complaint
MY FJ CRUISER FRAME IS ROTTING FROM THE INSIDE OUT, THE GAS TANK MOUNTING STRAP HAS BROKEN AND DUE TO FRAME RUST, THE MOUNTING POINT HAS FAILED AND BROKEN OFF THE FRAME. THE REAR BODY MOUNTS ARE DETERIORATING AS IS THE REAR FRAME CROSS MEMBERS. DUE TO THE FRAME RUAT AND GAS STRAP MOUNTING POINT FAILING, THE DEALER CANNOT REPAIR. THIS IS A SAFETY ISSUE AS THE GAS TANK CANNOT BE CORRECTLY MOUNTED. OF THE 2ND GAS TANK STRAP FAILS, THE GAS TANK MAY FALL OUT. I HAVE SEEN SEVERAL BODYSHOPS THAT ARE SURPRISED AT THE AGE OF THE VEHICLE AND THE AMOUNT OF FRAME ROT PRESENT.
NHTSA ODI #11302386
Mileage unknown · Jan 26, 2020
Suspension
MY TRUCK HAS MODERATE RUST THAT IM CONCERNED WILL TURN INTO STRUCTURAL FAILURES AFTER SEEING THE FRAMES ON THE FJ CRUISER RUSTED FRAME OWNERS UNITE SITE. THIS TRUCK IS FROM TEXAS AND IS RELOCATED TO CHICAGO AND THE RUST IS ACCELERATING AT AN ALARMING RATE WITH THE SALT. HTTPS://WWW.FLICKR.COM/PEOPLE/186600547@N07/
NHTSA ODI #11302129
Mileage unknown · Jan 26, 2020
Fuel/propulsion System
FUEL STRAPS RUSTED OUT WHILE IN MOTION ON A CITY STREET AND FUEL TANK FELL DOWN. HAD TO GET TRUCK TOWED AND FIXED.
NHTSA ODI #11302125
53,000 miles · Jan 26, 2020
Structure
SEVERE RUSTING ON THE FRAME. VEHICLE FEELS VERY LOOSE WHILE DRIVING OR HITTING A BUMB AS RUST PROGRESSES.
NHTSA ODI #11302074
180,000 miles · Jan 26, 2020
Unknown Or Other
STRUCTURAL FRAME RUST OVER THE ENTIRE FRAME AND FUEL TANK STRAPS.
NHTSA ODI #11301970
165,500 miles · Jan 26, 2020
Unknown Or Other
FUEL TANK STRAP RUST. I NOTICED MY FUEL TANK HANGING LOW ONE DAY. TURNS OUT A FUEL TANK STRAP HAD RUSTED IN TWO. I HAD SOMEONE WELD THE STRAP BACK TOGETHER TO HOLD MY FUEL TANK IN PLACE. VEHICLE WAS STATIONARY WHEN NOTICED. IN THE ATTACHED PICTURE YOU CAN SEE THE WELD REPAIR THAT IS NOW HOLDING THE FUEL TANK IN PLACE.
NHTSA ODI #11301913
165,000 miles · Jan 26, 2020
Unknown Or Other
STRUCTURAL FRAME RUST. THE FRAME IS VERY RUSTY AND THIN WITH LOTS OF HOLES IN IT. I FEAR FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS. THE REAR CROSS MEMBER IS EXTREMELY RUSTED AND WOULD NOT HOLD IN A REAR END COLLISION. IN THIS PARTICULAR INCIDENT THE DRIVER'S SIDE REAR LOWER CONTROL ARM BROKE FREE WHILE DRIVING AT 55MPH AN…
Read full complaint
STRUCTURAL FRAME RUST. THE FRAME IS VERY RUSTY AND THIN WITH LOTS OF HOLES IN IT. I FEAR FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS. THE REAR CROSS MEMBER IS EXTREMELY RUSTED AND WOULD NOT HOLD IN A REAR END COLLISION. IN THIS PARTICULAR INCIDENT THE DRIVER'S SIDE REAR LOWER CONTROL ARM BROKE FREE WHILE DRIVING AT 55MPH AND SENT THE TRUCK OUT OF CONTROL IN TO THE NEXT LANE.LUCKILY NO ONE WAS INJURED AND SLOWING DOWN KEPT IT UNDER CONTROL. THIS WAS ON A SMALL HIGHWAY WHILE SLIGHTLY TURNING LEFT.
NHTSA ODI #11301912
160,000 miles · Jan 26, 2020
Fuel/propulsion SystemSuspension
FUEL TANK SUPPORT STRAPS RUSTING OUT.. ALSO FRAME RUSTING ALL OVER. REAR SUPPORT LINKS CONNECTIONS ON THE FRAME ARE RUSTING OUT.
NHTSA ODI #11301903
Mileage unknown · Jan 25, 2020
Unknown Or Other
MY FRAM IS COMPLETELY RUSTED OUT I HAVE NEVER HAD A CAR WITH THIS PROBLEM
NHTSA ODI #11301862
98,432 miles · Jan 25, 2020
Structure
FRAME IS SEVERELY RUSTED, HAS CRACKS & CORROSION, & IS UNSAFE TO DRIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Consequence & remedy
Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Toyota Fj Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration