Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1460–25K
6525–50K
5150–75K
4975–100K
76100–150K
55150K+
442 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports5 fire reports8 injury reports
What owners actually said
593 reports
71,000 miles · Dec 29, 2020
SteeringSuspensionUnknown Or Other
SEVERE SUSPENSION BRACKET RUST ON MULTIPLE REAR AND FRONT COMPONENTS. I LUCKILY WAS ABLE TO AVOID AN ACCIDENT WHEN BRAKING BUT MY ENTIRE CAR SWAYED WHEN THE REAR LATERAL SUPPORT BAR BRACKET BROKE RIGHT OFF THE MOUNT THAT IS WELDED TO THE REAR DUE TO RUST. I THEN INSPECTED AND FOUND MULTIPLE RUST AREAS ON FRAME AND OTHER SUSPENSI…
Read full complaint
SEVERE SUSPENSION BRACKET RUST ON MULTIPLE REAR AND FRONT COMPONENTS. I LUCKILY WAS ABLE TO AVOID AN ACCIDENT WHEN BRAKING BUT MY ENTIRE CAR SWAYED WHEN THE REAR LATERAL SUPPORT BAR BRACKET BROKE RIGHT OFF THE MOUNT THAT IS WELDED TO THE REAR DUE TO RUST. I THEN INSPECTED AND FOUND MULTIPLE RUST AREAS ON FRAME AND OTHER SUSPENSION BRACKETS. MAKING THIS VEHICLE UNSAFE TO DRIVE. I AM AWARE OF TOYOTA'S ONGOING DILEMMA WITH USING THIS HORRIBLE UNTREATED STEEL AND HOPE THE NHTSA ADDRESSES THIS ISSUE. THIS IS NOT NORMAL CORROSION THIS IS AN ABSOLUTE NEGLECT IN SAFETY BY NOT HAVING THIS STEEL TREATED ON SUCH CRITICAL COMPONENTS OF A VEHICLES FRAME. HAD THIS INCIDENT HAPPEN ON THE HIGHWAY AT SPEEDS OF 55 MPH OR GREATER. SERIOUS INJURY AND/OR DEATH CAN OCCUR. IF I AM NOT THE ONLY CONSUMER HAVING THIS ISSUE ON TOYOTA FJ CRUSIER VEHICLES. I HOPE THE NHTSA ENFORCES A RECAL ON THESE FRAMES AND/OR CRITICAL SUSPENSION COMPONENTS. MY VEHICLE IS 16 YEARS OLD, I PURCHASED IT FROM A DEALER WHOM RECIEVED IT FROM THE ORIGINAL OWNER WITH 57,000 MILES ON IT. NOW CURRENTLY AFTER 4 YEARS OF OWNING THIS FJ CRUISER I ONLY HAVE 71,000 MILES ON IT. HAD THIS BRACKET CAUGHT ONTO MY BRAKE LINES WHICH IS LOCATED DIRECTLY BELOW THIS REAR BRACKET I WOULD HAVE LOST ALL ABILITY TO STOP MY VEHICLE.
NHTSA ODI #11385464
97,000 miles · Dec 25, 2020
Structure
UNDER CARRIAGE, IS RUSTING AWAY ! VEHICLE, ONLY HAS 97,000 MILES ON IT. MECHANIC, SAID THE VEHICLE IS FALLING APART, WITH RUST...
NHTSA ODI #11384923
133,355 miles · Dec 18, 2020
StructureSuspension
MY SON WAS DRIVING HOME FROM SCHOOL WHEN HE HEARD A RATTLE/BANG WHEN HE TOOK A CORNER OR WENT OVER A BUMP. HE TOLD ME ABOUT THE NOISE AS SOON AS HE GOT HOME. WE TOOK THE FJ OUT FOR A DRIVE AND I HEARD THE NOISE COMING FROM THE DRIVER'S SIDE. UPON INSPECTING THE EXTERIOR DRIVERS SIDE I FOUND THAT THE LEFT SIDE, REAR TRAILI…
Read full complaint
MY SON WAS DRIVING HOME FROM SCHOOL WHEN HE HEARD A RATTLE/BANG WHEN HE TOOK A CORNER OR WENT OVER A BUMP. HE TOLD ME ABOUT THE NOISE AS SOON AS HE GOT HOME. WE TOOK THE FJ OUT FOR A DRIVE AND I HEARD THE NOISE COMING FROM THE DRIVER'S SIDE. UPON INSPECTING THE EXTERIOR DRIVERS SIDE I FOUND THAT THE LEFT SIDE, REAR TRAILING ARM MOUNTING POINT AND A SECTION OF THE FJ'S FRAME, HAD TORN AWAY FROM THE FRAME. THE TRAILING ARMS WAS NOT FLOATING, UNATTACHED. WE ARE VERY LUCK THAT THE TRAILING DID NOT DROP WHILE MY SON WAS DRIVING HOME, AS IT WOULD HAVE BEEN DRIVEN INTO THE PAVEMENT, POSSIBLY CAUSING A CATASTROPHIC ACCIDENT. I HAVE CALLED TOYOTA CORPORATE, WHO CAN PROVIDE NOT SOLUTION ON HOW TO REPAIR THIS ISSUE. AGAIN, I AM LUCKY MY SON WAS ON SECONDARY ROADS AND NOT THE HIGHWAY AND THE TRAILING ARM FELL TO THE PAVEMENT.
NHTSA ODI #11384039
12,300 miles · Dec 17, 2020
Electrical SystemSeats
DRIVER SEAT AND PASSENGER SEAT HEATING UNIT IS COMING ON WITHOUT THE SWITCH TURNED ON.
NHTSA ODI #11383872
187,000 miles · Dec 4, 2020
Structure
UPON STATE INSPECTION, SEVERE RUST AND CORROSION WAS DISCOVERED ON THE FRAME. NOT ONLY DID IT FAIL INSPECTION, MY MECHANIC STRONGLY URGED ME NOT TO DRIVE IT, AS THE REAR AXLE HAS A POSSIBILITY OF FALLING OUT.
NHTSA ODI #11377887
Mileage unknown · Nov 20, 2020
Structure
TOYOTA'S HAVE BEEN HAVING RUST ISSUES WITH FRAMES. A GOVERNMENT MANDATED FIX FOR TUNDRAS AND TACOMAS HAVE BEEN APPROVED, BUT NOT FOR FJ CRUISERS, EVEN THOUGH IT'S A SIMILAR MODEL. I NEED TO HAVE MY FRAME RUST ISSUES FIXED IN ORDER TO PASS INSPECTION.
NHTSA ODI #11375637
71,000 miles · Nov 17, 2020
Fuel System, GasolineStructure
TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR TIRE REPAIRS AND THE MECHANIC FOUND THAT THE FUEL TANK STRAPS WERE SEVERELY CORRODED AND THE SUBFRAME WAS ALSO SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR TIRE REPAIRS AND THE MECHANIC FOUND THAT THE FUEL TANK STRAPS WERE SEVERELY CORRODED AND THE SUBFRAME WAS ALSO SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.*DT THE CONSUMER PROVIDED PHOTOS. *TR
NHTSA ODI #11375059
75,000 miles · Nov 17, 2020
Power TrainService BrakesSuspension
SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DU…
Read full complaint
SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DUE TO RUST. ENTIRE FRAME AND ENGINE COMPARTMENT COVERED IN RUST. ALL THESE ITEMS HAVE CAUSED MULTIPLE SAFETY ISSUES. MULTIPLE STRAPS AND CONNECTIONS FOR VARIOUS COMPONENTS ARE NO LONGER USABLE DUE TO RUST.
NHTSA ODI #11375036
Mileage unknown · Nov 17, 2020
SteeringSuspensionUnknown Or Other
GAS TANK STRAPS BROKE FRAME DETERIATED ON FJ CRUSIER WITH ONLY 72000 MILES ON IT WOULD HAVE NEVER KNOWN HOW UNSAFE FRAME IS IF STRAPS GAS TANK HANGING
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Consequence & remedy
Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Toyota Fj Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration